Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 48TA ELIMINATOR II ENGINE DEGREASER 15OZ AEROSOL
Item No: 80043
Product Type: Aerosol cleaner
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
DISTILLATES (PETROLEUM), 30-60 Not Listed 100 ppm TWA
HYDROTREATED LIGHT
64742-47-8
500 ppm TWA; 1188 mg/m3 TWA 1000 ppm TWA; 2400 mg/m3 TWA
ACETONE 15-40
67-64-1
25 ppm TWA; 240 mg/m3 TWA
2-BUTOXYETHANOL 5-15 20 ppm TWA
111-76-2
CARBON DIOXIDE 1-10 5000 ppm TWA 5000 ppm TWA
124-38-9
3. HAZARDS IDENTIFICATION
Exposure to vapors or mist may result in irritation of the respiratory tract. Intentional misuse by
Toxicity:
concentrating and inhaling the vapor may be harmful or fatal. Harmful if swallowed. May cause eye
and skin irritation. Prolonged exposure may cause liver and kidney effects and may affect the central
nervous system. Aspiration hazard if swallowed.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Excessive accidental exposure may cause headache, dizziness, nausea and mild respiratory irritation.
May cause pain, redness or swelling of the eyes and excessive blinking and tear production. Skin:
Exposure may cause mild skin irritation. Prolonged or repeated exposure may dry the skin. Symptoms
may include redness, burning, drying, cracking and skin burns. Preexisting skin disorders may be
aggravated by exposure. Skin absorption is possible, but harmful effects are not expected from this
route under normal conditions of handling and use. Swallowing: This material can enter the lungs
during swallowing or vomiting and cause lung inflammation and/or damage. Aspiration into the lungs
can cause chemical pneumonia which can be fatal.
Ingredients Percent NTP: ACGIH IARC:
Carcinogens
ACETONE 15-40 Not known A4 - Not Classifiable Not known
67-64-1 as a Human
Carcinogen
2-BUTOXYETHANOL 5-15 male rat-no evidence; A3 Group 3; Vol.88, 2004
111-76-2 female rat-equivocal
evidence; male mice-
some evidence;
female mice-some
evidence
Medical Conditions Recognized as Persons with preexisting respiratory, liver, kidney, eye or skin diseases may be adversely affected.
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention..
Ingestion:
Move to fresh air in case of accidental inhalation of vapors. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes If
Skin Contact:
skin irritation persists, call a physician
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
<0 degrees F.
Flash Point (癋/C):
1 of 3
Product name: 48TA ELIMINATOR II ENGINE Item 80043
DEGREASER 15OZ AEROSOL
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Keep
Special Fire-Fighting Procedures:
containers cool. Use equipment or shielding required to protect against
bursting or venting of containers. Water spray may be ineffective on
flames but should be used to keep fire-exposed containers cool.
Oxides of carbon.
Hazardous Products Formed by Fire or Thermal
Decomposition:
Contents under pressure. Exposure to temperatures over 120 degrees F.
Unusual Fire/Explosion Hazards:
may cause bursting or venting. Keep containers cool. Use equipment or
shielding to protect personnel from bursting containers.
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a
Spill Procedures:
closed waste container until disposal.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F. Do
Storage:
not puncture or burn container.
Avoid contact with skin and eyes. Do not inhale vapors. Do not use near heat, sparks or open flame.
Handling:
Intentionally concentrating and inhaling the vapor may be harmful or fatal. Wash hands before eating
and smoking.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits..
9. PHYSICAL AND CHEMICAL PROPERTIES
Clear liquid
Appearance:
SOLVENT
Odor:
>200 degrees F.
Boiling Point (癋):
Does not apply
pH:
Insoluble
Solubility in Water:
0.76-0.86 g/ml
Specific Gravity:
22% by weight
VOC Content(Wt.%):
72-78 psig
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Strong oxidizers.
Incompatabilities:
Keep away from heat, sparks and open flame.
Conditions to Avoid:
Oxides of carbon.
Hazardous Products Formed by Fire or Thermal
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations. This container may
be recycled in aerosol recycling centers. Before offering for recycling, empty the can by using the
product according to the label. If recycling is not available, wrap the container and discard in the trash.
2 of 3
Product name: 48TA ELIMINATOR II ENGINE Item 80043
DEGREASER 15OZ AEROSOL
D001 as per 40CFR 261.21
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
CONSUMER COMMODITY
DOT Shipping Name:
ORM-D
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Aerosols, flammable
Proper Shipping Name:
Class 2.1
Class or Division:
UN 1950
UN/NA Number:
IMDG
Aerosols, Limited Quantity
Proper Shipping:
Class 2.1
Hazard Class:
UN 1950
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
2-BUTOXYETHANOL
CALIFORNIA PROP 65:
WARNING: This product contains chemicals known to the State of California to cause cancer and birth defects or other
reproductive harm.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 4 , REACTIVITY 0
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 4, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 03/18/2005
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 1
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839
3 of 3
|