Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: COMPLIANT GUN - CLEANING SOLVENT HMIS CODES: H F R P
PRODUCT CODE: 7002 2*3 0
=================== SECTION I - MANUFACTURER IDENTIFICATION ===================
MANUFACTURER'S NAME: PACIFIC COAST LACQUER
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 8/22/2007
INFORMATION PHONE : (800) 672-4900 NAME OF PREPARER :
=========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ===========
VAPOR PRESSURE
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F)
-----------------------------------------------------------------------------------
ACETONE 67-64-1 185.5 68
OSHA PEL: 1000 ppm; 2,400 mg/m3
OSHA TWA: 750 ppm; 1,800 mg/m3
OSHA STEL: 1000 ppm; 2,400 mg/m3
ACGIH TWA: 500 ppm, STEL: 750 ppm
~ TOLUENE 108-88-3 21.8 68
OSHA PEL: 200 ppm, ACGIH TLV: 100 ppm
~ ISOPROPYL AL 67-63-0 32 68
OSHA PEL: 400 ppm, ACGIH TLV: 400 ppm
VM&P NAPHTHA,MEDIUM ALIPHATIC 64742-89-8 9.8 68
OSHA PEL: 300 ppm, ACGIH TLV: 300 ppm
~ XYLENE 1330-20-7 6.1 68
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
n-BUTYL ACETATE; BUTYL ETHANOATE 123-86-4 10 68
OSHA PEL: 150 ppm, ACGIH TLV: 150 ppm
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ==============
BOILING RANGE (Deg F): 133 - 285 DENSITY: 6.73 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): .81
MATERIAL V.O.C.: 2.8 lb/gl MATERIAL V.O.C.: 336 g/l
SOLUBILITY IN WATER: Soluble EVAPORATION RATE: SLOWER THAN ETHER
V.O.C. COMPOSITE VAPOR PRESSURE: 6.82 mm HG @68 Deg F
APPEARANCE AND ODOR: Water-white liquid with mild odor.
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ================
FLASH POINT(Deg F): 1 METHOD USED: TOC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: 1 UPPER: 12.8
EXTINGUISHING MEDIA: ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
MATERIAL SAFETY DATA SHEET
Page: 2
UNUSUAL FIRE AND EXPLOSION HAZARDS
Fire-exposed containers should be cooled with water to prevent pressure build-up
which could result in container rupture.
========================= SECTION V - REACTIVITY DATA =========================
STABILITY: STABLE
CONDITIONS TO AVOID
Avoid heat, sparks and open flame
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
===================== SECTION VI - HEALTH HAZARD DATA =========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Inhalation: May cause CNS depression.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin and eye contact: May cause irritation to both.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin absorption: May cause irritation.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Ingestion: May cause CNS depression.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause irritation to nose, eyes and skin. May also cause CNS (central
nervous system) depression which may be evidenced by giddiness, headache,
dizziness and nausea; in extreme cases, unconsciousness and death may occur.
Chronic: Prolonged or repeated contact may result in dermatitis and damage to
central nervous system, liver and kidneys.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: No
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS DIFFICULT.
MATERIAL SAFETY DATA SHEET
Page: 3
SPLASH (EYES): FLUSH EYES IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT LEAST
15 MINUTES. SPLASH (SKIN): WASH AFFECTED AREAS WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE
LUNGS. GET MEDICAL ATTENTION IMMEDIATELY.
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ==============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
REMOVE ALL SOURCES OF IGNITION AND PROVIDE VENTILATION. LARGE SPILLS MAY BE
PUMPED TO SALVAGE VESSELS. SMALL SPILLS MAY BE PICKED UP WITH AN ABSORBENT
MATERIAL.
WASTE DISPOSAL METHOD
Place in tightly closed containers and dispose of in accordance with local,
state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Keep away from heat, sparks and open flames. Keep containers closed when not in
use. Use with adequate ventilation.
OTHER PRECAUTIONS
Do not take internally. Ground equipment to prevent accumulation of static
charge. Do not cut, weld, drill or grind on or near containers.
====================== SECTION VIII - CONTROL MEASURES ========================
RESPIRATORY PROTECTION
Use self-contained breathing apparatus where vapor concentration may be above
TLV limits. Where vapor does not exceed TLV limits, use NIOSH/MSHA approved
respirator.
VENTILATION
Use explosion-proof ventilation as required to control vapor concentrations.
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Safety glasses, splash goggles or face shield . Contact lenses should not be
worn.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Safety showers and eyewash stations should be provided.
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
MATERIAL SAFETY DATA SHEET
Page: 4
===================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
This product contains a chemical known to the State of California to cause birth
defects or other reproductive harm.
Contains: Toluene -
========================== SECTION X - DISCLAIMER =============================
The information contained herein is based on the data available to us and is
believed to be correct. However, Pacific Coast Lacquer Co. makes no warranty
expressed or implied regarding the accuracy of these data or the results to be
obtained from the use thereof. Pacific Coast Lacquer Co. assumes no
responsibility for injury from the use of the product described herein.
|