MATERIAL SAFETY DATA SHEET
HARDCAST PRODUCTS
Business Hours 8:00 am - 5:00 pm FOR TRANSPORTATION EMERGENCIES
CARLISLE COATINGS AND WATERPROOFING, INC.
Emergency Telephone Number CALL CHEMTREC 800/424-9300
Subsidiary of Carlisle Corporation
972/442-6545
900 Hensley Lane Wylie, Texas 75098
SECTION I
PRODUCT NAME & SYNONYMS CHEMICAL FAMILY HMIS RATINGS
Sure Grip 404 Synthetic Rubber/Resin Mixture HEALTH 1
FLAMMABILITY 4
PRODUCT USE FORMULA
Solvent Based Duct Sealer Mixture REACTIVITY 0
SECTION IIA - HAZARDOUS INGREDIENTS
HAZARDOUS INGREDIENTS CAS # % OSHA Limits (ppm) Skin LD50 of Ingredient LC50 of Ingredient
TLV PEL Ceiling Designation mg/kg ppm/4H
Toluene 108-88-3 11-14 100 150 300 N/A oral-rat:5,000 mus:7,528
Heptane 142-82-5 23-27 400 500 None N/A ivn-mus:222 hmn:TCLo 1000 6M
Amorphous Silica 7631-86-9 5-6 80 mg/m? (as dust) N/A N/A N/A
SECTION IIB - ADDITIONAL INGREDIENTS (> 3%)
Calcium Carbonate
Hdrocarbon Resin CAS # 68132-04-7 1317-65-3
Clay
Hydrated Alumina CAS # 21645-51-2 1332-58-7
N/E=Not established N/A=Not applicable
SECTION III - PHYSICAL DATA
SPECIFIC GRAVITY BOILING POINT % VOLATILES BY WT VAPOR DENSITY (Air = 1)
1.0 - 1.1 209癋 (98.5癈) 35-40% 3.14-3.45 (Air=1)
VAPOR PRESSURE FREEZING POINT SOLUBILITY IN WATER EVAPORATION RATE
36.7 mm HG @ 30癈 -131癋 (-90.5癈) Negligible 2.1-3.7 (nBuAc=1)
pH PHYSICAL STATE ODOR THRESHOLD CORROSIVITY
Not applicable Liquid Not available Not applicable
VOC ODOR & APPEARANCE
395 gms / liter Thick gray paste with mild hydrocarbon odor.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY IF YES, UNDER WHAT CONDITIONS
Flammable Division 2 Ignition can occur when this product is exposed to heat, sparks, or flame.
FLASHPOINT AUTOIGNITION TEMPERATURE LOWER FLAMMABLE LIMIT (%By Volume) UPPER FLAMMABLE LIMIT (% By Volume)
13.5癈 Closed Cup 222.5癈 1.0% 7.5%
HAZARDOUS COMBUSTION PRODUCTS
Toxic gases such as carbon dioxide, carbon monoxide, and nitrogen oxides may be released in a fire.
Dry chemical, carbon dioxide, or foam. Water may not be effective as an extinguishing agent.
EXTINGUISHING MEDIA
Water fog or spray may be used to provide a smothering effect on fires. A solid stream of water may scatter or spread the fire.
This product contains solvents that are dangerous fire and explosion hazards when exposed to
SPECIAL FIREFIGHTING PROCEDURES
heat or flame. Fire fighters should wear self-contained breathing apparatus with a full face piece and full protective clothing.
Water fog or spray may be used to cool fire exposed containers and the surrounding combustibles.
GROUND ALL CONTAINERS WHEN TRANSFERRING MATERIAL. Extremely flammable. Store
UNUSUAL FIRE & EXPLOSION HAZARDS
& use away from all sources of heat, flame or sparks. Do not smoke while applying. Vapors are heavier than air and may travel
along ground or may be moved by ventilation & ignited by pilot lights, sparks, heaters, smoking, electrical motors, static discharge,
or other ignition sources at locations distant from the material handling point and flash back. As with other hydrocarbon solvents,
vapors may ignite when exposed to static discharge. There is no evidence to show this product is sensitive to physical shock.
SECTION V - REACTIVITY DATA
This product is chemically stable. CONDITIONS TO AVOID
Hazardous polymerization will not occur. Heat, sparks, open flames, and other ignition sources.
INCOMPATIBILITY
Strong oxidizing agents, acids, bases.
DECOMPOSITION PRODUCTS
Toxic gases such as carbon dioxide, carbon monoxided and nitrogen oxides may be released in a fire.
SECTION VI - TOXICOLOGICAL PROPERTIES
EFFECTS OF ACUTE EXPOSURE TO PRODUCT
Primary Route of Entry: Skin Contact (Yes), Eye Contact (Yes), Ingestion (Yes), and Inhalation (Yes)
Skin, eye, nose and throat irritation on short term exposure to liquid or vapor. Overexposure may result in headache,
dizziness, fatigue, nausea, and loss of consciousness. Solvent may be absorbed through the skin in toxic amounts.
Ingestion causes irritation of the gastro intestinal tract.
Sure Grip 404
PRODUCT NAME Page 2
SECTION VI - TOXICOLOGICAL PROPERTIES -continued
EFFECTS OF CHRONIC EXPOSURE TO PRODUCT
Chronic exposure may cause reversible kidney and liver damage
EXPOSURE LIMITS SENSITIZATION TO PRODUCT IRRITANCY OF PRODUCT SYNERGISTIC PRODUCTS
OSHA PEL-TWA Toluene None Known None known
Eye, nose, & throat irritation
100 ppm @ or above PEL of 100 ppm
CARCINOGENICITY MUTAGENICITY & TUMORIGENICITY REPRODUCTIVE TOXICITY TERATOGENICITY
No Evidence No Evidence This product contains chemical This product contains chemical known to
known to th State of California the State of California to cause birth
to cause birth defects or other defects or other reproductive harm.
reproductive harm.
SECTION VII - PREVENTIVE MEASURES
EYE PROTECTION GLOVES
Glasses or goggles recommended Gloves recommended (hycron, neoprene, or nitrile).
RESPIRATOR FOOTWEAR
NIOSH approved respirator if PEL 100 ppm is exceeded. Industrial shoes to protect feet from contact with adhesive
OTHER
Long sleeves, long trousers to protect skin from contact with cleaner
Protective skin creams or emollients useful.
ENGINEERING CONTROLS
Do not use in enclosed areas without proper explosion proof ventilation. General and local exhaust ventilation must be
sufficient to control vapor concentrations and keep the PEL below 100 ppm.
LEAK OR SPILL PROCEDURE
Remove all sources of ignition. Avoid breathing vapors. Use self-contained breathing apparatus in enclosed areas.
Ventilate area. Contain and remove with inert absorbents and non-sparking tools.
WASTE DISPOSAL
Dispose of in accordance with all local, state, and federal regulations.
KEEP OUT OF REACH OF CHILDREN GROUND HANDLING EQUIPMENT
HANDLING PROCEDURES & EQUIPMENT
Use away from all sources of heat, flames, or sparks. Do NOT smoke while using. Handle with non sparking tools.
Wash with soap and water before eating or drinking. Launder contaminated clothing before reuse.
Keep containers cool, dry, and store away from all sources of heat, flame, or sparks.
STORAGE REQUIREMENTS
Keep containers tightly closed and store with adequate ventilation. Do not pressurize, cut, weld, or grind empty
containers. Residual product and solvent vapors may ignite explosively.
SPECIAL SHIPPING INFORMATION
A red caution label is requiredfor 1 gallon cans only. DOT classification: Flammable Liquid, Adhesives, 3, UN1133, PGII (Heptane)
SECTION VIII - FIRST AID MEASURES
EYE CONTACT
Immediately flush with large amounts of running water for at least 15 minutes. Get medical attention.
SKIN CONTACT
Remove contaminated clothing and immediately flush skin with running water. Wash exposed area with soap and water.
Contact a physician.
INHALATION
Remove to fresh air. Provide oxygen if breathing is difficult. If necessary, give artificial respiration.
If symptoms persist, seek medical attention.
INGESTION
Do not induce vomiting. Get medical attention.
SECTION IX - SARA SECTION 313 SUPPLIER NOTIFICATION
This product contains the following toxic chemicals subject to the reporting requirements of SARA 313
of the Emergency Planning & Community Right-to-Know Act of 1986 & of 40CFR 372:
CHEMICAL NAME CAS # % CHEMICAL NAME CAS # %
PA:
Toluene 108-88-3 11.7
California (Prop 65): Amorphous Silica 7631-86-9 5-6
Toluene 108-88-3 11.7 Heptane 142-82-5 23-27
FL: CANADA: WHMIS Class D
Toluene 108-88-3 11.7 Toluene 108-88-3 11.7
Heptane 142-82-5 23-27 Heptane 142-82-5 23-27
MA, MN,NJ: Amorphous Silica 7631-86-9 5-6
Amorphous Silica 7631-86-9 5-6
Toluene 108-88-3 11.7
Heptane 142-82-5 23-27
SECTION X - PREPARATION INFORMATION
PREPARED BY DATE DATE - REVISION # SUPERSEDES ALL PREVIOUS
R & D Group 6 June 2002 # 10 PUBLICATIONS
NOTICE
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of
Hardcast. The data on this sheet relates only to the specific material designated herein. Hardcast assumes no legal
responsibility for use or reliance upon these data.
|