Material Safety Data Sheet
IDENTITY (As Used on Label and List)
PRM Polymer Basecoat
Section I
Manufacture's Name Emergency Telephone Number:
Perma-Chink Systems, Inc. CHEMTREC 1-800-424-9300
Address (Number, Street, City, State, and ZIP code) Telephone Number for Information:
1605 Prosser Road (425) 885-5085
Date of Preparation
Knoxville, TN 37914 2/02/09
Preparer's Name Signature of Preparer (optional)
Sean Gahan
Section II ?Hazardous Ingredients/Identity Information
Hazardous Component (Specific Chemical Identity, Common Name(s):
CAS OSHA / PEL ACGIH TLV Other Limits % (optional)
mg/m3 mg/m3
# Recommended
Portland Cement 65977-15-1 5 10
Silica 14808-60-7 0.1 0.1
Clay 132-58-7 5 10
Vinyl 108-05-4 5 10
Limestone 474-34-1 5 10
Section III ?Physical/Chemical Characteristics
Boiling Point: Specific Gravity (H20 = 1)
N/A 2.8
Vapor Pressure (mm Hg.) Melting Point
N/A % Volatile (Volume) N/A
Vapor Density (Air = 1) Evaporation Rate
N/A (Butyl Acetate = 1) N/A
Solubility in Water
Negligible
Appearance and Odor
Grayish solid.
Section IV ?Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limitations LEL UEL
None N/A
Extinguishing Media
Water, spray foam, CO2, or dry chemical.
Special Fire Fighting Procedures
None
Unusual Fire and Explosion Hazards
None.
Section V ?Reactivity Data
Stability Unstable Conditions to Avoid
Stable Reacts with acid to liberate CO2.
Incompatibility (Materials to Avoid) Oxides of carbon
Hazardous Decomposition or Byproducts None
Hazardous Polymerization May Occur Conditions to Avoid
Will Not Occur None Known
Section VI ?Health Hazard Data
Inhalation? Yes Skin? No Ingestion? No Eye Contact? NO
Routes of Entry
Health Hazards (Acute and Chronic)
Eye Contact: May cause eye redness or irritation.
INHALATION: Prolonged inhalation of excessive silica dust may reduce lung fuction.
INGESTION: May cause gastrointestinal irritation. SKIN: May cause temporary redness or skin rash.
Carcinogenicity? NO NTP? NO IARC Monographs? NO OSHA Regulated? Yes
Signs and Symptoms of Exposure: No acute effects. Long-term overexposure to high concentrations of this dust without the use
of a dust mask may reduce respiratory function in some individuals.
Medical Conditions: Unknown
Emergency and First Aid Procedures:
Eye contact: Flush with clean water for at least 15 minutes; seek medical attention.
Inhalation: Remove individuals to fresh air. Seek medical attention.
Skin contact: Wash affected area with soap and warm water.
Ingestion: Seek medical attention.
Section VII ?Precautions for Safe Handling and Use
Steps to be taken in Case Material is Released or Spilled
Material is not classified as a toxic pollutant or hazardous substance under Section 307 and 311 of the Clean Water Act.
Accidental releases can be cleaned up by sweeping, vacuuming, or flushing with water.
Waste Disposal Method
Material is not classified as hazardous waste under RCRA Section 3001. Dispose of material in accordance with all
applicable Federal, State, and Local regulations.
Precautions to be taken in Handling and Storing
Avoid breathing vapors. Wash hands thoroughly after handling. Keep containers close when not in use. When using
product, provide adequate ventilation. Avoid contact with skin or clothing. Store in a cool dry place. KEEP OUT OF
THE REACH OF CHILDREN.
Other Precautions
None.
Section VIII ?Control Measures
Respiratory Protection (Specify Type)
Wear NIOSH ?approved organic vapor respirator.
Ventilation Local Exhaust Special
Provide adequate ventilation.
Mechanical (general) Other
Protective Gloves Eye Protection
Gloves are recommended. Goggles or safety glasses with side shields.
Other Protective Clothing or Equipment
None.
Work/Hygenic Practices: Wash hands thoroughly before eating, smoking or using the restroom.
The information contained herein is, to the best of Perma-Chink Systems, Inc. knowledge, accurate as of the data indicated. Since
the information contained herein may be applied under conditions beyond our control and with which we may be unfamiliar, and
since data made available subsequent to the date hereof may suggest modifications of the information, we do not assume
responsibility for the results of its use. This information is furnished on the condition that the person receiving it shall make his own
determination as to the suitability of the material for his particular purpose and on the condition that he assumes the risk of his use
thereof.