SECTION 2 - COMPOSITION AND INFORMATION ON INGREDIENTS
Hazardous Ingredients CAS Number Percent
GLYCOL ETHER 112-34-5 3.00
vinyl acetate 108-05-4 0.50
OSHA PELs & ACGIH TLVs are listed in Section 8 where applicable.
SECTION 3 - HAZARD IDENTIFICATION
EMERGENCY OVERVIEW:
White colored water-based adhesive. Slippery in the wet state.
ROUTES OF ENTRY:
Inhalation: yes
Ingestion: yes
Skin: no
Eye: yes
INHALATION:
Vapors and/or aerosols which may be formed at elevated temperature may
be irritating to eyes and respiratory tract.
INGESTION:
No hazard expected in normal industrial use. Ingestion is not a likely
route of exposure.
SKIN:
Prolonged or repeated skin contact can cause irritation.
EYE:
Substance may cause moderate eye irritation.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:
Pre-existing skin disorders.
CARCINOGENICITY:
IARC: Yes, 2B (vinyl acetate). See Section 2.
NTP: No
OSHA: No
The International Agency for Research on Cancer has determined vinyl
acetate to be carcinogenic in experimental animals.
Available epidemiologic studies do not confirm an increased risk of
cancer in exposed humans.
REPRODUCTIVE TOXICITY:
None anticipated based on product formula.
TARGET ORGANS:
Eyes and skin.
SECTION 4 - FIRST AID MEASURES
INHALATION:
Remove to fresh air. If difficulty persists, seek medical attention.
INGESTION:
Call poison control center immediately. Follow their specific
instructions. Do not induce vomiting.
SKIN:
Wash with soap and water. Contact a physician if irritation develops
or persists.
EYE:
Hold eyelids apart and flush with plenty of water for at least 15
minutes. Seek medical attention.
SECTION 5 - FIRE-FIGHTING MEASURES
Flammability Class (OSHA) IIIB
Flash Point: > 200 F
Setaflash
Explosive Range: Not Available
EXTINGUISHING MEDIA:
Use alcohol foam, carbon dioxide, water spray, or ABC dry chemical
when fighting fires involving this product.
HAZARDOUS COMBUSTION PRODUCTS:
Various oxides of carbon, organic compounds, and water may be released
during combustion.
FIRE FIGHTING PROCEDURES:
Wear a NIOSH approved self contained breathing apparatus. Wear
appropriate personal protective equipment.
SECTION 6 - ACCIDENTAL RELEASE MEASURES
CONTAINMENT TECHNIQUES:
Use inert absorbent to dike the spill. Keep away from drains.
CLEAN-UP:
If possible pump liquid into an approved container or spread absorbent
over spill and shovel product/absorbent mixture into an approved
container. If product has dried scrape up and place in an approved
container.
SECTION 7 - HANDLING AND STORAGE
HANDLING:
Empty drums should be completely drained, properly bunged and promptly
returned to a reconditoner, or properly disposed of.
Use only in well ventilated area.
STORAGE:
Store at temperatures between 50 F and 90 F.
SECTION 8 - EXPOSURE CONTROLS AND PERSONAL PROTECTION
Occupational Exposure Limits
ACGIH TLV ACGIH TLV-C ACGIH STEL OSHA STEL OSHA PEL
ENGINEERING CONTROLS:
Use local exhaust as needed to maintain occupational exposure limits.
OTHER:
Facilities storing or utilizing any chemical should be equipped with
an eyewash facility and a safety shower.
RESPIRATORY PROTECTION:
Respiratory protection is not expected to be necessary under normal
use. Follow requirements for respiratory protection in OSHA 1910.134.
EYE PROTECTION:
Chemical splash goggles (ANSI Z87.1 or approved equivalent).
SKIN PROTECTION:
Where skin contact can occur, wear impervious gloves.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
Form: LIQUID
Appearance/Color: WHITE
Odor: MILD
Solubility (in water): DISPERSIBLE IN WATER
pH Value: 4.5
Boiling Range/Point: 210.鳩
Evaporation Rate: Slower than n-Butyl Acetate
% Volatile: 50.%
Specific Gravity: 1.10
SECTION 10 - STABILITY AND REACTIVITY
Stability: This product is stable
Hazardous Polymerization: Hazardous polymerization will not occur
CONDITIONS TO AVOID:
None known.
INCOMPATIBLITY:
Strong acids and bases.
HAZARDOUS DECOMPOSITION PRODUCTS:
Oxides of carbon may be released during combustion.
SECTION 11 - TOXICOLOGICAL INFORMATION
Acute and chronic health effects are not expected as long as good
industrial hygeine and safety precautions are followed.
SECTION 12 - ECOLOGICAL INFORMATION
This product has not been tested for environmental effects.
SECTION 13 - DISPOSAL CONSIDERATIONS
WASTE DISPOSAL:
Disposal of this product must comply with all applicable federal,
state and local regulations.
CONTAINER DISPOSAL:
Disposal of this container should comply with all applicable federal,
state and local regulations.
SECTION 14 - TRANSPORT INFORMATION
UN Number N/A
UN Pack Group N/A
UN Class NON HAZ
ICAO/IATA Class NON HAZARDOUS (*SEE NOTE)
IMDG Class NON HAZARDOUS
Shipping Name NON HAZARDOUS
ADR/RID Class NON HAZARDOUS
Packaging may not be approved for shipping by air. Please contact
Franklin International for further information.
SECTION 15 - REGULATORY INFORMATION
SARA TITLE III SECTION 313:
This product contains the following toxic chemicals subject to the
reporting requirements of Section 313 of the Emergency Planning and
Community Right to Know Act of 1986 and of 40 CFR 372:
Chemical Name CAS Number Percent
GLYCOL ETHER 112-34-5 3.00
vinyl acetate 108-05-4 0.50
TSCA (Toxic Substances Control Act Inventory):
All components of this product are listed on the TSCA inventory except
as exempted.
SECTION 16 - OTHER INFORMATION
DISCLAIMER:
While the information and recommendations set forth herein are
believed to be accurate as of the data hereof, Franklin International
makes no warranty, express or implied, with respect thereto and
disclaims all liability from reliance thereon.