MATERIAL SAFETY DATA SHEET
(COMPLIES WITH 29CFR 1910.1200)
SECTION I - CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Protective Gloves: Chemical resistant rubber.
Identity (As Used on Label and List): CGR-150
Eye Protection: Approved safety goggles or glasses.
Product Class: Coating Remover
Footwear: Rubber, slip resistant footwear.
Emergency Telephone Number: 800-255-3924
Other Protective Clothing or Equipment: Not required.
Telephone Number for Information: 651-481-1900
Work/Hygienic Practices: Avoid excessive breathing of vapor or mist. Avoid
Distributor's Name and Address:
repeated or prolonged contact with skin. Do not contaminate food or beverages.
Multi-Clean, A Division of Minuteman International
600 Cardigan Road
SECTION IX - PHYSICAL/CHEMICAL CHARACTERISTICS
Shoreview, MN 55126
Boiling Point: N. Av. pH: 6-8
SECTION II - COMPOSITION/INFORMATION ON INGREDIENTS Specific Gravity (H20) = 1: 1.067 % Volatile: > 80
Vapor Density (Air = 1): > 1 Odor Threshold: N. Av.
Hazardous Components (Specific Chemical Identity):
Evaporation Rate (Butyl Acetate = 1): N. Av. Oil/Water Distribution
Chemical Common Name(s) %
Solubility in Water: Complete Coefficient: N. Av.
A Benzyl Alcohol 60-100
CAS #100-51-6 Vapor Pressure (MM HG): N. Av.
B Ethylene Glycol 10-30 Melting Point: N. Ap.
CAS #107-21-1
SECTION X - STABILITY AND REACTIVITY
SECTION III - HAZARDS IDENTIFICATION Stability: Unstable: Stable: X
Emergency Overview Conditions to Avoid: N. Av.
Appearance and Odor: Slightly viscous clear gel. Incompatibility (materials to avoid): Acids and strong oxidizers.
Primary Hazards: Irritant Hazardous Decomposition or By-products: Oxides of Carbon
Potential Health Hazards Hazardous Polymerization: May occur: Will not occur: X
Route(s) of Entry: Skin Absorption: X Ingestion: X Inhalation: X Conditions to Avoid: May attach aluminum on heating and some plastics.
Eye: May cause irritation on contact.
SECTION XI - TOXICOLOGICAL INFORMATION
Skin: May cause irritation on contact. May be harmful if absorbed through skin.
Chemical OSHA PEL ACGIH TLV Recom. LD50 LC50
Ingestion: May be harmful if swallowed.
A 10 ppm 10 ppm N. Av. 1230 mg/kg 1000 ppm.
Inhalation: May irritate mucous membranes. Overexposure to vapors may cause
(rat, oral) (rat)
respiratory tract irritation and a burning sensation.
B 50 ppm 50 ppm 50 ppm N. Av. N. Av.
Signs and Symptoms of Exposure: Irritation on direct contact.
Carcinogenicity: NTP? No IARC Monographs? No Teratogen, Mutagen, Reproductive Toxin Status: No
OSHA Regulated? No Toxicologically Synergistic Products: N. Av.
Target Organ (s): Eyes, skin, mucous membranes.
SECTION XII - ECOLOGICAL INFORMATION
Medical Conditions Generally Aggravated by Exposure: N. Av.
Health Hazards, Chronic: High vapor concentrations, ingestion and skin Ecotoxicological Information: N. Av.
absorption may cause headache, sore throat, coughing, difficulty breathing, Chemical Fate Information: N. Av.
low blood pressure, fatigue, nausea, vomiting, diarrhea and abdominal pain.
SECTION XIII - DISPOSAL CONSIDERATIONS
Severe cases may result in respiratory and muscular paralysis convulsions,
Waste Disposal Method:
narcosis and death. Direct contact with liquied may cause eye and skin
Dispose of spilled material in accordance with local, state and federal regulations.
irritation, allergic skin reaction and anesthetic (numbing) effects.
Waste material should not be sewered. Collect and dispose through disposal facility.
SECTION IV - FIRST AID MEASURES RCRA Hazard Class: None
Emergency and First Aid Procedures:
SECTION XIV - TRANSPORT INFORMATION
For ingestion: If a person can swallow, give several glasses of water. Do not
Shipping Classification: Compound cleaning liquid, N.O.I.
induce vomiting. Get immediate medical attention. For Eye Contact: Flush eyes
UN Number: N. Ap.
with running water for at least 15 minutes. If irritation persists, get medical attention.
Packing Group: N. Ap.
For Skin Contact: Wash affected area with soap and water. Remove contaminated
clothing and launder before reuse. For Inhalation: Remove to fresh air. If irritation SECTION XV - PREPARATION DATA
persists, get medical attention.
Prepared By: Mike Elms
Sources Used: Raw material data, general toxicology from the trade for similar
Telephone Number: 651-481-1900
products.
Date: 3/02
SECTION V - FIRE FIGHTING MEASURES
SECTION XVI - REGULATORY INFORMATION
Flammability: Combustible Autoignition Temperature: N. Av.
US Federal Regulations
Flash Point (method used): Over 212癋, Open Cup.
TSCA Status: All ingredients listed.
Flammable Limits: N. Av. LEL UEL
CERCLA Reportable Quantity: None
Extinguishing Media
SARA Title III
Water? Foam? X Water Fog?
Section 302 Extremely Hazardous Chemicals: None
Alcohol Foam? CO2? X Dry Chemical? X
Section 311/312 Hazard Category: Immediate health, chronic health.
Vaporizing Liquid? Other?
Section 313 Toxic Chemicals: Ethylene Glycol
Special Fire Fighting Procedures: N. Ap.
State Regulations
Unusual Fire and Explosion Hazards: None known NOTICE STATE OF CALIFORNIA
TDG Flammability Classification: None Warning: This product may contain chemicals known to the State of California to
Sensitivity to Mechanical Impact: None cause cancer or reproductive defects as trace impurities in the standard industrial
Sensitivity to Static Discharge: Above flashpoint. materials used in the manufacture of this product.
International Regulations
SECTION VI - ACCIDENTAL RELEASE MEASURES
WHMIS Controlled Product Hazard Class: D2B, B3
Steps to be Taken in Case Material is Released or Spilled:
Dike and contain spill with inert material (sand, earth, etc). Collect spill with mop, SECTION XVII - OTHER INFORMATION
absorbent material (example: floor-dri) or vacuum. Thoroughly rinse affected area
None
with water.
SECTION VII - HANDLING AND STORAGE N. Ap. - Not Applicable; N.Av. - Not Available
Precautions to be Taken in Handling and Storing: Normal care in handling and
storage. Do not taste or swallow. NFPA SYSTEM
Other Precautions: Keep out of reach of children. Keep from freezing. _2_ A. Health Hazard _1_ A. Fire Hazard _0_ A. Reactivity Hazard
SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE, HOWEVER NO
WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THESE DATA OR THE RESULTS TO
Respiratory Protection (Specify Types): NIOSH approved organic vapor mask BE OBTAINED FROM THE USE THEREOF. MINUTEMAN INTERNATIONAL, INC. ASSUMES NO RESPONSIBILITY
required if ventilation is insufficient to maintain a satisfactory vapor level. FOR PERSONAL INJURY OR PROPERTY DAMAGE TO VENDEES, USERS OR THIRD PARTIES CAUSED BY THE
MATERIAL. SUCH VENDEES OR USERS ASSUME ALL RISKS ASSOCIATED WITH THE USE OF THE MATERIAL.
Ventilation: Local Exhaust: Not required Special: Not required
Mechanical (General): Provide adequate ventilation to exhaust
vapors. Other: Not required
|