#141
MATERIAL SAFETY DATA SHEET
3 Flammability = 0 Reactivity = 0
NFPA RATING: Health =
3 Flammability = 0 Reactivity = 0
HMIS RATING: Health =
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (1130A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: STRIP-ALL
Address: 302 North Fourth Street Date Prepared: January 31, 2007
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800)-424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: CAS# OSHA PEL ACGIH TLV OTHER LIMITS %
Common Name(s) RECOMMENDED
2 mg/M3
Sodium metasilicate (1) 6834-92-0 not established not established 5-10
Ethanolamine (2) 141-43-5 3 ppm 3 ppm N/A 3-5
Water 7732-18-5 none none N/A ---
Benzyl alcohol (3) 100-51-6 not established not established N/A ---
(1) Exposure may be elevated as ceiling for Sodium hydroxide per OSHA: PEL = 2mg./M3 or TLV = 2mg.M3
(2) Regulated by OSHA, and the following states: CT, FL, IL, LA, MA, NJ, PA, RI.
(3) Regulated by FL, MA, PA.
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
corr. 208癋 1.05 & 39癈 = 1.06
Boiling Point: Specific Gravity (H2O = 1): 25癈 =
17.2 average 92.2
Vapor Pressure (mm Hg.): Percent Volatile by Volume (%):
0.8 slower than 1
Vapor Density (AIR = 1): Evaporation Rate (ethyl ether = 1):
complete Appearance and Odor: clear amber liquid; non-objectionable odor
Solubility in Water:
12.5-13.5
pH (concentrate) =
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
None (Tag Closed Cup) N/A UEL = N/A
Flash point: Flammable Limits: LEL =
Extinguishing Media: Water, carbon dioxide, dry chemical or foam.
Special Fire Fighting Procedures: Normal fire fighting procedures may be used. Cool and cautiously approach or handle
fire-exposed containers.
Unusual Fire and Explosion Hazards: N/A
SECTION V -- PHYSICAL HAZARDS
Stable N/A
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Oxidizing materials and strong acids.
Hazardous Decomposition Products or Byproducts: Produces normal products of combustion when exposed to fire.
Will not occur None known
Hazardous Polymerization: Conditions to Avoid:
SECTION VI -- HEALTH HAZARD DATA
Yes Skin? Yes Ingestion? Yes
Routes of entry: Inhalation?
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Direct contact with concentrate in eyes can cause severe irritation and damage.
2. Prolonged and repeated exposure to skin may produce irritation or damage. Inhalation of spray mist may result in
varying degrees of irritation.
Chemical listed as Carcinogen or Potential Carcinogen:
No No OSHA = No
National Toxicology Program = I.A.R.C. Monographs =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater or equal to 0.1%.
page 2 of #141 STRIP -ALL
SECTION VI -- HEALTH HAZARD DATA cont.
Signs and Symptoms of Exposure: Concentrated product may produce skin and eye burns. Ingestion may produce burns of the
mouth throat, esophagus and stomach.
Medical Conditions Generally Aggravated by Exposure: Skin problems such as industrial dermatitis.
Emergency and First Aid Procedures: In case of contact immediately flush eyes or skin with plenty of water for at least 15
minutes while removing contaminated clothing and shoes. Remove contact lenses and again flush eyes with water. GET
MEDICAL ATTENTION. Wash clothing and thoroughly clean contaminated shoes before reuse. If swallowed do not induce
vomiting; immediately give large amounts of water and CALL A PHYSICIAN, hospital emergency room or poison control center.
Inhalation: remove victim to fresh air; if respiratory tract remains irritated, call a physician.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Absorb with floor dry or similar inert material. Sweep or scrape up
and put in appropriate container. Rinse spill area thoroughly with water. Use appropriate protective equipment.
Waste Disposal Method: Disposal is regulated by the Resource Conservation and Recovery Act; concentrate is corrosive per EPA
Hazardous Waste Classification. Disposal of regulated quantities should be neutralized at a permitted facility in accordance with all
federal, state and local requirements.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use. Container disposal: Triple rinse (or
equivalent), then offer clean, dry container for recycling or reconditioning. Waste from normal use may be sewered to public-
owned treatment works in compliance wit applicable federal, state and local requirements.
Other Precautions: Do not use with fog mist or fine droplet sprayer without respiratory protection. This product contains no
reportable quantities of toxic chemicals subject to the reporting requirements of Section 313 of SARA Title III Emergency Planning
and Community Right to Know Act of 1986 and 40 CFR Part 372.
SECTION VIII -- CONTROL MEASURES:
Respiratory Protection (Specify Type): Ventilate to keep air concentration below TLV on ethanolamine or metasilicate
Ventilation:
Recommended Recommended Special = N/A N/A
Local Exhaust = Mechanical (General) = Other =
Protective Gloves: Impervious gloves when working with concentrate
Eye Protection: Chemical safety goggles when working with concentrate
Other Protective Clothing or Equipment: Impervious to water and alkaline liquid where concentrate is a concern.
Work / Hygienic Practices: Wash thoroughly after handling.
SECTION IX - TRANSPORTATION INFORMATION:
Applicable regulations: DOT = No; IMCO = No; IATA = No
Proper shipping name: Cleaning compound
UN No.: not applicable Limited Qty.: not applicable Hazard Class: not applicable
Labels required: not required DOT Exception: not applicable
EPA Hazardous waste/number code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = yes; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR
1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein
is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|