Material Safety Data Sheet
I. Chemical Product And Company Data
Health 1
PRODUCT: EP50 T PRIMER PART A
CHEMICALFAMILY: Epoxy Resin Flammability 1
REVISION DATE: March 07 Reactivity 0
Adurel International Inc
MANUFACTURER: Personal Protection H
820 Water St. Racine WI 53403
800-860-5834 Fx 262-632-3446
II. Composition / Information On Ingredients
This document is prepared pursuant to the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Where a proprietary ingredient is shown, the identity may be made available as provided in this standard.
All components of this product are included in the EPA Toxic Substances Control Act (TSCA) Chemical
Substance Inventory.
EXPOSURE LIMITS
HAZARDOUS INGREDIENTS CAS NO TLV STEL PEL CONTENT
N/A
Proprietary Ingredients N/A N/A Balance
N/A N/A
Bisphenol A Epoxy Resin 025085-99-8 N/A <95%
Benzyl Alcohol 100-51-6 N/A N/A N/A <10%
California Proposition 65
ingredients
None
Section 313 Supplier Notification
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know Act of 1986 (40CFR372)
None 9016-87-9
III. Hazards Identification
HMIS Hazard Rating No. 3
PRIMARY ROUTE OF ENTRY: Eye and skin contact, breathing and ingestion.
Symptoms of Exposure
Skin Contact: Prolonged or repeated exposure may cause skin irritation and redness. Skin
sensitization or allergic reaction may occur in some individuals.
Eyes: Protect may cause irritation to the eyes.
Adurel International, Inc. UP70 PRIMER PART A Page 1 of 5
Inhalation No known kealth information on inhalation of vapors.
Ingestion: Not expected to be a relevant route of exposure although it may cause gastrointestinal
irritation, nausea, vomiting and abdominal pain.
IV. First
Aid
Measures
Inhalation Remove victim from exposure. If difficulty with breathing, administer oxygen and seek
medical assistance
Eyes Flush eyes with cold water for 15 minutes, lifting lower and upper eye lids throughout. Flush
Seek medical assistance. lids th
Skin Immediately remove contaminated clothing. Wash thoroughly with soap and water. If
irritation persists seek medical attention. Wash contaminated clothing before reuse.
Ingestion Do not induce vomiting, get immediate medical attention, if vomiting occurs
spontaneously keep head below hips to prevent aspiration of liquids into lungs. Do
not give anything by mouth to an unconscious person
V. Fire
Fighting
Methods
HMIS Hazard Rating No. 1
Flash Point: >200.0 o F
General Hazard: Decomposition and combustion products may be toxic.
Auto-Ignition Temp.: Not Available
Limits of Flammability LEL:
Extinguishing Media Carbo
chem
Special Fire & Unusual Hazards Move containers from area if it
can be done without risk. Cool
fire-exposed containers with
water from the side. As in any
fire, wear NIOSH/MSHA
approved, pressure demand self
contained breathing apparatus
and full protective gear.
VI. Accidental Release
Measures
Action To Take For Spills/ Leaks: Avoid contact with skin or eyes. Flush area with water spray. Clean up
residue with absorbent material.
Waste Disposal Method: Handle disposal of waste material in manner which complies with local, state,
province and federal regulation. Landfill if solidified, or incineration at agency approved waste-disposal
facilities.
VII. Handling And Storage
Average Shelf Life: 1 yr unopened Refer
Special Instructions Store in a cool place and keep from freezing.
VIII. Exposure Controls / Personal
Protection
Adurel International, Inc. UP70 PRIMER PART A Page 2 of 5
Ventilation: Ventilation is recommended. Air movement must be designed to insure turnover at all
locations in work area to avoid build up of heavy vapors.
Personal Protection Equipment: Do NOT wear contact lenses when working with this material. Use
chemical goggles/safety glasses with side shields and impervious gloves. Wear clothing with long sleeves
and pants. In operations where mists can be generated or the exposure limits for crystalline silica
exceeded, wear a NIOSH/MSHA approved dust/fume respirator selected by a technically qualified person
for the specific work conditions. Wear respirator protection whenever airborne concentrations exceed TLV
ceilings or TWA, use NIOSH approved respirators for listed hazard.
Confined spaces, room, or tanks are areas where concern for TLV's is especially important. Reference
OSHA regulation CFR 29 1910.134 for recommended respiratory protection.
IX. Physical And Chemical Properties
Boiling Point (oC): 100 300
(deco
Percent Volatile: <100g.l or .84 lbs/gal Water/Oil Distribution N/A
Coefficient:
Freezing Point (oC): N/A Solubility in Water: negligible
Vapor Pressure @ 20o C N/A Specific Gravity @20?C 1.15
Vapor Density >air pH: N/A
Odor Threshold: N/A Evaporation Rate: Slower cf ether
Appearance: Clear liquid Odor: Mild Epoxy
N/A = Not Available N/D=NOT Determined
Ca. = Approximate
X. Stability And
Reactivity
HMIS Hazard Rating No. 0
Stability Stable Stabl
Incompatibility: Strong acids, bases, amines and oxidizing agents Stron
perox
Hazardous Decomposition Products Oxides of carbon, and phenolics in fire; Decomposition and
Combustion products may be toxic
Conditions To Avoid Excess heating above 60C over long periods degrades resin.
XI. Toxicity Information
HMIS Hazard Rating No. 3
PRIMARY ROUTE OF ENTRY: Inhalation, dermal
Effects Of Overexposure
Inhalation: No information available Inhala
nose,
and re
result
findin
hyper
onset
Eyes: Contact may cause irritation Conta
Skin Contact: In some individuals may cause irritation.
Ingestion: Not expected to be a relevant route of exposure although it may cause
gastrointestinal irritation, nausea, vomiting and abdominal pain.
Adurel International, Inc. UP70 PRIMER PART A Page 3 of 5
XII. Ecological
Information
Marine Pollutant: Material
is highly toxic to aquatic
organisms on an acute
basis. Bioconcentration
potential is low.
Biodegradation under
aerobic static lab
conditions is below
detecable limits.
(NL = Not Listed; P = Moderate; PP = Severe; ND = Not Determined)
XIII. Disposal Considerations
Handle disposal of waste material in manner which complies with all applicable local, state, provincial and
federal regulations.
XIV. Transport Information
DOT SHIPPING INFORMATON
NOT REGULATED
DOT Proper Shipping Name
DOT Hazard Class
DOT I.D Number Label(s)
XV. Regulatory Information
OSHA Hazard Communication Standard Hazardous
(29 CFR 1910.1200)
CERCLA/ Super fund (40 CFR 117,302) N/A
SARA Extremely Hazardous Substances N/A
(40 CFR 355)
SARA Hazard Categories (40 CFR 370)
SARA Toxic Chemicals (40 CFR 372) See section II supplier notification
Inventory Status The chemicals in this product are listed on the US
TSCA Chemical Substance Inventory and the
Canadian Domestic Substances List.
XVI. Other Information
THE INFORMATION HEREIN HAS BEEN COMPLIED FROM SOURCES BELIEVED TO BE RELIABLE
AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, LymTal INTERNATIONAL INC.
CAN NOT GIVE ANY GUARANTEES REGARDING INFORMATION FROM OTHER SOURCES, AND
EXPRESSLY DOES NOT MAKE ANY WARRANTIES, NOR ASSUMES ANY LIABILITY, FOR ITS USE.
Adurel International, Inc. UP70 PRIMER PART A Page 4 of 5
|