MATERIAL SAFETY DATA SHEET
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
1. PRODUCT AND COMPANY IDENTIFICATION
Product Name/Use: 25 FULL IMPACT No Rinse Stripper Concentrate
Product Synonyms: Command Center 25 FULL IMPACT No Rinse Stripper Concentrate;
Outpost 25 FULL IMPACT No Rinse Stripper Concentrate
MANUFACTURER
Butcher Telephone Number: 800-225-9475
The Butcher Company
Emergency T elephone (24 hours): 800-228-5635
67 Forest Street
CHEMTREC (U.S./Can.): 800-424-9300
Marlborough, MA 01752-3012
CHEMTREC (Int'l): +1 703-527-3887
2. COMPOSITION / INFORMATION ON INGREDIENTS
INGREDIENT(S) CAS NO. % BY WEIGHT
Benzyl alcohol 100-51-6 40 ?60
Ethanolamine 141-43-5 10 ?25
Dipropylene glycol butoxy ether 29911-28-2 10 ?25
See Section 8 for Exposure Limits NA - Not Applicable
OSHA REGULATORY STATUS: This product is classified as hazardous under OSHA regulations.
WHMIS CLASS: Class E; Class D- Division 2B
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Clear, Red Liquid. Strong, Amine Odor. Causes Eye and Skin Burns. May Cause Respiratory
Tract Irritation. Harmful if Swallowed. May Be Harmful if Absorbed Through Skin.
POTENTIAL HEALTH EFFECTS (See Section 11 for Toxicological Information)
PRIMARY ROUTE(s) OF EXPOSURE: X Eye X Skin Contact X Skin Absorption
X Inhalation X Ingestion
EFFECTS OF ACUTE EXPOSURE
EYES:
Causes eye burns. Symptoms may include pain, tearing, redness, and eye injury.
SKIN:
Causes skin burns. Symptoms may include pain, redness, swelling, scarring, and skin damage. May be harmful
if absorbed through skin.
MSDS No: 4239 Page: 1 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
INHALATION:
High concentrations of vapor or mist may cause nose, throat and respiratory tract irritation. Symptoms may
include coughing, wheezing and shortness of breath. High concentrations of vapor or mist may also cause
central nervous system effects including headache, dizziness and nausea.
INGESTION:
Harmful if swallowed. May cause mouth, throat and stomach burns. Symptoms may include nausea, vomit-
ing, diarrhea, and severe stomach pain. May also cause central nervous system effects including headache,
dizziness and weakness.
EFFECTS OF CHRONIC EXPOSURE:
Prolonged inhalation of high concentrations of concentrated alkaline materials above exposure limits (See Section
2, Composition/Information on Ingredients) can cause respiratory tract injury.
MEDICAL CONDITIONS AGGRAVATED:
May aggravate pre-existing eye, skin and respiratory conditions.
4. FIRST AID MEASURES
EYES:
Immediately flush eyes with plenty of water while holding eyelids apart. After initial flushing, remove any contact
lenses and continue flushing for at least 15 minutes. Do not put any medication in the victim's eyes unless
instructed by a physician. Get immediate medical attention.
SKIN:
Immediately flush with plenty of water for at least 15 minutes, then wash with soap and water. Immediately re-
move contaminated clothing. Get medical attention if irritation develops or persists. Thoroughly wash (or discard)
clothing before reuse. Destroy contaminated shoes.
INHALATION:
Remove to fresh air. If not breathing, give respiration; if breathing is difficult, give oxygen (by trained personnel
only). Get immediate medical attention.
INGESTION:
Do not induce vomiting. Rinse mouth out with water. Drink large quantities of water. Get immediate medical
attention. Never give anything by mouth to an unconscious person.
5. FIRE FIGHTING MEASURES
FLASH POINT AND METHOD: >200癋 93癈 TCC
FLAMMABLE LIMITS:
Not applicable.
AUTOIGNITION TEMPERATURE: Not applicable.
MSDS No: 4239 Page: 2 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
EXTINGUISHING MEDIA:
Use extinguishing media appropriate for surrounding fire.
HAZARDOUS COMBUSTION PRODUCTS:
Normal products of combustion (carbon monoxide and carbon dioxide) and nitrogen oxides.
FIRE AND EXPLOSION HAZARDS:
None known.
FIRE FIGHTING INSTRUCTIONS:
This product is not flammable. As in any fire, MSHA/NIOSH approved self-contained breathing apparatus
(SCBA) and full protective gear should be worn.
6. ACCIDENTAL RELEASE MEASURES
See Section 8, Exposure Controls/Personal Protection and Section 3, Hazard Identification. Floors may be slip-
pery. Use care to avoid falling. Ventilate spill area. Contain and isolate spill. Keep non-essential personnel from
entering spill area. Use mop and absorbent to collect material for proper disposal. Use non-metallic implements
for cleaning and collection. Rinse area with water.
7. HANDLING AND STORAGE
HANDLING:
Follow label use directions. Do not mix with other chemicals unless instructed by label directions. Avoid contact
with eyes, skin and clothing. Avoid breathing vapor or mist. Wash thoroughly after handling. Immediately re-
move contaminated clothing. Wash clothing and equipment before reuse. Destroy contaminated shoes. Empty
containers retain residue and may be hazardous (See Section 14, Transport Information.).
STORAGE:
Keep container closed when not in use. Store away from incompatible materials. (See Section 10, Stability and
Reactivity).
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
PERSONAL PROTECTIVE EQUIPMENT (PPE)
EYE:
Where eye contact is possible, wear chemical splash goggles (ANSI Z87.1-approved).
SKIN:
Where skin contact is possible, chemical-resistant gloves should be worn. When additional skin contact is pos-
sible, other protective equipment and clothing (e.g., footwear) may be needed. All contaminated clothing should
be removed immediately and cleaned (or discarded) before reuse.
RESPIRATORY:
No respiratory protection is required if general room ventilation is adequate and airborne concentrations are kept
below exposure limits. When exposure limits are exceeded, use appropriate respiratory protection (NIOSH/MSHA)
to prevent overexposure.
MSDS No: 4239 Page: 3 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
ENGINEERING CONTROLS:
Good general room ventilation is expected to be adequate. If user operations generate vapor or mist, ventilation
should be used to keep airborne concentrations below exposure limits.
EXPOSURE LIMITS:
INGREDIENT(S) OSHA PEL/STEL ACGIH TLV/STEL
Benzyl alcohol NA NA
Ethanolamine 3 ppm (8 mg/m3)/ 3 ppm (7.5 mg/m3)/
6 ppm (15 mg/m3) 6 ppm (15 mg/m3)
Dipropylene glycol butoxy ether NA NA
NA - Not Available
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Liquid
ODOR: Strong, Amine
APPEARANCE: Clear, Red
pH: 11.0 to 12.0
PERCENT VOLATILE BY WEIGHT 88 :
VAPOR PRESSURE: Not Available
VAPOR DENSITY: Not Available
BOILING POINT Not Available
:
FREEZING/MELTING POINT Not Available
:
SOLUBILITY IN WATER: Complete
EVAPORATION RATE: Not Available
SPECIFIC GRAVITY: 1.003 to 1.017
VISCOSITY: Water Thin
OCTANOL/WATER PARTITION COEFFICIENT Not Available
:
ODOR THRESHOLD: Not Available
10. STABILITY AND REACTIVITY
STABILITY (CONDITIONS TO AVOID):
Stable.
POLYMERIZATION:
Will not occur.
HAZARDOUS DECOMPOSITION:
None known.
INCOMPATIBLE MATERIALS:
Oxidizers (e.g., bleach), strong acids (e.g., hydrochloric acid) and reactive metals (e.g., aluminum).
MSDS No: 4239 Page: 4 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
11. TOXICOLOGICAL INFORMATION
ACUTE DATA:
This product is corrosive to the eyes and skin. The following data are available for product ingredients:
PRODUCT/INGREDIENT ORAL LD50 (rat) DERMAL LD50 (rabbit) INHALATION LC50 (rat)
Benzyl alcohol 1230 mg/kg 2000 mg/kg 1000 ppm (8-hr)
Ethanolamine 1720 mg/kg 1018 mg/kg Not Available
3700?400 mg/kg >2000 mg/kg
Dipropylene glycol butoxy ether Not Available
SENSITIZATION DATA:
No data available.
CHRONIC DATA:
Prolonged overexposure to high concentrations of ethanolamine by inhalation and ingestion has caused liver
and kidney effects in laboratory animals. Prolonged overexposure to benzyl alcohol by ingestion and inhalation
has caused central nervous system effects in humans and laboratory animals.
REPRODUCTIVE/TERATOGENIC DATA:
No data available.
CARCINOGENIC/MUTAGENIC DATA:
Not listed as carcinogenic by NTP IARC, or ACGIH or regulated as a carcinogen by OSHA.
,
SYNERGISTIC MATERIALS:
No data available.
12. ECOLOGICAL INFORMATION
No data available.
13. DISPOSAL CONSIDERATIONS
Disposal of this material should be in accordance with local, state or provincial and federal regulations. The
unused product, as manufactured, may be a RCRA hazardous waste in accordance with 40 CFR 261. The prod-
uct's pH should be verified prior to disposal. According to RCRA, it is the responsibility of the waste generator
to ensure proper disposal.
14. TRANSPORT INFORMATION
DOT/TDG HAZARDOUS MATERIAL DESCRIPTION: Corrosive Liquid, N.O.S.
DOT/TDG TECHNICAL NAME: Ethanolamine, benzyl alcohol
DOT/TDG HAZARD CLASS: 8
UN ID No./P.I.N. No.: 1760
DOT/TDG PACKING GROUP: II
NAERG: 154
MSDS No: 4239 Page: 5 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
15. REGULATORY INFORMATION
Not meant to be all-inclusive--selected regulations represented.
UNITED STATES
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT)
311/312 HAZARD CATEGORIES: Under 40 CFR 370.2, this product meets the following hazard categories:
Immediate, Delayed.
313 REPORTABLE INGREDIENTS: Ingredients in this product are not currently subject to notification.
CERCLA (COMPREHENSIVE RESPONSE, COMPENSATION, AND LIABILITY ACT)
CERCLA REGULATORY: None of the ingredients in this product are reportable under CERCLA.
TSCA (TOXIC SUBSTANCE CONTROL ACT)
TSCA STATUS: This product complies with all TSCA inventory requirements.
MASSACHUSETTS, NEW JERSEY PENNSYLVANIA RIGHT-TO-KNOW:
,
INGREDIENT(S) CAS NO. STATE LISTING
Benzyl alcohol 100-51-6 MA, PA
Ethanolamine 141-43-5 MA, NJ, PA
Dipropylene glycol butoxy ether 29911-28-2 Not Listed
Tall oil fatty acid, amine salt NA Not Listed
NA - Not Applicable
CANADA
WHMIS (WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM):
Class E- Corrosive material; Class D- Division 2B, chronic toxic effects. This product has been classified in
accordance with the hazard criteria of the Canadian Controlled Products Regulations (CPR) and the MSDS
contains all the information required by the CPR.
16. OTHER INFORMATION
HMIS RATING NFPA RATING
FIRE
HEALTH * 3
FLAMMABILITY 1
1
REACTIVITY 0
HEALTH 3 0 REACTIVITY
PERSONAL PROTECTION -
--
SPECIAL
MSDS No: 4239 Page: 6 of 7
25 FULL IMPACT No Rinse Stripper Date Prepared: 06/30/2000
Date Revised: 01/14/2001
Concentrate
MSDS STATUS
Revision #: 4
This MSDS replaces the June 30, 2000 MSDS. Any changes in information are as follows:
APPROVED BY: EH&S/Regulatory Affairs
APPROVAL DATE: 01/14/2001
The information on this data sheet represents our current data and best opinion as to the proper use in handling
of the product under normal foreseeable conditions. Any use of this product which is not in conformance with
this data sheet or product label, or which involves using the product in combination with any other product or
any other process is the responsibility of the user.
MSDS No: 4239 Page: 7 of 7
|