Form F 7.3.29
Rev: B
Page: 1 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
-------------------------------------------- I. PRODUCT IDENTIFICATION -------------------------------
TRADE NAME (as labeled): LATAPOXY?300 Epoxy Adhesive Part A
CHEMICAL FAMILY: Amine epoxy curing agent
MANUFACTURER'S NAME: LATICRETE INTERNATIONAL, INC.
1 Laticrete Park, N. Reviewed & Approved By:
Steven B. Fine
Bethany, CT 06524-3423 USA
Steven B. Fine
Sr. Research Chemist/Safety Officer
Phone number for additional information: (203) 393-0010
Date prepared or revised: 1/09 Name of preparer: S.B. Fine
-------------------------------------------- II. HAZARDOUS INGREDIENTS ----------------------------
OTHER
CHEMICAL NAMES CAS PERCENT ACGIH TLV OSHA PEL (SPECIFY)
NUMBERS
Tetraethlyene 68953-36-6 70-75 N/A N/A
pentamine reaction
products with tall oil
fatty acids
Tetraethlyene 112-57-2 5-10 N/A N/A
pentamine
1-(2- 140-31-8 1-4 N/A N/A
aminoethylpiperazine)
Tris2-4- 90-72-2 1-3 N/A N/A
6(diaminomethyl)
phenol
N/A = Not applicable or available
------------------------------------------ III. HEALTH HAZARD INFORMATION -----------------------
SYMPTOMS OF OVEREXPOSURE for each potential route of exposure. (Possible Longer Term
Effects). Sensitization and asthmatic reaction may develop with continued exposure to vapors.
SIGNS AND SYMPTOMS OF EXPOSURE (Acute effects)
Inhaled: Breathing vapors may cause irritation of the nose and throat. Symptoms associated with
pre-existing lung disorders may be aggravated by exposure to this material.
Contact with skin or eyes: This material causes severe eye irritation. Direct contact with the material
or exposure to vapor or mists may cause stinging, tearing, redness, blurred vision, and chemical
burns of the cornea. Burns of the eye may cause blindness. This material is corrosive to skin. Skin
sensitization and allergic reaction are possible.
Form F 7.3.29
Rev: B
Page: 2 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
Absorbed through skin: N/A
Swallowed: Not likely to occur in typical industrial environments however ingestion of this material
may be harmful or fatal.
SUSPECTED CANCER AGENT?
x NO: This product's ingredients are not found in the lists below.
YES: Federal OSHA NTP IARC
------------------------------IV. FIRST AID: EMERGENCY PROCEDURES-----------------------------------------
Eye Contact: Hold eyelids apart and immediately flush eyes with plenty of water for at least 15
minutes. Get medical attention immediately.
Skin Contact: Remove product and immediately flush affected area with water for at least 15
minutes. Call a physician. Except in the most minor, superficial and localized burns, cover the
affected area with a sterile dressing or clean sheeting and transport for medical care. DO NOT
APPLY GREASES OR OINTMENTS. Control shock, if present. Launder contaminated clothing prior
to reuse. Contaminated leather wear should be discarded. Victims of a major skin area contact
should remain under medical observation for at least 24 hours due to possible delayed effects.
.
Inhaled: If breathing has stopped or is labored give assisted respiration (e.g. mouth-to-mouth).
Supplemental oxygen may be indicated. Prevent aspiration of vomit. Turn victim's head to the side.
Assure mucus does not obstruct airway. Call a physician
Swallowed
In the event of ingestion, DO NOT INDUCE VOMITING. Obtain medical care and hospital treatment
immediately. .
---------------------------------------------- V. FIRE AND EXPLOSION ------------------------------------------
Flash Point method): 350oF (Cleveland Open Cup)
Auto ignition temperature,F:
Flammable limits in air, volume %: Lower (LEL) Upper (UEL)
Fire extinguishing materials:
x water spray x carbon dioxide other:
x foam x dry chemical
Special fire fighting procedures: NFPA class II of HMIS class I rating. Wear full protective gear and
NIOSH/MSHA approved self-contained breathing apparatus. Retain expended liquids from fire
fighting for later disposal.
Unusual fire and explosion hazards: N/A
----------------------------------- VI. SPILL, LEAK, AND DISPOSAL PROCEDURES -----------------------
Form F 7.3.29
Rev: B
Page: 3 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
Spill response procedures (include employee protection measures): Dam and absorb spill with
absorbent materials, minimize breathing vapors. Increase ventilation. Wear impervious gloves,
safety goggles, and NIOSH approved organic vapor canister type respirator.
Preparing wastes for disposal (container types, neutralization, etc.): Absorb spill on sand, earth, or
vermiculite. Carefully collect into closed containers for disposal. Wash spill area with 5% acetic acid
then flush with water. Do not sewer. NOTE: Dispose of all wastes in accordance with federal, state
and local regulations.
------------------------------------------VII. Handling and Storage----------------------------------------------------------
Store in cool dry area.
-------------------------------------- VIII. Exposure Controls and Personal Protection ------------------------------
Ventilation and engineering controls: General ventilation should be adequate.
Respiratory protection (type): In confined areas, a NIOSH approved organic vapor canister type
respirator should be worn.
Eye protection (type): Chemical splash proof goggles.
Gloves (specify material): Nitrile rubber gloves. In emergency situations, wear impermeable gloves
with cuffs to prevent spread of material to area above the wrists.
.
Other clothing and equipment: Long sleeved shirt and long trousers
Work practices, hygienic practices: Wash at the end of each work shift and before eating, smoking or
using the toilet. Launder or discard contaminated clothing. Discard contaminated leather articles.
Examine protective gloves before using. Discard if find evidence of holes or cracks
Other handling and storage requirements: N/A
Protective measures during maintenance of contaminated equipment: See above.
------------------------------------------------ IX. PHYSICAL PROPERTIES ----------------------------
Vapor density (air=1): N/A Melting point or range,F: N/A
Boiling point or range, F: N/A
Specific gravity: 0.99
Solubility in water: slightly soluble Evaporation rate (butyl acetate = 1): N/A
Vapor pressure, mmHg at 20C: N/A
Appearance and odor: Amber colored liquid with amine odor
Form F 7.3.29
Rev: B
Page: 4 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
HOW TO DETECT THIS SUBSTANCE (warning properties of substance as a gas, vapor, dust, or
mist):
---------------------------------------------------- X. REACTIVITY DATA -----------------------------------------------
Stability: x Stable Unstable
Conditions to avoid: N/A
Incompatibility (materials to avoid): Oxidizing Agents (i.e. perchlorates, nitrates etc.). Cleaning
solutions, such as chromerge (sulfuric acid/dichromate) and aqua regia. a reaction accompanied by
large heat release occurs when the product is mixed with acids.
Hazardous decomposition products (including combustion products): (from burning, heating, or
reaction with other materials). Carbon monoxide, carbon dioxide, oxides of nitrogen.
Hazardous polymerization: May occur x Will not occur
Conditions to avoid: N/A.
-----------------------------------------------XI. Toxicology Information-------------------------------------------------
Polyamide resin ?Oral (Rat) LD50 >2000mg/kg Irritation data skin- rabbit: >660mg/kg corrosive eye ?br>
rabbit: severe
---------------------------------------------XII. Ecological Information-------------------------------------------------
LC50 (24 h) :222 mgll Species : Rainbow trout (Oncorhynchus mykiss). LC100 (96 h) :240 mg/l
Species :Rainbow trout (Oncorhynchus mykiss). LC0 (96 h) :180 mg/l Species :Rainbow trout
(Oncorhynchus mykiss). LC50 (24 h) :249 mgll Species :Carp (Cyprinus carpio). LC50 (96 h): 175
mg/l Species : Carp (Cyprinus carpio). EC50(96h):718mg/l Species : Grass shrimp (Palaemonetes).
EC100 (96 h): 1,000 mg/l Species : Mud crab (Neopanope). EC0 (96 h): 750 mg/l Species : Mud crab
(Neopanope). EC50 (72 h): 84 mg/l Species: Scenedesmus subspicatus
Toxicity to other organisms : No data available.
Persistence and degradability
Biodegradability : According to the results of tests of biodegradability this product is not
readily biodegradable.
Mobility : No data available.
Bioaccumulation : No data is available on the product itself.
-----------------------------------------------XIII. Disposal Information--------------------------------------------------
Dispose in compliance with local, state, and federal regulations.
Form F 7.3.29
Rev: B
Page: 5 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
------------------------------------------------XIV. Transport Information---------------------------------------------------
DOT
DOT Proper Shipping Name: Amines liquid Corrosive, n.o.s
Technical Name (tetraethylenepentamine and Tris-2,4,6-(dimethylaminomethyl)phenol))
Hazard Class: 8
UN/ID Number: UN2735
Packing Group II .
For material in inner packagings not over 1 liter (0.3 gallon) can be classified Consumer Commodity
ORM-D.
IATA
Proper Shipping Name: Amines liquid Corrosive, n.o.s
Technical Name (tetraethylenepentamine and Tris-2,4,6-(dimethylaminomethyl)phenol)
Hazard Class: 8
UN/ID Number: UN2735
Packing Group II .
IMDG
Proper Shipping Name: Amines liquid Corrosive, n.o.s
Technical Name (tetraethylenepentamine and Tris-2,4,6-(dimethylaminomethyl)phenol))
Hazard Class: 8
UN/ID Number: UN2735
Packing Group II
TDG
Proper Shipping Name: Amines liquid Corrosive, n.o.s
Technical Name (tetraethylenepentamine and Tris-2,4,6-(dimethylaminomethyl)phenol))
Hazard Class: 8
UN/ID Number: UN2735
Packing Group II
------------------------------------------------XV. Regulatory Information--------------------------------------------------
All ingredients are listed on the U.S. EPA TSCA inventory of chemical substances.
SARA Section 311/312 Hazard Classification: Immediate (Acute) Health, Delayed (chronic) Health.
W.H.M.I.S. Code E
Form F 7.3.29
Rev: B
Page: 6 of 6
MATERIAL SAFETY DATA SHEET Date: 01/25/07
------------------------------------------------XVI Other Information---------------------------------------------------------
This information is furnished without warranty, representation, inducement or license of any kind;
except that it is accurate to the best of our knowledge, or obtained from sources believed by us to be
accurate.
|