Tuesday, August 30, 2005
Page 1 of 4
MSDS - Material Safety Data Sheet
Product Name: NAPA MAC'S CARBURETOR CLEANER WITH DIPPING
BASKET
MSDS No.: 6402
I. Basic Information:
Manufacturer: Balkamp Inc.
2
Address: 2601 S. Holt Road
City, ST Zip: Indianapolis, IN 46241
2 0
Emergency Contact:
Emergency Telephone Number:
Contact:
Information Telephone Number: 317-244-7241
2
2
Last Update: 08/30/2005
0
X Liquid Gas Solid
Chemical State:
C
Pure Mixture
X
Chemical Type:
II. Ingredients:
Trade Secret
EHS IARC SARA
313 OSHA ACGIH Other
% Range NTP SUB Z PEL TLV Limits
CAS No. Chemical Name
95636 1,2,4-Trimethylbenzene 1-5 N/E 25 ppm
X
111762 2-Butoxyethanol 10.0 - 30.0 25 ppm 25 ppm
X
91203 Naphthalene 1-5 10 ppm 10 ppm 10 ppm
X
64742467 Petroleum Distillate, Hydrotreated 10.0 - 30.0 5 mg/m3 (m 5 mg/m3 (m
Middle
64742945 Petroleum naphtha 10.0 - 30.0 N/E N/E 100 ppm
X
31138655 Sodium Glucohrptonate 0.1 - 1.0 N/E N/E
61790123 Tall Oil Fatty Acid 5.0 - 10.0 N/E 10 mg/m3
102716 Triethanolamine 1-5 N/E 5 mg/m3
III. Hazardous Identification:
Hazard Category:
X Acute X Chronic X Fire Pressure Reactive
Hazardous Identification Information:
Danger: Combustible. Harmful or fatal if swallowed. Eye and Skin Irritant.
IV. First Aid Measures:
Route(s) of Entry:
Absorption, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See Signs and Symptoms
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritating to the respiratory tract. . Repeated exposure may cause narcosis..
Ingestion: HARMFUL OR FATAL IF SWALLOWED.
Tuesday, August 30, 2005
Page 2 of 4
MSDS - Material Safety Data Sheet
Product Name: NAPA MAC'S CARBURETOR CLEANER WITH DIPPING
BASKET
MSDS No.: 6402
Medical Conditions Generally Aggravated by Exposure:
None known
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash with soap and water thoroughly. If irritation persist, get prompt medical attention. Launder contaminated
clothing before reuse.
Inhalation: Remove to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately.
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially
fatal condition.
V. Fire Fighting Measures:
Flash Point: 146?F Lower Explosive Limit: N/D Upper Explosive Limit: N/D
F.P. Method: TCC
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Special Fire Fighting Procedures:
Wear self-contained positive pressure breathing apparatus and protective clothes. Cool containers with a water fog. Do not use
forced water stream as this could cause the fire to spread.
Unusual Fire and Explosion:
Toxic fumes, gases or vapors may evolve on burning. Vapors may be havier that air and may travel along the ground to a distant
ignition source and flash back.
VI. Accidental Release Measures:
Steps to be Taken in Case Material is Released or Spilled:
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill until clean-up has
been completed. Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags, etc).
Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible, vacuum
spilled liquid using an explosion proof vacuum to recover material. Prevent run-off to sewers, streams, or other bodies of water. If
run-off occurs, notify proper authorities as required that a spill has occured.
VII. Handling and Storage:
Precautions to be Taken:
Use with adequate ventilation and proper protective equipment.
Do not use or store near fire, sparks, or open flame.
Other Precautions:
Keep container closed tightly when not in use. CAUTION: Combustible.
Store in a cool place away from ignition sources and oxidizing agents.
VIII. Exposure Controls/Personal Protection:
Ventilation Requirements:
See Section 2 for applicable exposure limits. Maintain adequate ventilation.
Avoid breathing vapors. In restricted areas, use respirator with approved chemical filters designed to remove vapor. In confined
areas, use approved air line type respirator or hood. A self-contained breathing apparatus is required for vapor concentrations
above TLV limit
Personal Protective Equipment:
See Section 2 for applicable exposure limits. For prolonged exposure wear protective goggles, gloves, and apron.
Tuesday, August 30, 2005
Page 3 of 4
MSDS - Material Safety Data Sheet
Product Name: NAPA MAC'S CARBURETOR CLEANER WITH DIPPING
BASKET
MSDS No.: 6402
IX. Physical and Chemical Properties:
Boiling Point: > 212 F Melting Point: N/A
Evaporation Rate (Butyl Acetate = 1): N/D Vapor Pressure (mm Hg.): see below
Specific Gravity (H20 = 1): 0.91700 Vapor Density (AIR = 1): N/D
Solubility In Water: Emulsifies Appearance and Odor: Clean amber color liquid, aromatic solvent odor.
Other Information: VOC Contents: <45%
Vapor Pressure: < 1.0 mm Hg @ 20癈
X. Stability and Reactivity:
Stability:
Stable
Incompatibility (Materials to Avoid):
Strong oxidizing agents
Decomposition/By Products:
Products of combustion: carbon oxides, oxides of nitrogen, smoke
Hazardous Polymerization:
Will not occur
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or
bottle by using the product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose
of unused product in accordance with all local, state government and federal laws and regulations
XIV. Transport Information:
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
XV. Regulatory Information:
Tuesday, August 30, 2005
Page 4 of 4
MSDS - Material Safety Data Sheet
Product Name: NAPA MAC'S CARBURETOR CLEANER WITH DIPPING
BASKET
MSDS No.: 6402
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
Pennsylvania Right to Know:
1,2,4 Trimethyl benzene (95-63-6)
Naphthalene (91-20-3)
New Jersey Right to Know:
1,2,4 Trimethyl benzene (95-63-6)
Naphthalene (91-20-3)
Warning: This product contains a chemical known to the State of California to cause cancer.
XVI. Other Information:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye.
KEEP AWAY FROM CHILDREN AND ANIMALS!
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
While Balkamp Inc. believes this data is accurate as of the revision date, we make no warranty with respect to the data and we
expressly disclaim all liability for reliance thereon. The data is offered soley for information, investigation, and verification. Various
government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product
which may not be covered by this MSDS. The user is repsonsible for full compliance.
|