#125
MATERIAL SAFETY DATA SHEET
3 Flammability = 0 Reactivity = 0
NFPA RATING: Health =
3 Flammability = 0 Reactivity = 0
HMIS RATING: Health =
SECTION I 鈥? IDENTITY AND MANUFACTURER'S INFORMATION (538N-65A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: EXTRA STRENGTH CSP CLEANER
Address: 302 North Fourth Street Date Prepared: January 16, 2007
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire,
exposure or accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II 鈥? INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: OTHER LIMITS
Common Name(s) CAS# OSHA PEL ACGIH TLV RECOMMENDED %
1 mg/M3 1 mg/M3
Phosphoric acid * (1) 7664-38-2 N/A 15-20
Butyl cellosolve (2-Butoxyethanol) * 111-76-2 25 ppm 25 ppm N/A 1-3
(2)
Water 7732-18-5 none none N/A ---
*This product contains the following chemicals subject to the reporting requirements of SARA Title III, Sec. 313, and 40 CFR Part
372: Phosphoric acid and 2-Butoxyethanol.
(1) Regulated by OSHA, CT, FL, IL, LA, MA, NJ, NY, PA, RI
(2) Regulated by OSHA, FL, IL, LA, MA, NJ, PA, RI
VOC = 13 g/1.; VOC less water = 102 g/1.
SECTION III 鈥? PHYSICAL / CHEMICAL CHARACTERISTICS
corr. Specific Gravity (H2O = 1): 25潞C = 1.09 & 39潞C = 1.09
Boiling Point: 195掳F
17.5 avg. 83
Vapor Pressure (mm Hg.): Percent Volatile by Volume (%):
0.6 slower than 1
Vapor Density (AIR = 1): Evaporation Rate (ethyl ether =
1):
appreciable Appearance and Odor: colorless, slightly hazy, heavy-bodied liquid; lemon
Solubility in Water:
odor
SECTION IV 鈥? FIRE AND EXPLOSION HAZARD DATA
none (P.M.C.C.) N/A UEL = N/A
Flash point: Flammable Limits: LEL =
Extinguishing Media: Carbon dioxide, foam or dry chemical
Special Fire Fighting Procedures: Hot phosphoric acid is corrosive. Wear protective clothing to avoid contact with skin
or eyes.
Unusual Fire and Explosion Hazards: Keep away from heat, sparks and open flames. May generate hydrogen gas in
contact with some metals.
SECTION V 鈥? PHYSICAL HAZARDS
Stable None known
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Corrodes some metals and alloys; cyanides and strong alkalis.
Hazardous Decomposition Products or Byproducts: Hydrogen gas from contact with some metals (contains some
corrosion inhibitors and is not expected to cause any problems with sewage pipes).
Will not occur Not pertinent
Hazardous Polymerization: Conditions to Avoid:
SECTION VI 鈥? HEALTH HAZARD DATA
By mist Skin? Yes Ingestion? Yes
Routes of entry: Inhalation?
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Short-term exposure to the acid or its solutions may cause eye and skin burns. Spray mist may irritate nose and throat.
2. Chronic exposure may produce severe skin and eye burns.
Chemical listed as Carcinogen or Potential Carcinogen:
No No No
National Toxicology Program = I.A.R.C. Monographs = OSHA =
This product has no carcinogens listed by IARC, NTP, NIOSH, or ACGIH as of this date, greater than or equal to 0.1%.
page 2 of #125 - Extra Strength CSP Cleaner
SECTION VI 鈥? HEALTH HAZARD DATA cont.
Signs and Symptoms of Exposure: Contact: burns of eyes, skin and on mouth and lips after ingestion, with sour taste of acid;
severe gastrointestinal irritation, nausea, vomiting, bloody diarrhea.
Medical Conditions Generally Aggravated by Exposure: Not applicable
Emergency and First Aid Procedures: Ingestion: Immediately give large amounts of water and call a physician, hospital
emergency room or poison control center. If excess inhaled remove to fresh air. In case of contact, immediately flush eyes or skin
with plenty of water for 15 minutes; remove contact lenses and flush eyes again with water. For eyes, CALL A PHYSICIAN. If
skin irritation persists, get medical attention. Remove and wash all contaminated clothing before reuse.
SECTION VII 鈥? PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Collect spilled acid in most convenient and safe manner for
reclamation. Absorb liquid in vermiculite, dry sand or similar material and dispose of in a secured sanitary landfill according to
state, federal and local regulations.
Waste Disposal Method: Since pH is less than 1, material is classified as corrosive material per EPA definition of hazardous waste
regarding pH. Dispose of concentrated material in accordance with local pollution regulations. Do not put in storm drains.
Precautions To Be Taken In Handling And Storing: Keep container closed when not in use.
Other Precautions: Contact lenses should not be worn when working with this chemical. Use with adequate ventilation. Avoid
breathing vapors or spray mist. Open windows and doors, use exhaust fans or other means to insure fresh air entry during
application and drying. Refer to OSHA Standard 29 CFR 1910.94 for technical guidelines on keeping air contamination below
acceptable exposure limits.
SECTION VIII 鈥? CONTROL MEASURES
Respiratory Protection (Specify Type): NIOSH approved self-contained breathing apparatus in areas with high mist
concentrations.
Ventilation:
Local Exhaust = If required to maintain Acceptable Special N/A Other N/A
Mechanical (General) =
TLV = =
Chemical safety goggles
Protective Gloves: Acid-resistant rubber Eye
Protection:
Other Protective Clothing or Equipment: Acid-resistant aprons, or suits as required; rubber footwear where applicable.
Work / Hygienic Practices: Wash thoroughly from skin.
SECTION IX 鈥? TRANSPORTATION INFORMATION
Applicable regulations: DOT = Yes; IMCO = Yes; IATA = Yes
Proper shipping name (Quart and Gallon Boxes) for U.S. Highway: Consumer Commodity ORM-D
Proper shipping name (55 Gallon Drums) for U.S. Highway: Compounds, cleaning liquid, (Phosphoric acid), 8, NA 1760, PG
III
UN No.: UN1760 Limited Qty.: not applicable Hazard Class: 8
Label required: not required on quart and gallon boxes by highway; 55 gallon drum = Corrosive Label
DOT Exception: not applicable
EPA Hazardous waste/number code: not listed
Hazardous waste characteristics:
Ignitability = not applicable; Corrosivity = yes; Reactivity = not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET.
The information and recommendations contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR
1910.1200 of the Occupational Safety and Health Standards Hazard Communication Rule. All information contained herein
is presented in good faith and is believed to be appropriate and accurate.
THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE OR DISPOSAL OF THIS
PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL, STATE OR LOCAL
REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|