MSDS Material Safety Data Sheet


File Name: 107-21-1.asp

                             MATERIAL SAFETY DATA SHEET
Product Name: CCW AWP (All weather Primer)
Synonyms: Water-Based Primer

Manufacturer/Supplier Phone Numbers
Medical Emergency:
Carlisle Coatings & Waterproofing Incorporated
900 Hensley Lane CHEMTREC (USA): (800) 424-9300
Wylie, TX 75098 CHEMTREC (International):
Internet Address: MSDS Assistance: (972) 442-6545
Fax Number: (972) 442-0076 Fax On Demand: NA
Technical Assistance: (888) 229-2199
Customer Service: (888) 229-0199
Component CAS No. Percent Range Hazardous in Blend
Ethylene Glycol 107-21-1 0.2 鈥? 1

This product is not hazardous according OSHA 29 CFR 1910.1200.
Flammable/Combustible No. Acute Toxin No Chronic Toxin No Carcinogen No
Pressure No Reactive No Exposure Limit Target Organ Other

2A. OTHER INGREDIENTS Greater than 3%
Component CAS No.
Latex Mixture
Latex Mixture
Latex Mixture


Emergency and Hazards Overview:
May cause moderate irritation to eyes. May be harmful if swallowed. Read and understand all health and
safety information on the product label and Material Safety Data Sheet before use.
Health 1 Flammability 0 Reactivity 0
Primary Route of Exposure: Skin x Inhalation x Eye x Ingestion x
Health Effect Information
Eye Contact: May cause eye irritation if wiped or rubbed into eyes.
Skin Contact: May cause mild skin irritation on prolonged or repeated contact.
Inhalation: Vapor and mist may cause respiratory irritation, dizziness and/or nausea, tightness of chest,
shortness of breath, headache. Ethylene glycol is very toxic in particular form upon inhalation.
Ingestion: Ingestion of large quantity may cause initial central nervous system stimulation, followed by
Medical Conditions Aggravated by Exposure: Prolonged exposure to vapors could aggravate preexisting
disorders in lungs, kidney and liver.

CCW AWP (All Weather Primer) Issued: 06/10/04
Supersedes: 04/08/03
Page 1 of 5

Eye Contact: Flush with water for 15 minutes. Get medical attention immediately.
Skin Contact: Wipe off and wash skin with soap and water. Promptly remove contaminated clothing and
wash before reuse

Inhalation: Remove to fresh air. If breath has stopped, start artificial respiration. Oxygen may be
administered. Consult physician immediately.
Ingestion:. Do not induce vomiting unless directed to do so by a physician. Consult a physician
Notes to Physician: This product contains ethylene glycol, not in reportable quantity.


Flammable Properties
Flash Point: NA Test Method: NA
Flame extension: NA Test Method: NA
Flammable Limits in Air
Upper Percent: NA
Lower Percent: NA
Autoignition Temperature: NA Test Method: NA
NFPA Classification: H 1 F 0 R 0
Extinguishing Media: CO2, foam, and dry chemical or water spray.
Fire Fighting Measures
Special Fire Fighting Procedures and Equipment: Firemen must wear full-face air-supplied masks and
full protective clothing.
Unusual Fire and Explosion Conditions: None known.
Hazardous Combustion By-Products: CO, CO2, unburned hydrocarbons. Emits acrid fumes.

Personnel Safeguards: Evacuate non-essential personnel to safe areas. Clean-up responders should wear
proper protective clothing and gloves before entering the affected area.
Regulatory Notifications: Certain component of this product is defined as hazardous according to U.S.
EPA. Spill reporting requirements and reportable quantities vary by region.
Consult all applicable state and local regulations. For Canada, observe all
precautions noted above.
Containment and Clean up: Prevent Product from entering drinking water supplies or streams. Observe
above precautions, collect liquid with inert, noncombustible material and remove for disposal.

Handling: Avoid prolonged contact with skin. Use protective gloves. Avoid rubbing eyes while
Storage: Store in dry, cool environment. Keep containers closed when not in use.
Empty Container Warnings
Drums: Drums may be reused after wash.
Plastic: Plastic containers may be reused after wash.

CCW AWP (All Weather Primer) Issued: 06/10/04
Supersedes: 04/08/03
Page 2 of 5

Exposure Limits and Guidelines

Component CAS No. Exposure Limit
Ethylene Glycol 107-21-1 50 ppm OSHA PEL/Ceiling
Personal Protective Equipment
Eye/Face Protection: Wear safety goggles. Contact lenses should not be worn.
Skin Protection: Use protective rubber gloves.

Respiratory Protection: Provide adequate ventilation to maintain vapors below PEL/TWA. If vapor
levels are exceeded, use NIOSH approved respirator, both during and
immediately after application, until vapor levels are below limits.
Personal Hygiene: Avoid rubbing eyes during handling. Use good personal hygiene practices to avoid
incidental ingestion.
Engineering Controls / Work Practices
Ventilation: Provide local exhaust or area ventilation to maintain concentration of vapors below
Other: Source of clean water should be available in the work area for flushing eyes and skin. Wash
thoroughly with soap and water after use and before eating.

Appearance: Pale blue liquid Vapor Pressure: 17 mm Hg @ 20掳C
Odor: Typical latex odor
Physical state: Liquid Vapor Density (air=1): pH: Slight basic Percent Volatile by Volume: 60-70
DOT Corrosivity: NA Volatile Organic Content: 34 g/liter (less
Molecular Weight: NA
Boiling Point: 212掳F
Melting Point: NA Average Carbon Number: NA
Specific Gravity: 1.02 Viscosity @ 77 F: 60 鈥? 90 cps
Pour Point: NA
Solubility in Water: Miscible with water
Octanol / Water Coefficient: Log Kow = NA


Chemical Stability: Stable
Conditions to Avoid: Avoid extreme heat, fire and temperature.
Incompatible Materials to Avoid: Avoid strong acids, strong oxidizers.
11. TOXICOLOGICAL INFORMATION (will only print available data)
Ethylene Glycol
Primary Eye Irritation: Irritating
Primary Skin Irritation: NA
Acute Dermal Toxicity: Product toxicity has not been determined.
Subacute Dermal Toxicity: NA
Dermal Sensitization: NA
Inhalation Toxicity: Product toxicity has not been determined.

CCW AWP (All Weather Primer) Issued: 06/10/04
Supersedes: 04/08/03
Page 3 of 5
Inhalation Sensitization: NA
Oral Toxicity: Product toxicity has not been determined. Following are component data:
LD50, Ethylene Glycol: Rat 4,000 mg/kg
Mutagenicity: NA
Carcinogenicity: NA
Reproductive Toxicity: Product toxicity has not been determined. Following are component data:
Ethylene Glycol: Pregnant Rat 1.25g/kg and above: increased malformed fetus
Pregnant Mice 750 mg/kg and above: increased malformed fetus
Teratogenicity: NA
Immunotoxicity: NA

Neurotoxicity: NA
Other: No other toxicological information available
Ethylene Glycol
Aquatic Toxicity: Not known
Terrestrial Toxicity: Not known
Chemical Fate and Transport: Not known
No other ecological information available

Regulatory Information: Consult all regulations (federal, state, provincial, local etc.) or a qualified waste
disposal firm when characterizing waste for disposal.
Waste Disposal Methods: Dispose of waste in accordance with local, state and federal EPA regulation.

U.S. Department of Transportation (DOT)
Highway / Rail (Non-Bulk): Not regulated
The DOT description is provided to assist in the proper shipping classification of this product and
may not be suitable for all shipping descriptions.
Other: No other information available.
15. Regulatory Information
Regulatory Lists
U.S. TSCA Inventory: All components of this material are on the US TSCA Inventory or exempt from
listing on the TSCA Inventory.
Sara Section 313: This product contains the following Sara, Title III, Section 313 Chemicals:
Chemical CAS Number Percent in Product
Ethylene Glycol 107-21-1 50 ppm OSHA PEL/Ceiling
IARC Group: NA
Regulatory Lists Searched
Health & Safety: NA
Environmental: NA
International: NA
State: NA
National Inventories: NA
SARA 311 / 312 Categories
No No Fire: No No No
Acute: Chronic: Pressure: Reactive:
Not Regulated:
California Proposition 65 Information: Warning! None in the list.

CCW AWP (All Weather Primer) Issued: 06/10/04
Supersedes: 04/08/03
Page 4 of 5
Canadian WHMIS Classification
Class: Not applicable
Division: Not applicable
This product has been classified in accordance with hazard criteria of the Controlled Products
Regulations (CPR). This MSDS contains all the information required by the CPR.

Other Regulations: No other information available.


Health and Environmental Label Language
All ingredients contained in this product are included on the US EPA Toxic Substances Control Act
(TSCA) inventory or exempt from listing on the TSCA inventory. All ingredients contained in this
product comply with the requirements of the Canadian Environmental Protection Act (CEPA) and are
listed on the Domestic Substance List (DSL) or Non-Domestic Substance List (NDSL)

MSDS Revisions
Previous Version Date: 4/8/03
Old Information:
New Information:

Prepared By: R&D Date: 7/23/04

Disclaimer of Warranty: The information contained herein is based upon data and information available
to us, and reflects our best professional judgment. This product may be formulated in part with
components purchased from other companies. In many instances, especially when proprietary or trade
secret materials are used, Carlisle Coating and Waterproofing Inc. rely upon the hazard evaluation of such
components submitted by that product鈥檚 manufacturer or importer. No warranty of merchantability, fitness
for any use, or any other warranty is expressed or implied regarding the accuracy of such data or
information. The results to be obtained from the use thereof, or that any such use does not infringe any
patent, since the information contained herein may be applied under conditions of use beyond our control
and with which we may be unfamiliar, we do not assume responsibility for the results of such application.
This information is furnished upon the condition that the person receiving it shall make his own
determination of the suitability of the material for his particular use.

CCW AWP (All Weather Primer) Issued: 06/10/04
Supersedes: 04/08/03
Page 5 of 5

10213-79-3.asp 10213-79-3 61788-90-7 66455-29-6 107-98-2
7440-43-9.asp 7440-43-9 7440-50-8 7440-22-4 7723-66-6 7440-02-0 10043-35-3
01-16-0.asp 01-16-0 7439-89-6 7440-47-3 7440-02-0 7789-75-5 7439-96-5 13463-67-7 7440-32-6 14808-60-7 69012-64-2 1317-65-3 7439-98-7 7440-67-7 7440-03-1 7440-50-8
breedinginsulation_us_MSDS__ELASTOMERIC_FOAM_0803.asp N/A
64742-88-7.asp 64742-88-7 7785-70-8
108-88-3.asp 108-88-3
64742-82-1.asp 64742-82-1 95-63-6 1330-20-7 108-67-8 100-41-4
64-17-5.asp 64-17-5 71-23-8 67-56-1
1330-20-7.asp 1330-20-7 71-63-3
64742-82-1.asp 64742-82-1 8052-41-3
64742-82-1.asp 64742-82-1 8052-41-3
64742-82-1.asp 64742-82-1 8052-41-3
64-17-5.asp 64-17-5 7664-41-7 67-56-1
64742-82-1.asp 64742-82-1 95-63-6 1330-20-7 108-67-8 100-41-4
68476-40-4.asp 68476-40-4 95-63-6 64742-95-6 1330-20-7
briwax_com_touchup.asp N/A
briwax_com_waterbaseddye.asp N/A
briwax_com_waxstick.asp N/A
60-00-4.asp 60-00-4 1310-58-3 7732-18-5
broward_k12_fl_us_RMD_Annual_Report_2003.asp N/A
btfbio_com_BioBall_MSDS_Issue_5_230108.asp N/A
btinternet_com_Europrevmsds.asp N/A
78-93-3.asp 78-93-3 131-11-3 7722-84-1 1338-23-4
bugspray_com_bp1l.asp N/A
bugspray_com_ffl.asp N/A
71751-41-2.asp 71751-41-2
bugspray_net_eatons_4_the_birds_gel_msds.asp N/A
bugspray_net_eatons_4_the_birds_msds.asp N/A
calypte_com_120164_Rev_2_MSDS__NonReactive_Control.asp N/A
calypte_com_120176_Rev_2_MSDS__Low_Positive_Urine_Control.asp N/A
7775-27-1.asp 7775-27-1 7727-21-1 061-00-1
campbellchemicals_com_au_MSDSPennside.asp N/A
9055-00-9.asp 9055-00-9 14464-46-1
8007-24-7.asp 8007-24-7
002699-79-8.asp 002699-79-8
26002-80-2.asp 26002-80-2 28057-48-9 124-38-9 64742-47-8
107-21-1.asp 107-21-1
60-29-7.asp 60-29-7 64-17-5
64-17-5.asp 64-17-5 7664-41-7
7664-38-2.asp 7664-38-2 111-76-2 7732-18-5
497-19-8.asp 497-19-8
castaldo_com_msds_gl_wl.asp N/A
101-68-8.asp 101-68-8
castaldo_com_msds_lqcst_b.asp N/A
castaldo_com_msds_qsil_a.asp N/A
castaldo_com_msds_qsil_b.asp N/A
castaldo_com_nsp99.asp N/A
castaldo_com_spray.asp N/A
catalog_bd_com_msdsocrmsabs.asp N/A
67-68-5.asp 67-68-5


Chemical Information Net chemcas.orgCopyright Reserved

Trading Lead

Leputech HPLC Laboratory