M ATERIAL S AFETY D ATA S HEET
1393 East Highland Road
JT EATON STICK-EM 庐 GLUE PRODUCTS Twinsburg, OH 44087 鈥? U.S.A.
1
SECTION 鈥? IDENTIFICATION
H M I S R a t i n g : Health: 1
I D E N T I T Y: Flammability: 1
JT EATON STICK-EM GLUE PRODUCTS Reactivity: 0
EPA Registration No. N O N E Personal Protection: -
ACTIVE INGREDIENT CHEMICAL NAME: NONE Other:
CHEMICAL FAMILY: Hot Melt Adhesive/Thermoplastic
Manufacturer's Name: Emergency Telephone Number: 1-800-664-9042 or
J.T.EATON & CO., INC.
National Pesticide Telecommunications Network at 1-800-858-7378
1393 East Highland Road
Telephone Number for Information:
Twinsburg, Ohio 44087
9 AM to 5 PM EST - 330-425-7801
Prepared by: Bart Baker Date Prepared: November 03, 2006
2
SECTION HAZARDOUS INGREDIENTS
<-OSHA LIMITS -> OPTIONAL
HAZARDOUS COMPONENTS CAS NUMBER PEL STEL CEILING A C G I H T LV %
NONE N/A N/A N/A N/A N/A
This Material Safety Data sheet is prepared to comply with the United States Occupational Safety and Health Administration (OSHA)
Hazard Communication Standard (29 CFR 1910.1200) and the Canadian Workplace Hazardous Material Information System (WHMIS).
Unlisted ingredients are not "hazardous" per the OSHA standard and/or are not found on the WHMIS ingredient disclosure list.
3
SECTION 鈥? PHYSICAL / CHEMICAL DATA
BULK DENSITY: 7.75 lbs. gallon
BOILING POINT: (F): N/A
MELTING POINT: 325掳 F
VAPOR PRESSURE: (mm hg): Negligible at Ambient.
EVAPORATION RATE (Butyl Acetate = 1): Negligible
VAPOR DENSITY: (AIR = 1): N/A
% VOLATILE: N/A
SOLUBILITY IN H2O: Insoluble
SPECIFIC GRAVITY (H2O = 1): 0.93 APPEARANCE / ODOR: Clear to pale yellow tacky solid.
Characteristic Odor: Petroleum odor.
4
SECTION 鈥? FIRE & EXPLOSION HAZARD DATA
FLASH POINT (Method Used) - >170掳 C (>340掳 F) PM SPECIAL FIRE FIGHTING PROCEDURES: Fire fighters should
wear butyl rubber boots, gloves and body suit and a self
FLAMMABLE LIMITS: N/A LEL: N/A UEL: N/A
contained breathing apparatus.
EXTINGUISHING MEDIA: In case of fire use: Water Spray, Carbon
UNUSUAL FIRE & EXPLOSION HAZARDS: No known
Dioxide (CO2).
unusual hazards in a fire explosion situation.
5
SECTION 鈥? REACTIVITY DATA
HAZARDOUS DECOMPOSITION PRODUCTS (from
CHEMICAL STABILITY: Stable.
burning, heating, or reaction with other materials):
CONDITIONS TO AVOID: Not applicable.
Carbon Dioxide in fire. Carbon Monoxide in fire.
INCOMPATIBLE MATERIALS: Strong oxidizing agents. Potentially irritating and toxic fumes at elevated
temperatures.
HAZARDOUS POLYMERIZATION: Will not occur.
6
SECTION 鈥? HEALTH HAZARD DATA
INHALATION? SKIN? INGESTION?
ROUTES OF ENTRY: MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: None known.
NO YES YES EMERGENCY AND FIRST AID PROCEDURES:
HEALTH HAZARDS (ACUTE and CHRONIC):None known at ambient EYES: Immediately flush eyes with water for at least 15 minutes.
temperatures. For hot product, inhalation of vapors may cause Call a physician.
SKIN: Wash affected area with soap and water. For hot product,
irritation in the respiratory tract. Small ingested amounts are not
immediately immerse in or flush the affected area with large amount of
expected to produce adverse health effects. Larger quantities (>1 oz.)
cold water to dissipate heat and reduce the extent of the thermal burns.
should be recovered from the stomach by aspiration. Call a physician.
Call a physician.
CARCINOGENICITY: None known.
INHALATION: Move patient to fresh air. Call a physician.
NTP? IARC MONOGRAPH? OSHA REGULATED? INGESTION: Small ingested amounts are not expected to produce
adverse health effects. Larger quantities (>1 oz.) should be
NO NO NO
recovered from the stomach by aspiration. Call a physician.
M ATERIAL S AFETY D ATA S HEET
1393 East Highland Road
Twinsburg, OH 44087 鈥? U.S.A.
SECTION 7 鈥? PRECAUTIONS FOR SAFE HANDLING
IN CASE MATERIAL IS RELEASED OR SPILLED: Material is a solid WASTE DISPOSAL METHOD: Landfill or incinerate in accordance
adhesive. The material will not flow out. f recovery is not feasible, add with local, state and federal regulations.
mix with dry soil, sand or non-reactive absorbent and place in a container
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
or dumpster pending disposal. Shovel spilled material into empty, dry
Keep in cool, dry, well ventilated storage areas. Handle in well
container for later disposal or recovery. Wash down affected area with
ventilated areas.
mineral spirits or baby oil to remove material from surface of floor. Follow
by washing area with soap and water.
8
SECTION 鈥? CONTROL MEASURES
RESPIRATORY PROTECTION: Not required under normal conditions. EYE PROTECTION: Splash proof eye goggles. Where contact
For emergency situations use self contained breathing apparatus with may occur with hot materials, wear a face shield.
pressure demand mode.
WORK / HYGIENIC PRACTICES: Provide readily accessible
VENTILATION: eye wash stations. Wash promptly if skin becomes
LOCAL EXHAUST: NO contaminated. Remove from skin with vegetable oil.
SPECIAL: NO
MECHANICAL EXHAUST: NO
PROTECTIVE GLOVES: Rubber gloves, latex rubber. Contact with hot
materials, wear thermal resistant gloves and arm protection.
9
SECTION 鈥? CALIFORNIA ADDENDUM
(PROPOSITION 65) SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
The following specific warnings are hereby given relative to substances that the State of California has identified as
carcinogens and/or reproductive hazards under Proposition 65:
WARNING: None WARNING: None
10
SECTION 鈥? SARA TITLE III HAZARD CATEGORY
For Reporting Under Sections 311 & 312
Immediate - NO Delayed - NO Fire - NO Reactive - NO Sudden Release of Pressure - NO
SARA Title III (40CFR311/312) Hazard category: Not applicable.
SARA Title III Section 313 Toxic chemical substances present at above de-minimus concentrations: None
11
SECTION 鈥? SHIPPING INFORMATION
Manufacturer makes no warranty, express or implied,
HAZARD CLASS: D.O.T. Placarding Not Required
other than indicated on Label and MSDS. Customer
BILL OF LADING DESCRIPTION: Adhesive Glue Traps Item 187120
assumes all risk of use and/or handling of this material
Sub Class 70 Density 16 lbs/CU Ft. when such use and / or handling is contrary to Label
Insecticides Item 102120 Class 60 and MSDS.
All information contained in this Material Safety Data Sheet is furnished free of charge and is intended for your evaluation. In our opinion
the information is, as of the date of this Material Safety Data Sheet, reliable, however, it is your responsibility to determine the suitability
of the information for your use. You are advised not to construe the information as absolutely complete since additional information may
be necessary or desirable when particular, exceptional or variable conditions or circumstances exist or because of applicable laws or
government regulations. Therefore, you should use this information only as a supplement to other information gathered by you and you
must make independent determinations of the suitability and completeness of the information from all sources to assure both proper use
of the material described herein and the safety and health of employees. Accordingly, no guarantee expressed or implied is made by
J.T. Eaton & Co., Inc. as to the results to be obtained based upon your use of the information nor does J.T. Eaton & Co., Inc. assume any
liability arising out of your use of the information.
JT EATON STICK-EM GLUE PRODUCTS
EPA Registration No. N O N E
Page 2
|