Page 1/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
* 1 Identification of substance
路 Product details
路 Trade name: CarboSorb E
路 Article number: 0LD0994
路 Application of the substance / the preparation Laboratory chemicals
路 Manufacturer/Supplier:
PerkinElmer Life & Analytical Sciences B.V.
Rigaweg 22, 9723 TH Groningen
PO Box 5205, 9700 GE Groningen
The Netherlands
Phone: (31) 50- 544 59 00
Fax: (31) 50- 544 59 50
路 Information department: Environment Health and Safety (EHS)
2 Composition/Data on components
路 Chemical characterization:
路 CAS No. Description
5332-73-0 3-methoxypropylamine
路 Identification number(s)
路 EINECS Number: 226-241-3
* 3 Hazards identification
路 Hazard description:
C Corrosive
路 Information pertaining to particular dangers for man and environment:
R 10 Flammable.
R 35 Causes severe burns.
路 Classification system:
路 NFPA ratings (scale 0 - 4)
Health = 4
3 Fire = 3
4 0 Reactivity = 0
路 WHMIS-ratings (scale 0 - 4)
HEALTH 4 Health = 4
Fire = 3
FIRE 3
Reactivity = 0
REACTIVITY 0
* 4 First aid measures
路 General information:
Take affected persons out into the fresh air.
Immediately remove any clothing soiled by the product.
路 After inhalation:
Seek medical treatment in case of complaints.
Supply fresh air.
(Contd. on page 2)
USA
DR
Page 2/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 1)
In case of unconsciousness place patient stably in side position for transportation.
路 After skin contact: Immediately wash with water and soap and rinse thoroughly.
路 After eye contact: Rinse opened eye for several minutes under running water. Then consult a doctor.
路 After swallowing: Drink copious amounts of water and provide fresh air. Immediately call a doctor.
路 Information for doctor:
路 The following symptoms may occur: Headache
* 5 Fire fighting measures
路 Suitable extinguishing agents:
Foam
Fire-extinguishing powder
Carbon dioxide
路 For safety reasons unsuitable extinguishing agents: Water with full jet
路 Special hazards caused by the material, its products of combustion or resulting gases:
Nitrogen oxides (NOx)
Carbon monoxide (CO)
路 Protective equipment:
Wear fully protective suit.
Wear self-contained respiatory protective device.
* 6 Accidental release measures
路 Person-related safety precautions:
Keep away from ignition sources
Ensure adequate ventilation
Wear protective equipment. Keep unprotected persons away.
路 Measures for environmental protection:
Dilute with plenty of water.
Do not allow to enter sewers/ surface or ground water.
路 Measures for cleaning/collecting:
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust).
Use neutralizing agent.
Dispose contaminated material as waste according to item 13.
Ensure adequate ventilation.
* 7 Handling and storage
路 Handling:
路 Information for safe handling: Work only in fume cabinet.
路 Information about protection against explosions and fires:
Keep ignition sources away - Do not smoke.
Protect against electrostatic charges.
路 Storage:
路 Requirements to be met by storerooms and receptacles: No special requirements.
路 Information about storage in one common storage facility: Not required.
路 Further information about storage conditions: Keep receptacle tightly sealed.
USA
(Contd. on page 3)
DR
Page 3/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 2)
* 8 Exposure controls and personal protection
路 Additional information about design of technical systems: No further data; see item 7.
路 Components with limit values that require monitoring at the workplace: Not required.
路 Additional information: The lists that were valid during the creation were used as basis.
路 Personal protective equipment:
路 General protective and hygienic measures:
Keep away from foodstuffs, beverages and feed.
Immediately remove all soiled and contaminated clothing.
Wash hands before breaks and at the end of work.
Avoid contact with the eyes and skin.
路 Breathing equipment: Not necessary if room is well-ventilated.
路 Protection of hands:
Protective gloves
The glove material has to be impermeable and resistant to the product/ the substance/ the preparation.
Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/
the chemical mixture.
Selection of the glove material on consideration of the penetration times, rates of diffusion and the
degradation
路 Material of gloves
The selection of the suitable gloves does not only depend on the material, but also on further marks of quality
and varies from manufacturer to manufacturer.
路 Penetration time of glove material
The exact break trough time has to be found out by the manufacturer of the protective gloves and has to be
observed.
路 Eye protection:
Tightly sealed goggles
路 Body protection: Protective work clothing
* 9 Physical and chemical properties
路 General Information
Fluid
Form:
Colorless
Color:
Amine-like
Odor:
路 Change in condition
Melting point/Melting range: -75掳C (-103掳F)
Boiling point/Boiling range: 118掳C (244掳F)
27掳C (81掳F)
路 Flash point:
270掳C (518掳F)
路 Ignition temperature:
Product is not explosive. However, formation of explosive air/vapor
路 Danger of explosion:
mixtures are possible.
(Contd. on page 4)
USA
DR
Page 4/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 3)
路 Explosion limits:
2.3 Vol %
Lower:
12.3 Vol %
Upper:
0.873 g/cm鲁
路 Density at 20掳C (68掳F):
路 Solubility in / Miscibility with
Fully miscible.
Water:
11.5
路 pH-value at 20掳C (68掳F):
10 Stability and reactivity
路 Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications.
路 Dangerous reactions No dangerous reactions known.
路 Dangerous products of decomposition:
Nitrogen oxides
Carbon monoxide and carbon dioxide
* 11 Toxicological information
路 Acute toxicity:
路 LD/LC50 values that are relevant for classification:
5332-73-0 3-methoxypropylamine
Oral LD50 690 mg/kg (rat)
路 Primary irritant effect:
路 on the skin: Strong caustic effect on skin and mucous membranes.
路 on the eye: Strong caustic effect.
路 Sensitization: No sensitizing effects known.
路 Additional toxicological information:
Swallowing will lead to a strong caustic effect on mouth and throat and to the danger of perforation of
esophagus and stomach.
* 12 Ecological information
路 Information about elimination (persistence and degradability):
路 Other information: The product is biodegradable.
路 General notes: Water hazard class 1 (Self-assessment): slightly hazardous for water
* 13 Disposal considerations
路 Product:
路 Recommendation: Must be specially treated adhering to official regulations.
路 Uncleaned packagings:
路 Recommendation: Disposal must be made according to official regulations.
路 Recommended cleansing agent: Water, if necessary with cleansing agents.
USA
(Contd. on page 5)
DR
Page 5/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 4)
* 14 Transport information
路 DOT regulations:
8
路 Hazard class:
UN2734
路 Identification number:
I
路 Packing group:
路 Proper shipping name (technical name): AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (3-
methoxypropylamine)
8+3
路 Label
路 Land transport ADR/RID (cross-border):
8 (CF1) Corrosive substances
路 ADR/RID class:
883
路 Danger code (Kemler):
2734
路 UN-Number:
I
路 Packaging group:
2734 AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (3-
路 Description of goods:
methoxypropylamine)
路 Maritime transport IMDG:
8
路 IMDG Class:
2734
路 UN Number:
8+3
路 Label
I
路 Packaging group:
F-E,S-C
路 EMS Number:
No
路 Marine pollutant:
AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (3-
路 Propper shipping name:
methoxypropylamine)
路 Air transport ICAO-TI and IATA-DGR:
8
路 ICAO/IATA Class:
2734
路 UN/ID Number:
8+3
路 Label
I
路 Packaging group:
AMINES, LIQUID, CORROSIVE, FLAMMABLE, N.O.S. (3-
路 Propper shipping name:
methoxypropylamine)
USA
(Contd. on page 6)
DR
Page 6/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 5)
* 15 Regulations
路 Sara
路 Section 355 (extremely hazardous substances):
Substance is not listed.
路 Section 313 (Specific toxic chemical listings):
Substance is not listed.
路 TSCA (Toxic Substances Control Act):
Substance is listed.
路 Proposition 65
路 Chemicals known to cause cancer:
Substance is not listed.
路 Cancerogenity categories
路 EPA (Environmental Protection Agency)
Substance is not listed.
路 IARC (International Agency for Research on Cancer)
Substance is not listed.
路 NTP (National Toxicology Program)
Substance is not listed.
路 TLV (Threshold Limit Value established by ACGIH)
Substance is not listed.
路 MAK (German Maximum Workplace Concentration)
Substance is not listed.
路 NIOSH-Ca (National Institute for Occupational Safety and Health)
Substance is not listed.
路 OSHA-Ca (Occupational Safety & Health Administration)
Substance is not listed.
路 Product related hazard informations:
Observe the general safety regulations when handling chemicals.
The product has been classified and marked in accordance with directives on hazardous materials.
路 Hazard symbols:
C Corrosive
路 Risk phrases:
10 Flammable.
35 Causes severe burns.
路 Safety phrases:
16 Keep away from sources of ignition - No smoking.
26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
路 National regulations:
路 Water hazard class: Water hazard class 1 (Self-assessment): slightly hazardous for water.
USA
(Contd. on page 7)
DR
Page 7/7
Material Safety Data Sheet
acc. to ISO/DIS 11014
Printing date 11/24/2005 Reviewed on 11/24/2005
Trade name: CarboSorb E
(Contd. of page 6)
* 16 Other information
This information is based on our present knowledge. However, this shall not constitute a guarantee for any
specific product features and shall not establish a legally valid contractual relationship.
路 Department issuing MSDS: Environment Health and Safety (EHS)
路 Contact: J. van der Weele
路 * Data compared to the previous version altered.
USA
DR
|