Material Safety Data 24 Hour Assistance:
1-847-367-7700
Sheet
Rust-Oleum Corp.
www.rustoleum.com
Section 1 - Chemical Product / Company Information
Product Name: PARKS DRUM EPOXY PART A RESIN Revision Date: 04/05/2007
Identification
241156
Number:
Product Use/Class: Super Glaze - Part A
Rust-Oleum Corporation Rust-Oleum Corporation
Supplier: Manufacturer:
11 Hawthorn Parkway 11 Hawthorn Parkway
Vernon Hills, IL 60061 Vernon Hills, IL 60061
USA USA
Preparer: Regulatory Department
Section 2 - Composition / Information On Ingredients
Chemical Name CAS Number Weight % Less Than ACGIH TLV-TWA ACGIH TLV-STEL OSHA PEL-TWA OSHA PEL -CEILING
Bis-A Liquid Epoxy Resin 25085-99-8 90.0 N.E. N.E. N.E. N.E.
O-Cresyl Glycidyl Ether 2210 -79-9 15.0 N.E. N.E. N.E. N.E.
Section 3 - Hazards Identification
*** Emergency Overview ***: Causes eye irritation. Causes skin irritation. May cause allergic skin reaction.
Effects Of Overexposure - Eye Contact: Extremely irritating to the eyes and may cause severe damage, including
blindness. Substance causes severe eye irritation. Injury may be permanent.
Effects Of Overexposure - Skin Contact: May cause skin sensitization, an allergic reaction, which becomes
evident on re-exposure to this material.
Effects Of Overexposure - Inhalation: High vapor concentrations are irritating to the eyes, nose, throat and lungs.
Effects Of Overexposure - Ingestion: Substance may be harmful if swallowed.
Effects Of Overexposure - Chronic Hazards: Reports have associated repeated and prolonged occupational
overexposure to solvents with permanent brain and nervous system damage.
Primary Route(s) Of Entry: Skin Contact, Skin Absorption, Inhalation, Eye Contact
Section 4 - First Aid Measures
First Aid - Eye Contact: Hold eyelids apart and flush with plenty of water for at least 15 minutes. Get medical
attention.
First Aid - Skin Contact: Wash with soap and water. Get medical attention if irritation develops or persists.
First Aid - Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give
oxygen. Get immediate medical attention.
First Aid - Ingestion: If swallowed, do not induce vomiting. Give victim a glass of water or milk. Call a physician or
poison control center immediately. Never give anything by mouth to an unconscious person.
Section 5 - Fire Fighting Measures
Flash Point: 294 F Lower Explosive Limit: N.A. %
(Setaflash) Upper Explosive Limit : N.A. %
Extinguishing Media: Dry Chemical, Foam, Water Fog
Unusual Fire And Explosion Hazards: FLASH POINT IS TESTED TO BE GREATER THAN 200 DEGREES F.
Special Firefighting Procedures: Full protective equipment including self-contained breathing apparatus should be
used. Evacuate area and fight fire from a safe distance. Water may be used to cool closed containers to prevent
buildup of steam.
Section 6 - Accidental Release Measures
Steps To Be Taken If Material Is Released Or Spilled: Contain spilled liquid with sand or earth. DO NOT use
combustible materials such as sawdust. Dispose of according to local, state (provincial) and federal regulations. Do
not incinerate closed containers.
Section 7 - Handling And Storage
Handling: Wash thoroughly after handling. Avoid contact with eyes, skin and clothing. Use only in a well-ventilated
area. Follow all MSDS/label precautions even after container is emptied because it may retain product residues.
Storage: Keep containers tightly closed. Isolate from heat, electrical equipment, sparks and open flame.
Section 8 - Exposure Controls / Personal Protection
Engineering Controls: Prevent build-up of vapors by opening all doors and windows to achieve cross -ventilation.
Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne levels below
recommended exposure limits.
Respiratory Protection: A respiratory protection program that meets OSHA 1910.134 and ANSI Z88.2 requirements
must be followed whenever workplace conditions warrant a respirator's use. A NIOSH/MSHA approved air purifying
respirator with an organic vapor cartridge or canister may be permissible under certain circumstances where
airborne concentrations are expected to exceed exposure limits.
Protection provided by air purifying respirators is limited. Use a positive pressure air supplied respirator if there is
any potential for an uncontrolled release, exposure levels are not known, or any other circumstances where air
purifying respirators may not provide adequate protection.
Skin Protection: Nitrile or Neoprene gloves may afford adequate skin protection. Use gloves to prevent prolonged
skin contact.
Eye Protection: Use safety eyewear designed to protect against splash of liquids.
Other protective equipment: Refer to safety supervisor or industrial hygienist for further information regarding
personal protective equipment and its application.
Hygienic Practices: Wash thoroughly with soap and water before eating, drinking or smoking. Remove
contaminated clothing immediately and launder before reuse.
Section 9 - Physical And Chemical Properties
Boiling Range: 239 - 500 F Vapor Density: Heavier than Air
Odor: Odor Threshold:
Solvent Like ND
Appearance: Evaporation Rate:
Liquid N.A.
Solubility in H2O: N.A.
Freeze Point: Specific Gravity:
N.D. 1.149
Vapor Pressure: PH:
ND N.E.
Physical State: Liquid
(See section 16 for abbreviation legend)
Section 10 - Stability And Reactivity
Conditions To Avoid: Avoid temperatures above 120 掳 F.
Incompatibility: Incompatible with strong oxidizing agents, strong acids and strong alkalies.
Hazardous Decomposition: When heated to decomposition, it emits acrid smoke and irritating fumes.
Hazardous Polymerization: Will not occur under normal conditions
Stability: Stable under normal conditions
Section 11 - Toxicological Information
Product LD50: N.D. Product LC50: N.D.
Chemical Name LD50 LC50
Bis-A Liquid Epoxy Resin >5000 MG/KG RAT N.D.
O-Cresyl Glycidyl Ether 5800 MG/KG (Oral, Rat) 1220 PPM /4HR (Rat)
Section 12 - Ecological Information
Ecological Information: Product is a mixture of listed components.
Section 13 - Disposal Information
Disposal Information: Dispose of material in accordance to local, state and federal regulations and ordinances. Do
not allow to enter storm drains or sewer systems.
Section 14 - Transportation Information
DOT Proper Shipping Name: Paint
DOT Technical Name: --- Packing Group: ---
DOT Hazard Class: Not Regulated Hazard Subclass: ---
DOT UN/NA Number: ---- Resp. Guide Page: ---
Section 15 - Regulatory Information
CERCLA - SARA Hazard Category
This product has been reviewed according to the EPA `Hazard Categories' promulgated under Sections 311and
312 of the Superfund Amendment and Reauthorization Act of 1986 (SARA Title III) and is considered, under
applicable definitions, to meet the following categories:
IMMEDIATE HEALTH HAZARD
SARA Section 313:
Listed below are the substances (if any) contained in this product that are subject to the reporting requirements of
Section 313 of Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR part 372:
Toxic Substances Control Act:
Listed below are the substances (if any) contained in this product that are subject to the reporting requirements of
TSCA 12(B) if exported from the United States:
U.S. State Regulations: As follows -
New Jersey Right-to-Know:
The following materials are non-hazardous, but are among the top five components in this product.
None
Pennsylvania Right-to-Know:
The following non-hazardous ingredients are present in the product at greater than 3%.
None
California Proposition 65:
WARNING! This product contains a chemical(s) known by the State of California to cause cancer.
WARNING! This product contains a chemical(s) known to the state of California to cause birth defects or other
reproductive harm.
International Regulations: As follows -
CANADIAN WHMIS:
This MSDS has been prepared in compliance with Controlled Product Regulations except for the use of the 16
headings.
CANADIAN WHMIS CLASS: B2 D2A D2B
Section 16 - Other Information
HMIS Ratings:
Health: 2 Flammability: 0 Reactivity: 0 Personal Protection: X
VOLATILE ORGANIC COMPOUNDS, g/l: 0 g/l
REASON FOR REVISION: Regulatory Update
Legend: N.A. - Not Applicable, N.E. - Not Established, N.D. - Not Determined
The information contained on this MSDS has been checked and should be accurate. However, it is the
responsibility of the user to comply with all Federal, State, and Local laws and regulations.
|