MATERIAL SAFETY DATA SHEET
SECTION 1 PRODUCT/MANUFACTURER S IDENTITY
Powdered Detergent/Disinfectant Formula ID Number: SP30
Product Name:
(Water Flakes? MSDS File Name: WF POWDERED DET DISINF HAZARD RATING
Concentrate In Dilution
EPA Reg #: 1839-93-3640
ST-794, ST-803
Synonyms: 4= Extreme
DOT Hazard Class: None 1 0
Flammability
3= High
Stearns Packaging Corporation DOT Shipping Name: Disinfectant, NOI, powder.
Company: 2 1
Health 2= Moderate
4200 Sycamore Ave. (53714) Item 57100, Sub. 3, Class 85 1= Slight
0 0
Reactivity
PO Box 3216 0= Insignificant
NSF Certified: None None None
Special Hazard
Madison, WI 53704-0216
800-655-5008
Phone:
Abbreviation Key: N.A.=Not Applicable,
Emergency Contact: CHEM-TEL, 800-255-3924
608-246-5149
Fax:
N.D.=Not Determined
www.stearnspkg.com
Website:
SECTION 2 HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
CHEMICAL IDENTIFICATION CAS NO. HAZARD PEL(ppm) TLV(ppm) %(Optional)
Sodium sulfate 7757-82-6
Urea 57-13-6 Irritant
Alkyl dimethyl benzyl ammonium chloride 68391-01-5 Corrosive 7.95%
Alkyl dimethyl ethylbenzyl ammonium chloride 85409-23-0 Corrosive 7.95%
Linear primary alcohol ethoxylate 68131-39-5 Irritant
Sodium carbonate 497-19-8 Irritant
SARA Section 313 Title III Notification Required: No
SECTION 3 PHYSICAL DATA
Solubility in water: Complete Vapor Pressure (mm Hg): N.A. pH (Concentrate): N.A.
Appearance and Odor:
White powder,
Boiling Point: N.A. Vapor Density (Air=1): N.A. pH (Use Dilution): 9.0
lemon scent
Melting Point: N.A. Evaporation Rate (Water=0.3): N.A. Specific Gravity: N.A.
SECTION 4 FIRE AND EXPLOSION HAZARD DATA
Flash Point and Method: Non-combustible, >200篎 Extinguishing Media: N.A.
Special Fire Fighting Procedures: Use full protective clothing and self-contained
LEL: N.A.
3
Flammable Limits
UEL: N.A. breathing apparatus.
Unusual Fire & Explosion Hazards: None
SECTION 5 REACTIVITY DATA
Chemical Stability: Stable: X Unstable: Hazardous Polymerization: May Occur Will Not Occur X
Conditions to Avoid: Freezing and extreme heat. Conditions to Avoid: None known
Incompatibility (Materials to Avoid): Combination with acids will give off carbon Hazardous Decomposition or By-Products: Carbon dioxide
dioxide.
SECTION 6 HEALTH HAZARD DATA/FIRST AID PROCEDURES
Health Hazards (Acute and Chronic): Mildly alkaline; may cause burning to Emergency and First Aid Procedures:
eyes and respiratory passages. Possible irritant to skin over Eyes: If contact occurs, flush with plenty of cool water for 15 minutes. Consult
prolonged periods of exposure. a physician.
Signs and Symptoms of Exposure: Irritation of exposed tissues, especially Skin: May be irritating to skin. Flush with water and wear gloves in the future to
eyes, skin, throat, nasal cavities, and other mucous membranes. minimize exposure. Wash hands thoroughly after handling. Discontinue
use if irritation persists and consult a physician.
Medical Conditions Aggravated by Exposure: N.D. Inhalation: Remove from exposure. Obtain medical attention immediately.
Ingestion: May be harmful if swallowed. Drink large amounts of water or milk.
Carcinogenicity: IARC Monographs? Yes No X
DO NOT induce vomiting. Get medical attention immediately. Avoid
contamination of foods.
NTP? Yes No X OSHA Regulated? Yes No X
NOTE TO PHYSICIAN: No specific antidote. Use supportive care. Treatment should be based on physician s judgment in response to the patient s
reaction.
SECTION 7 PREVENTATIVE AND CONTROL MEASURES
Ventilation: Local Exhaust: Recommended for control of dusts. Steps to be Taken if Material is Spilled or Released: Sweep up for salvage or
Mechanical: Recommended for control of dusts. disposal. Take care to avoid contact with large amounts of dust.
Skin Protection: Use neoprene, rubber, or other chemical resistant gloves. Waste Disposal: Comply with all local, state and federal regulations. Consult
Wear protective clothing to prevent repeated or prolonged contact. your state DNR or the EPA for specific questions. Wastewater should
never enter a fresh water body without treatment.
Eye Protection: Avoid eye contact.
Respiratory Protection: In general, respirators are not needed if the product is Handling and Storage: Wear all recommended safety gear. Do not mix with other
used in a well-ventilated area chemicals or cleaning agents. Avoid contact with dust.
Other Precautions: Keep out of the reach of children.
SECTION 8 OTHER REGULATORY INFORMATION
California Safe Drinking Water and Toxic Enforcement Act of 1986 No chemicals listed by California are present at a level that poses a significant risk of
causing cancer or reproductive toxicity. rev. 10/07/08
This MSDS data relates only to the material designated and does not relate to its use with any other material or process. The data is believed to be accurate. However, since use conditions
vary and are outside our control, Stearns Packaging Corporation makes no warranties, expressed or implied, and assumes no liability for failure to follow directions and safety precautions.