2003
MSDS - Clear-LayTM Rigid PVC Film
Page 1 of 2
Emergency Contact: Grafix, Inc.
19499 Miles Rd.
Cleveland, Oh. 44128
(216) 581-9050
Product Identification:
Clear-Lay is an Polyvinyl Chloride film. Various fillers or additives used to modify the physical appearance and/or surface
properties may be present. Actual formula is proprietay.
Hazardous Ingredients:
This material is not a "health hazard" as defined under the OSHA Hazard Communication Standard, 29 CFR 1910.1200 or
S.A.R.A. Title III, Section 313. This material is considered an article under OSHA and TSCA standards.
Physical-Chemical Data:
The transparent to opaque, odorless film is chemically stable and resistant to water. It has a specific gravity of 1.32 - 1.45.
Physical Hazards:
Heavy gauges of PVC Film can contain sharp edges. Proper protective gear such as gloves is recommended. The top
coating of the film can create a slip hazard when dropped on the floor. Walking areas should be kept clear of this film.
Unwinding, winding and passage of this film through and over rollers will tend to generate a strong electrostatic charge on
the web. Static discharge devices should be properly positioned at such points to eliminate the charge and prevent
uncontrolled discharge from the web. This is particularly required in potentially explosive atmospheres and to protect
personnel from the effects of static discharge.
General exhaust is acceptable except where overheating can occur during processing. High temperature are not
recommended.
?br>
GRAFIX Plastics
A Division of GRAFIX, Inc.
19499 Miles Rd. Cleveland, OH. 44128
(800) 447-2349 (216) 581-9050 FAX (216) 581-9041
E-MAIL info@grafixplastics.com WEB http://www.grafixplastics.com
2003
MSDS - Clear-LayTM Rigid PVC Film
Page 2 of 2
Health Hazard Data:
No adverse health effect have been attributed to this PVC film at ambient
temperature.
Hazard Designations
Key
Health: 1 0-None
Flamability 1 1-Slight
Reactivity 0 2-Moderate
3-Severe
4-Extreme
Control Measure and Safe Handling Procedures
The film will burn if exposed to flame. Fire fighters should protect themselves from decomposition and combustion
products that may include carbon dioxide, carbon monoxide, HCL and other such toxic gases. Wear self-contained
breathing apparatus and complete personal protective equipment when potential for exposure to products of combustion
exist. Fire fighting extinguishing media include carbon dioxide, water spray, foam or dry chemical.
Disposal and Shipping Information:
PVC film is not classified as hazardous waste under the Resource Conservation and Recovery Act, and unless prohibited by
state or local regulation, can be disposed of in a municipal landfill or incinerated. This product is not classified by the U.S.
Department of Transportation as a hazardous material.
Information Contact:
Grafix, Inc.
19499 Miles Rd.
Cleveland, OH. 44128
To the best of our knowledge the information contained herein is accurate. However, Grafix assumes no liability whatsoever, for the accuracy or
completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All material
may present unknown hazards and should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are
the on hazards which exist.
?br>
GRAFIX Plastics
A Division of GRAFIX, Inc.
19499 Miles Rd. Cleveland, OH. 44128
(800) 447-2349 (216) 581-9050 FAX (216) 581-9041
E-MAIL info@grafixplastics.com WEB http://www.grafixplastics.com
|