BONDiT B-52
MATERIAL SAFETY
DATA SHEET
SECTION I - IDENTIFICATION
PRODUCT NAME: BONDiT B-52 GENERIC DESCRIPTION: Epoxy resin
MANUFACTURER: RELTEK, LLC PROPER SHIPPING NAME (49CFR 172.101): Resin Compound
2345 Circadian Way D.O.T. HAZARD NAME (49CFR 172.101): NA
Santa Rosa, CA D.O.T. ID NO (49CFR 172.101): NA
95407 D.O.T. HAZARD CLASS (49CFR 172.101): NA
(707) 284-8808 RCRA HAZARD CLASS (49CFR 261)(if
discarded): NA
EMERGENCY: (800) 535-5053 E.P.A. PRIORITY POLLUTANTS (40CFR
122.53): ND
DATE: 02-08-07 Rev e HEALTH (NFPA): 2
SUPERSEDES: 09-26-06 Rev d FLAMMABILITY (NFPA): 1
REACTIVITY (NFPA): 0
SARA SEC 312: Fire, Pressure:, Reactivity: No, No, No
(EPCRA) Acute, Chronic: No, No
SECTION II - HAZARDOUS INGREDIENTS 29 CFR 1910.1200
------ EXPOSURE LIMITS -----
INGREDIENT C.A.S. NO. PERCENT VALUE UNIT TYPE AUTH
PART A: BISPHENOL A-EPOXY RESIN
PROPRIETARY EPOXY RESIN *See Sec IX 95 ?0% *See Sec IX
Butadiene homopolymer 129288-65-9 5 ?0% Not established
PART B: BORON COMPOUND
Proprietary boron compound Trade secret <100% Not established
SECTION III - PHYSICAL DATA
BOILING POINT: [760 MM HG] >200 C VOLATILITY BY WEIGHT: Less than 1%
SPECIFIC GRAVITY:[77EF/25EC] EVAPORATION: Not Applicable
A 1.05, B 1.42
MELTING POINT: Not Applicable SOLUBILITY IN WATER: Nil
VAPOR PRESSURE: [77EF/25EC] ODOR: A ?Clear or translucent resin
Not Established
VAPOR DENSITY: [77EF/25EC] Not Established APPEARANCE: / COLOR: B 璙iscous Brown/white liquid, slight
amine odor
SECTION IV - HEALTH HAZARD DATA
EYE: Direct contact of Part B may cause irritation and pain. Effect is Flush with a large volume of
transient and has no known residual effect. water for 15 minutes, get medical
attention.
SKIN: Direct contact may irritate; may cause allergic skin sensitization. Part B Wash immediately with water.
causes dryness, itching and/or rash. Ma y be harmful if absorbed Remove contaminated clothing. If
through the skin. Use of protective gloves and clothing are irritation develops seek medical
recommended with its use. attention.
INHALATION: Part B vapors may cause irritation o f respiratory tract if inhaled. May Remove to fresh air. Get medical
cause irritation of respiratory system, respiratory sensitization or attention if ill effects persist.
asthma like response in susceptible individuals.
ORAL May irritate digestive system. May cause tissue or digestive system Get medical attention. Gi ve one to
damage. three glasses of water.
COMMENTS: Not listed as human carcinogenic by OSHA, IARC or NTP.
PAGE 1 OF 2
B-52e.MSD.doc
SECTION V - FIRE AND EXPLOSION DATA
FLASH POINT: SPECIAL FIRE Self-contained breathing apparatus
Closed cup, 249 / 480o F
C
FIGHTING and full protective clothin g should be
AUTOIGNITION: Not determined PROCEDURES: worn. Will give rise to Class B fire.
Large fires: use Alcohol Foam, Water
FLAMMABILITY LIMITS IN LOWER: A: N/D B: N/D Spray; Small fires: Carbon Dioxide,
AIR: Dry chemical, Dry sand or limestone.
UPPER: A: N/D B: N/D
UNUSUAL FIRE
OSHA FIRE HAZARD CLASS: N/D AND EXPLOSION
HAZARDS: None.
EXTINGUISHING MEDIA: CO2 X Dry chemical X Foam X
SECTION VI - REACTIVITY DATA
STABILITY: Stable HAZARDOUS Nitrogen oxides, carbon dioxide,
DECOMPOSITION carbon monoxide and aldehydes.
INCOMPATIBILITY: None PRODUCTS: Nitrogen oxide can react with water
vapors to form corrosive nitric acid
CONDITIONS TO (TVL=2).
AVOID: See Section IX
POLYMERIZATION: Will not occur.
SECTION VII - SPILL, LEAK, MAINTENANCE/REPAIR AND DISPOSAL PROCEDURES
SPILL Use absorbent material to collect and contain for REPORTABLE CONCENTRATION: Not applicable
RESPONSE: salvage or disposal in closed container.
REPORTABLE QUANTITY: Not applicable
WASTE Dispose of completely cured material in sanitary
DISPOSAL landfill. Dispose of parts or waste products in a
METHOD: hazardous waste facility. Since regulations vary,
consult applicable regulations before disposal.
REPORTABLE None
HAZARD:
SECTION VIII - PRECAUTIONS FOR SAFE HANDLING
EYES: Safety glasses, as a minimum. EXHAUST: Recommended
MECHANICAL: Recommended
SKIN: Washing at mealtime and end of shift.
Use protective clothing; rubber or PRECAUTIONS
plastic gloves as a minimum. Wash TO BE TAKEN IN
immediately upon any detectable HANDLING AND
contact. STORING: These precautions are for room
INHALATION & temperature handling. Use at elevated
VENTILATION: Respiratory protection only required if temperatures, or aerosol/spray
work area is not well-ventilated. Use applications, may require added
NIOSH approved suitable organic precautions.
vapor respirator if necessary in that COMMENT: None
case.
SECTION IX ?COMMENTS
All components are included in the TSCA inventory. OSHA Hazard Communication Standard (29CFR1910.1200) hazard class:
Corrosive, Sensitizer. EPA SARA Title III Section 312 (40CFR370) hazard class: Irritant. EPA SARA Title III Section 313
(40CFR372): Immediate Health Hazard. Toxic chemicals above "de minimis" levels: none.
Avoid mineral acids, alkalis, organic acids, reducing agents, reactive metals (i.e. sodium). CAUTION: N-Nitrosamines, many
of which are known to be potent carcinogens, may be formed when the product comes in contact with nitrous acid, nitrites or
atmospheres with high nitrous oxide concentrations. Product slowly corrodes copper, aluminum, zinc and galvanized
surfaces.
PAGE 2 OF 2
B-52e.MSD.doc
|