NFPA Fire: 0
Material Safety Data Sheet
Health: 3
Complies with OSHA's Hazard Communication Standard 29 CFR 1910.1200
Reactivity: 0
SECTION I - IDENTITY AND MANUFACTURER'S INFORMATION
Manufacturer's Name, Address: Franklin Cleaning Technology - P.O. Box 214 - Great Bend, KS 67530
Product Name: Chlorinated Degreaser Product Number: F2110
Chemical Family: Solution of sodium hypochlorite, surfactants & builders Package Size: 1G; 3.8L; 5, 55 Gal
EPA Reg. No: N/A Emergency Telephone No. 620-792-1711
Preparer Tom Keyse Date: 8/26/04 Signature:
SECTION II - HAZARDOUS INGREDIENTS IDENTITY INFORMATION
Hazardous Components CAS# OSHA TWA ACGIH TWA Percent
Sodium Hypochlorite 7681-52-9 .5 ppm Cl .5 ppm Cl <7
Sodium Metasilicate 6834-92-0 NE NE <3
Sodium Hydroxide 1310-73-2 2mg/m3 NE <1
*Water 7732-18-5
*Sodium Lauryl Sarcosinate 137-16-6
SECTION III - PHYSICAL AND CHEMICAL CHARACTERISTICS
No Physical Hazards x Flammable Gas Flammable Liquid/Solid Water Reactive
Combustible Flammable Aerosol Pyrophoric Oxidizer
Compressed Gas Explosive Unstable - Reactive: Organic Peroxide
Boiling Point, 癋: 212F Solubility in Water: Complete Evaporation Rate: 1
Vapor Pressure: Unknown Specific Gravity (water =1): 1.1 pH: 13.0
Vapor Density: Unknown %Volatiles by Weight: 82
Appearance and Odor: Clear liquid with chlorine odor.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method): None Flammable Limits: LEL: N/A UEL: N/A
Extinguishing Media: N/A
Special Fire None
Fighting Procedures:
Unusual Fire and None
Explosion Hazards:
SECTION V - REACTIVITY DATA
Stability: Unstable Conditions to Avoid: N/A
Stable x
Incompatibility: Mix only with water.
(Materials to Avoid)
Hazardous Decomposition None
Products or Byproducts:
Hazardous Polymerization: May Occur: Will Not Occur: x
Conditions to Avoid: N/A
Comments:
*Added to comply with the Pennsylvania Worker Right to Know Act of 1984 and the New Jersey Worker & Community Right to
Know Act of 1983.
F2110 F2110
SECTION VI - HEALTH HAZARD DATA
Route (s) of entry: Inhalation x Skin: x Eye: x Ingestion: x
No Health Hazard Reproductive toxin Sensitizer
Toxic Irritant Carcinogen
Highly Toxic Corrosive x See Target Organs x
TARGET ORGANS
Lungs Eyes x Blood Teratogen Mucous Membranes x
Heart Skin x Liver Central Nervous System Autonomic Nervous System
Kidney Prostate Mutagen Cardiovascular System Respiratory System x
Carcinogenicity: None Known x NTP: IARC: OSHA Regulated
Medical Conditions Generally Aggravated by Exposure:
None known
Signs and Symptoms of Exposure:
Corrosive. Can causess severe eye damage. May cause irritation to skin and mucous membranes. Harmful if swallowed. Avoid
contact with eyes, skin and clothing. Keep container closed. Use with adequate ventilation. Avoid breathing vapors or mist. Do
not swallow.
Emergency and First Aid Procedures:
If in eyes or on skin, immediately flush with plenty of water for at least 15 minutes while removing contaminated clothing and
shoes. Get medical attention. Wash clothing before reuse. Thoroughly clean shoes before reuse. If inhaled, remove to fresh air.
Get medical attention. If swallowed, do NOT induce vomiting. Get medical attention.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to be taken in case material is released or spilled:
Small spill: Mop up, rinse with water. Large spill: Mop up, rinse with water.
Waste Disposal Method:
Small Amount: Place in plastic bag with absorbent and discard in trash. Large Amount: Dispose in accordance with Local,
State and Federal regulations.
Potential EPA Hazardous Waste Code(s): D002
Steps to be taken in handling and storage:
Protect from freezing. Store at 40 - 90 F. Read and follow label use directions. Keep out of reach of children. Note: Do NOT use
or mix with other chemicals such as ammonia or acids which may cause the release of chlorine or other hazardous gases.
SECTION VIII - CONTROL MEASURES
Respiratory Protection(Specify Type):
Recommended in areas with inadequate ventilation.
Ventilation: Local Exhaust: Recommended Special: Optional
Mechanical: Recommended
Protective Gloves: Required Eye Protection: Required
Other Protective Clothing and Equipment:
Aprons, coveralls, chemical resistant boots
SECTION IX - SHIPPING INFORMATION
DOT Proper Shipping Name and Number:
1 gallon or less: Consumer Commodity ORM-D; Larger than 1 gallon: Corrosive liquid, n.o.s. (Sodium hypochlorite), 8, UN
1760, PGIII, ERG 154
NE = Not Established
N/A = Not Applicable