Permatex, A Brand of ITW Devcon
30 Endicott St.
Danvers, MA 01923 USA
Telephone: 978-777-1100
Emergency: 800-424-9300
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: ANAEROBIC GASKET MAKER 50ML
Item No: 51031P
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
POLYGLYCOL DIMETHACRYLATE 40-50 Not Listed Not Listed
25852-47-5
MALEIMIDE 10-20 Not Listed Not Listed
13676-54-5
BISPHENOL A FUMARATE RESIN 10-20 Not Listed Not Listed
39382-25-7
10mg/m3 nuisance dust
SACCHARIN 1-10 Not Listed
81-07-2
__-DIMETHYLBENZYL 1-10 Not Listed Not Listed
HYDROPEROXIDE
80-15-9
3. HAZARDS IDENTIFICATION
May cause eye, skin and respiratory irritation. Prolonged skin contact may result in dermatitis in
Toxicity:
sensitive individuals.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Repeated skin contact may cause allergic skin reactions. May cause pain, redness or swelling of the
eyes and excessive blinking and tear production.
Ingredients Percent NTP: ACGIH IARC:
Carcinogens
SACCHARIN 1-10 Delisted April 2000 Group 3: Vol 73, Page 517:
81-07-2 1999
Medical Conditions Recognized as Preexisting skin disorders.
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention..
Ingestion:
Move to fresh air in case of accidental inhalation of vapors. Obtain medical attention.
Inhalation:
Wash off immediately with soap and plenty of water removing all contaminated clothes and shoes If
Skin Contact:
skin irritation persists, call a physician
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
More than 200 degrees F. Method: Tag Closed Cup
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors.
Hazardous Products Formed by Fire or Thermal
Decomposition:
None
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits..
9. PHYSICAL AND CHEMICAL PROPERTIES
Red liquid
Appearance:
MILD
Odor:
More than 300 degrees F.
Boiling Point (癋):
Does not apply
pH:
Low
Solubility in Water:
1.08
Specific Gravity:
11.4%
VOC Content(Wt.%):
Less than 5 mm Hg @ 80F
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Metal salts, heat and amines.
Incompatabilities:
Heat
Conditions to Avoid:
Irritating vapors.
Hazardous Products Formed by Fire or Thermal
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1, INSTABILITY 1
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 05/05/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 0
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839