MATERIAL SAFETY DATA SHEET from STEARNS PACKAGING CORPORATION
SECTION I--PRODUCT/MANUFACTURER'S IDENTITY
IDENTITY (As Used On Label and List):
HAZARD RATING 4 = Extreme
Carpet & Upholstery Shampoo
0 Flammability 3 = High
SYNONYMS: ST-737, ST-1253 1 Health 2 = Moderate
0 Reactivity 1 = Slight
FORMULA ID NUMBER: JL-40 None Special Hazard 0 = Insignificant
EPA REG #: None
USDA ACCEPTANCE DATE/CATEGORY CODE: None
For Transportation Emergency Involving Hazardous
Materials Contact: CHEM-TEL 1 (800) 255?924
COMPANY: STEARNS PACKAGING CORPORATION
ADDRESS: 4200 Sycamore Ave. (53714), P.O. Box 3216
Madison, Wisconsin (WI) 53704-0216 Shipping Information:
PHONE: 1 (608) 246?150 DOT SHIPPING NAME: Compound, cleaning, NOI, liquid. Item 48580,
FAX: 1 (608) 246?149 Sub 3, Class 55
INTERNET: www.stearnspkg.com DOT SHIPPING NUMBER: None
EMAIL: stearns@stearnspkg.com HAZARD LABEL: None
HAZARD CLASS: None
SECTION II--HAZARDOUS INGREDIENTS OR IDENTITY INFORMATION
HAZARDOUS CHEMICAL IDENTITY &
CAS# HAZARD OSHA PEL ACGIH TLV OTHER LIMITS % (OPTIONAL)
Ammonium lauryl sulfate Irritant
2235-54-3
Sodium lauryl sarcosinate Irritant
137-16-6
SARA SECTION 313 TITLE III NOTIFICATION REQUIRED: No; CHEMICAL IN PRODUCT: None; CAS#: N/A; WEIGHT % OF CHEM: N/A
SECTION III--PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT: VAPOR PRESSURE (mm Hg):
Not Determined Not Determined
SPECIFIC GRAVITY (WATER=1): VAPOR DENSITY (AIR=1):
1.02 Not Determined
MELTING POINT: EVAPORATION RATE:
Not Applicable Not Determined
SOLUBILITY IN WATER: pH (CONCENTRATE):
Complete 7.3 ?7.7
APPEARANCE AND ODOR: pH (1% SOLUTION):
Clear, light amber liquid Not Determined
pleasant odor
SECTION IV--FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): Non-combustible, >200篎
EXTINGUISHING MEDIA: Not Applicable
FLAMMABLE LIMITS: LEL: Not Applicable UEL: Not Applicable
SPECIAL FIRE FIGHTING
PROCEDURES: Use full protective clothing and self-contained breathing apparatus.
FIRE & EXPLOSION HAZARDS: None
MSDS: CARPET & UPHOLSTERY SHAMPOO.doc Page 1 of 2 Revision Date: 7/15/03
SECTION V--REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY (MATERIALS TO AVOID): None known
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: None known
CONDITIONS TO AVOID: Freezing and extremes of heat
HAZARDOUS POLYMERIZATION: Will not occur
SECTION VI--HEALTH HAZARD DATA/FIRST AID PROCEDURES
HEALTH HAZARDS (ACUTE AND CHRONIC): Irritation of exposed tissues, especially eyes, skin, throat, nasal cavities and other mucous membranes.
CARCINOGENICITY: NTP: No
IARC Monographs: No
OSHA Regulated: No
SIGNS AND SYMPTOMS OF OVEREXPOSURE: Irritation of eyes and possibly upon diect prolonged contact with skin. Mists may irritate the mucous
membranes.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: No data available.
EMERGENCY AND FIRST AID PROCEDURES:
Eyes: If contact with eyes occurs, flush with plenty of cool water for 15 minutes. Consult a physician.
Skin: May be irritating to skin. If contact occurs, flush with water and wear gloves in the future to minimize exposure. Wash hands thoroughly
after handling. Discontinue use if irritation persists and consult a physician.
Inhalation: Remove from exposure. Obtain medical attention immediately.
Ingestion: May be harmful if swallowed. If ingested, drink large amounts of water or milk. DO NOT induce vomiting. Get medical attention
immediately. Avoid contamination of foods.
Note to Physician: No specific antidote. Use supportive care. Treatment should be based on judgment of the physician in response to the reactions of
the patient.
SECTION VII--PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: May be flushed with water. Material is a biodegradable detergent solution.
Spills may be flushed with water to a sanitary sewer.
WASTE DISPOSAL METHOD: Waste disposal must be done in accordance with all local, city or municipality, county, state, and federal regulations. Consult
your state department of natural resources or the EPA for specific questions not answerable through other sources. Wastewater should never enter a
fresh water body without treatment.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store at room temperature between 40篎 and 120篎. Keep container closed when not in
use. Do not mix with other chemicals or cleaning agents. For best results, mix and store in clean plastic container.
OTHER PRECAUTIONS: Always keep product out of the reach of children.
SECTION VIII--OTHER REGULATORY INFORMATION
SECTION IX--CONTROL MEASURES
RESPIRATORY PROTECTION: In general, respirators are not needed if the product is used in a well-ventilated area.
VENTILATION: Local Exhaust: Recommended.
Mechanical (General): Recommended.
SKIN PROTECTION: Neoprene, rubber, or other chemical resistant gloves. Wear protective clothing to prevent repeated or prolonged
contact.
EYE PROTECTION: Splash goggles, or safety glasses if splashing is not a concern.
WORK/HYGIENIC PRACTICES: As good hygiene dictates.
Stearns Packaging Corporation makes no warranty, representation or guarantee as to the accuracy, sufficiency or completeness of the material set forth herein. It is the user's responsibility to determine the safety, toxicity,
and suitability of his own use, handling and disposal of this product. Since actual use by others is beyond our control, no warranty, expressed or implied, is made by Stearns Packaging Corporation as to the effects of such
use, the results to be obtained or the safety and toxicity of this product, nor does Stearns Packaging Corporation assume any liability arising out of the use by others of this product referred to herein. The data in this MSDS
relates only to the specific material designated herein and does not relate to use in combination with any other material or in any process. Stearns Packaging Corporation does not recommend blending this product with
any other chemicals. All information, recommendations, and data contained herein concerning this product are based upon information available at the time of writing from recognized technical sources.
MSDS: CARPET & UPHOLSTERY SHAMPOO.doc Page 2 of 2 Revision Date: 7/15/03
|