All ingredients are listed on the TSCA Inventory. n.a.= not applicable / n.e.=not established
SECTION II -Physical and Chemical Characteristics
BOILING POINT: n.a.
VOC #/gal. :
VAPOR DENSITY: n.a. air = 1
DENSITY OF COATING:
VAPOR PRESSURE: n.a.
MELTING POINT: n.a.
SPECIFIC GRAVITY: 1.05 water = 1
EVAPORATION RATE: n.a.
WATER REACTIVE: No
SOLUBILITY IN WATER: Nil
APPEARANCE AND ODOR: Two stripes of solid film with slight amine odor.
SECTION III - Fire and Explosion Hazard Data
FLASH POINT: >200癋 Pensky Marten Closed Cup
AUTOIGNITION TEMPERATURE: not determined
UEL: n.a.
FLAMMABILITY LIMITS % IN AIR: LEL: n.a.
EXTINGUISHER MEDIA: Use dry chemicals and/or carbon dioxide.
Wear NIOSH self-contained breathing apparatus with full face piece operated in pressure demand or other positive
SPECIAL
pressure mode when fighting fires.
FIREFIGHTING
PROCEDURES:
UNUSUAL FIRE Potential organic toxic fumes. Combustion yields oxides of carbon and nitrogen.
HAZARDS AND
CONDITIONS TO
AVOID:
MATERIAL SAFETY DATA SHEET
PRODUCT: ND Epoxy-Lock?br>
SECTION IV - Reactivity Hazard Data
STABILITY: stable: X unstable:
HAZARDOUS POLYMERIZATION: may occur: will not occur:
X
CONDITIONS Avoid unintentionally breaking skinned layers of material on fastener.
TO AVOID:
INCOMPATIBILITY: Avoid strong acids and strong alkalies.
HAZARDOUS Combustion yields acrid smoke and oxides of carbon and nitrogen. Nitrogen oxide can react water vapors to
DECOMPOSITION form nitric acid.
PRODUCTS:
SECTION V - Health Hazard Data
PRIMARY ROUTES OF ENTRY: X
INHALATION: INGESTION: SKIN ABSORPTION:
EYE CONTACT: Not a likely route of exposure. If enters eye, it may cause chemical and mechanical irritation. Serious injury
could result.
FIRST AID: Flush with generous amounts of water for 15 minutes lifting both upper and lower eyelids occasionally. Seek
medical attention immediately.
Not a likely route of exposure. May cause irritation of the skin.
SKIN
CONTACT:
Immediately remove contaminated clothing and shoes. Wipe excess from skin and flush with plenty of water for at least 15
minutes. Thoroughly wash exposed area with soap and water. If irritation occurs, seek medical attention. Launder clothing
FIRST AID: before reuse. Contaminated leather articles, including shoes, should be destroyed.
Heating of material can generate vapors that could cause headaches, nausea, and respiratory irritation.
INHALATION:
Remove individual to fresh air. Give oxygen if breathing is difficult. Administer artificial respiration if not
FIRST AID:
breathing. Obtain immediate medical attention.
INGESTION: Not a likely route of exposure. Slightly toxic if swallowed. Components of this material are highly injurious to all
tissues. Contents of stomach should be removed by gastric suction or vomiting under the guidance of medical
personnel.
FIRST AID: If swallowed give 3-4 glasses of water. Never give anything by mouth to an unconscious or convulsing person.
Get medical attention.
Dermatitis and indigestion.
CHRONIC
EFFECTS:
Carcinogenic: Not listed.
MATERIAL SAFETY DATA SHEET
PRODUCT: ND Epoxy-Lock?br>
Component Oral LD50 Dermal LD50 Inhalation LC50
0.5 mg/L Rat
1350 mg/Kg Rabbit
Amine curing agent adduct 1653 mg/Kg Rat
not determined
not determined
Dimethacrylate ester <5000 mg/Kg Rat
2.06 mg/L Rat
1660 mg/Kg Rabbit
Amine accelerator 265 mg/Kg Rat
not determined
not determined
Phosphine oxide not determined
not determined
6g/kg Rabbit
Epoxy resin > 4g/kg Rabbit
not determined
5200 mg/Kg Rabbit
Triacrylates 5000 mg/Kg Rat
SECTION VI - Control and Protective Measures
RESPIRATORY In the applied form additional respiratory protection is not necessary. It is best to work in a well ventilated area.
PROTECTION:
PROTECTIVE A type of chemical resistant gloves must be used. Rubber, nitrile or neoprene are some suggested types.
GLOVES:
EYE PROTECTION: Wear NIOSH approved safety glasses. Emergency eye wash stations should be available.
VENTILATION LOCAL EXHAUST: MECHANICAL: SPECIFIC:
X
TO BE USED: OTHER (specify):
PROTECTIVE CLOTHING Wear impervious clothing to prevent repeated or prolonged skin contact.
AND EQUIPMENT:
Practice good personal hygiene and wash hands after using product. Adhere to work practices
HYGIENIC WORK
established by government regulations.
PRACTICES:
SECTION VII - Precautions for Safe Handling and Spill/Leak Procedures
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
Sweep up material and place in proper waste receptacle.
Dispose of material in accordance with local, state and federal regulations.
WASTE DISPOSAL
METHODS:
Store in a cool dry area away from direct sunlight.
SAFE HANDLING
AND STORAGE:
OTHER PRECAUTIONS AND SPECIAL HAZARDOUS INFORMATION:
n.a.
RECOMMENDED 1 1 2 C
HEALTH FLAMMABILITY REACTIVITY PERSONAL
NFPA/HMIS PROTECTION
note: ratings may differ according to application, environment, and physical state.
RATING
MATERIAL SAFETY DATA SHEET
PRODUCT: ND Epoxy-Lock?br>
NOTES:
Proper DOT Shipping Name: Not Regulated
SECTION 313 SUPPLIER NOTIFICATION
Detaching this notification from the Material Safety Data Sheet is prohibited by law and any copying or
distribution of same requires this attachment be included.
This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372:
CAS # CHEMICAL NAME % BY WEIGHT
This product contains no chemical above de minimis levels that is subject to Toxic
Chemical Release Reporting under Section 313.
This product contains the following materials that under California Proposition 65 of the Safe Drinking Water and Toxic
Enforcement Act of 1986 are recognized to cause cancer or reproductive toxicity.
Cancer Reproductive cancer Reproductive
Concentration &
Material CAS # agent Toxin
Agent Toxin
%
Epichlorohydrin 106-89-8 S1 ppm X
Toluene 108-88-3 (trace) X
Phenyl glycidyl ether 122-60-1 <2ppm X
ND Epoxy-Lock?is a registered trademark of ND Industries? Inc.
The information contained herein is based on the data available to us and is believed to be correct. However, ND Industries?
Inc. makes no warranty, expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Information is supplied upon the condition that the persons receiving same will make their own determination as to its
suitability for their properties prior to use. Since conditions of use are beyond our control, all risks are assumed by the user.