SPECTRUM CAVITY CHEMICAL
Page 1 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
MATERIAL SAFETY DATA SHEET
SECTION 1 - IDENTIFICATION
Product identifier : SPECTRUM CAVITY CHEMICAL
None reported.
Product Code(s) :
Cavity embalming fluid.
Product Use :
Mixture.
Chemical Family :
Supplier's name and address: Manufacturer's name and address:
Refer to Supplier
The Dodge Chemical Company (Canada) Ltd.
1265 Fewster Drive
Mississauga, Ontario, Canada
L4W 1A2
(905) 625-0311
:
Information Telephone #
(613) 996-6666 (CANUTEC)
24 Hr. Emergency Tel # :
SECTION 2 - HAZARDS IDENTIFICATION
WHMIS classification:
Classification :
Class B3 (Combustible Liquids);
Class D2A (Materials Causing Other Toxic Effects, Very Toxic Material);
Class D2B (Materials Causing Other Toxic Effects, Toxic Material).
OSHA: This material is classified as hazardous under OSHA regulations (29CFR
1910.1200). Hazardous classification:
Combustible liquid;
Acute Health Hazard;
Chronic Health Hazard.
Clear liquid. red - purple. Wintergreen odour.
Emergency Overview :
Danger.
Combustible liquid and vapor. May be fatal or cause blindness if swallowed in sufficient quantities.
Harmful or fatal if absorbed through the skin. May be fatal if too much is inhaled. Causes eye
burns. May cause digestive tract burns. Causes skin irritation. May cause allergic skin reaction.
Prolonged or repeated overexposure could cause disorders of the nervous system, liver and
kidneys. Possible birth defect hazard - contains material that may cause birth defects, based on
animal data. Possible cancer hazard - contains material which may cause cancer.
POTENTIAL HEALTH EFFECTS:
Signs and symptoms of short-term (acute) exposure
Inhalation : May cause severe irritation to the nose, throat and respiratory tract. Symptoms may include pain,
headache, nausea, vomiting, dizziness, drowsiness and other central nervous system effects.
Affected person could experience a latent period of no symptoms, followed by blurred vision and
possibly blindness. Could result in pulmonary edema (fluid accumulation). Symptoms may be
delayed. May result in unconsciousness and possibly death.
: Causes moderate skin irritation. May be absorbed and cause symptoms similar to those for inhalation.
Skin
: Exposure to high vapour concentrations or contact with liquid causes severe irritation, redness,
Eyes
tearing and pain. Prolonged contact may cause corrosive burns and eye damage.
: Poison, may be fatal or cause blindness if swallowed. May cause severe irritation and corrosive
Ingestion
damage in the mouth, throat and stomach. Severe stomach pains, vomiting, diarrhea, and liver and
kidney injury may follow. May be absorbed and cause symptoms similar to those for inhalation.
Effects of long-term (chronic) exposure
: Prolonged or repeated skin contact may cause drying and irritation. Prolonged or
repeated overexposure could cause adverse liver effects. Prolonged overexposure may
result in headaches, visual and mental confusion, nausea, vomiting, tremors and
generalized convulsions.
: Possible cancer hazard. See TOXICOLOGICAL INFORMATION, Section 11.
Carcinogenic status
Possible sensitizer. Potential teratogen. Possible mutagen. See TOXICOLOGICAL
Additional health hazards :
INFORMATION, Section 11.
Potential environmental effects
See ECOLOGICAL INFORMATION, Section 12.
:
SPECTRUM CAVITY CHEMICAL
Page 2 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS
CAS #
Ingredients Wt.%
Formaldehyde 50-00-0
3.00 - 7.00
Methanol 67-56-1
10.00 - 30.00
Methyl salicylate 119-36-8
0.10 - 1.00
SECTION 4 - FIRST AID MEASURES
Immediately remove person to fresh air. If breathing has stopped, give artificial
Inhalation :
respiration. Keep warm and in a quiet place. Seek immediate medical attention/advice.
Remove contaminated clothing. Flush affected skin with gently flowing lukewarm water
Skin contact :
for at least 20 minutes. Seek immediate medical attention/advice. Wash contaminated
clothing before re-use.
Immediately flush eyes with running water for at least 20 minutes. Seek immediate
Eye contact :
medical attention/advice.
Call a physician or Poison Control Centre immediately. Do NOT induce vomiting. This
Ingestion :
material is corrosive to the digestive tract. Have victim rinse mouth with water, then give
one to two glasses of water to drink. Never give anything by mouth to an unconscious
person.
Immediate medical attention is required. Contains methanol. Treat symptomatically.
Notes For Physician :
SECTION 5 - FIRE FIGHTING MEASURES
Fire hazards/conditions of flammability
Combustible liquid and vapour. This material may be ignited by heat, sparks and direct
:
flame. Vapours are heavier than air and collect in confined and low-lying areas. Closed
containers may rupture if exposed to excess heat or flame due to a build-up of internal
pressure.
Flammability classification (OSHA 29 CFR 1910.1200)
Class II Combustible Liquid.
:
Not known.
Oxidizing properties :
Explosion data: Sensitivity to mechanical impact / static discharge
: Not expected to be sensitive to mechanical impact. Vapours in the flammable range
may be ignited by a static discharge of sufficient energy.
: Dry chemical, foam, carbon dioxide and water fog.
Suitable extinguishing media
Special fire-fighting procedures/equipment
Firefighters should wear proper protective equipment and self-contained breathing
:
apparatus with full face piece operated in positive pressure mode. Move containers
from fire area if safe to do so. Water spray may be useful in cooling equipment exposed
to heat and flame. Avoid spreading burning liquid with water spray used for cooling
purposes.
Hazardous combustion products
May form formaldehyde gas, carbon oxides, hydrogen, formic acid and various
:
hydrocarbons.
0 - Minimal 1 - Slight 2 - Moderate 3 - Serious 4 - Severe
NFPA Rating
Health: 2 Flammability: 2 Instability: 0 Special Hazards: None.
:
SECTION 6 - ACCIDENTAL RELEASE MEASURES
Restrict access to area until completion of clean-up. Keep all other personnel upwind
Personal precautions :
and away from the spill/release. Individuals involved in the cleanup must wear
appropriate personal protective equipment. Refer to protective measures listed in
sections 7 and 8.
Prevent product from entering drains, sewers, waterways and soil. If necessary, dike
Environmental precautions :
well ahead of the spill to prevent runoff into drains, sewers, or any natural waterway or
drinking supply.
Remove all sources of ignition. Ventilate area of release. Stop the spill at source if it is
Spill response/cleanup :
safe to do so. Contain and absorb spilled liquid with non-combustible, inert absorbent
material (e.g. sand), then place absorbent material into a container for later disposal
(see Section 13). Notify the appropriate authorities as required.
Do not use combustible absorbents, such as sawdust.
Prohibited materials :
SPECTRUM CAVITY CHEMICAL
Page 3 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
Special spill response procedures
If a spill/release in excess of the EPA reportable quantity is made into the environment,
:
immediately notify the national response center in the United States (phone:
1-800-424-8002).
US CERCLA Reportable quantity (RQ): formaldehyde (100 lbs / 45.4 kg); Methanol
(5000 lbs / 2270 kg).
SECTION 7 - HANDLING AND STORAGE
Wear chemically resistant protective equipment during handling. Use only in
Safe Handling procedures :
well-ventilated areas. Do not breathe vapours or spray mist. Avoid contact with eyes,
skin and clothing. Keep away from heat, sparks, and open flames. Keep away from
bases and incompatibles. Use caution when opening cap. Keep containers tightly
closed when not in use. Wash thoroughly after handling.
Store in a cool, dry, well-ventilated area. Store away from incompatibles and out of
Storage requirements :
direct sunlight. Storage area should be clearly identified, clear of obstruction and
accessible only to trained and authorized personnel. No smoking in the area. Inspect
periodically for damage or leaks. Do not store for long periods of time below 2癈 (35?br>
F), or above 43.3癈 (110癋).
Avoid contact with strong oxidizers, strong alkalies, strong mineral acids, phenol and
Incompatible materials :
urea.
Always keep in containers made of the same materials as the supply container.
Special packaging materials :
SECTION 8 - EXPOSURE CONTROLS AND PERSONAL PROTECTION
Exposure Limits
OSHA PEL
ACGIH TLV
TWA STEL PEL STEL
Ingredients
Formaldehyde 0.3 ppm (ceiling) N/Av 0.75 ppm 2 ppm
Methanol 200 ppm (skin) 250 ppm (skin) 200 ppm N/Av
Methyl salicylate N/Av N/Av N/Av N/Av
Ventilation and engineering measures
Local exhaust ventilation is preferred to prevent contaminant dispersion into work area.
:
Use NIOSH/MSHA approved full-face respirator with an organic vapour cartridge if the
Respiratory protection :
recommended exposure limit is exceeded.
Impervious gloves must be worn when using this product. Advice should be sought
Skin protection :
from glove suppliers.
Chemical splash goggles are recommended. A full face shield may also be necessary.
Eye / face protection :
An eyewash station and safety shower should be made available in the immediate
:
Other protective equipment
working area. Depending on conditions of use, an impervious apron should be worn.
General hygiene considerations
: Do not breathe vapours or spray mist. Avoid contact with skin, eyes and clothing. Do
not eat, drink, smoke or use cosmetics while working with this product. Upon
completion of work, wash hands before eating, drinking, smoking or use of toilet
facilities. Remove soiled clothing and wash it thoroughly before reuse.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
Clear liquid. : red - purple
Physical state : Appearance
Wintergreen odour. : N/Av
Odour : Odour threshold
3.5 - 4.5
pH :
89 - 91癈 (192 - 196癋) : 1.025 - 1.035
Boiling point : Specific gravity
N/Av
Melting/Freezing point : Coefficient of water/oil distribution
: N/Av
: Complete
Vapour pressure (mmHg @ 20?C / 68?F) Solubility in water
: N/Av
>1
:
Vapour density (Air = 1) Evaporation rate (n-Butyl acetate = 1)
: <1
: 87%
Volatile organic Compounds (VOC's) Volatiles (% by weight)
: N/Av
SPECTRUM CAVITY CHEMICAL
Page 4 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
: 39 - 41癈 (102 - 106癋)
Flash point
TCC : N/Av
Flash point Method : Auto-ignition temperature
Lower flammable limit (% by vol.) Upper flammable limit (% by vol.)
7 (formaldehyde) : 73 (formaldehyde)
:
N/Ap : N/Ap
Flame Projection Length : Flashback observed
Section 10: Stability And Reactivity
Stable under the recommended storage and handling conditions prescribed. At higher
:
Stability and reactivity
temperatures, product may form formic acid and methanol.
: Hazardous polymerisation does not occur.
Hazardous polymerization
: Avoid heat and open flame. Exposure to cold may cause precipitation of the polymer,
Conditions to avoid
will redissolve upon gentle heating.
Materials To Avoid And Incompatibility
: Avoid contact with strong oxidizers, strong alkalies, strong mineral acids, phenol and
urea.
Hazardous decomposition products
: Methanol; Formic acid. Refer to Section 5 for additional `Hazardous combustion
products'.
SECTION 11 - TOXICOLOGICAL INFORMATION
Eyes, skin, respiratory system, central nervous system, liver and kidneys.
Target organs :
Inhalation: YES YES YES YES
Skin Absorption: Skin & Eyes: Ingestion:
Routes of exposure :
There is no available data for the product itself, only for the ingredients. See
Toxicological data :
below for individual ingredient acute toxicity data.
LC50(4hr) LD50
Ingredients inh, rat (Rabbit, dermal)
(Oral, rat)
42 mg/kg (mouse);
287 ppm
Formaldehyde 300 mg/kg
100 mg/kg (rat)
64,000 ppm 5628 mg/kg
Methanol 15,800 mg/kg
N/Av 887 mg/kg
Methyl salicylate N/Av
Formaldehyde is classified as carcinogenic by IARC (Group 1), ACGIH (Group A2) and
Carcinogenic status :
NTP (Group 2).
Not expected to have other reproductive effects.
Reproductive effects :
Contains methanol, which may cause teratogenic effects at doses which are not
Teratogenicity :
maternally toxic. Contains methyl salicylate which has caused teratogenic and/or toxic
effects in animals.
This product contains Formaldehyde, which may cause mutations to non-reproductive
Mutagenicity :
cells (somatic cells), based on animal data.
Not available.
Epidemiology :
May cause severe skin sensitization with allergic contact dermatitis symptoms such as
Sensitization to material :
swelling, rash and eczema. No data available to indicate product or components may
be respiratory sensitizers.
N/Av
Synergistic materials :
Moderate skin irritant. Corrosive to eyes.
Irritancy :
May cause blindness if swallowed.
other important hazards :
Conditions aggravated by overexposure
: Pre-exisiting skin, respiratory, renal or nervous system disorders.
SECTION 12 - ECOLOGICAL INFORMATION
There is no data available for this product. The product should not be allowed to enter
Ecotoxicity :
drains or water courses, or be deposited where it can affect ground or surface waters.
No data is available on the product itself.
Mobility :
No data is available on the product itself.
Persistence :
No data is available on the product itself.
Bioaccumulation potential :
Other Adverse Environmental effects
No data is available on the product itself.
:
SPECTRUM CAVITY CHEMICAL
Page 5 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
SECTION 13 - DISPOSAL CONSIDERATIONS
Handle waste according to recommendations in Section 7.
Handling for Disposal :
Improper disposal can cause damage to the environment. Dispose in accordance with
Methods of Disposal :
all applicable federal, state, provincial and local regulations. Contact your local, state,
provincial or federal environmental agency for specific rules.
If this product, as supplied, becomes a waste in the United States, it may meet the
RCRA :
criteria of a hazardous waste as defined under RCRA, Title 40 CFR 261. It is the
responsibility of the waste generator to determine the proper waste identification and
disposal method. For disposal of unused or waste material, check with local, state and
federal environmental agencies.
SECTION 14: TRANPORT INFORMATION
Packing
Regulatory
Group
UN Number Shipping Name Class
Information Label
3
UN1993 FLAMMABLE LIQUID, N.O.S. (Methanol; formaldehyde)
TDG III
This material may be shipped as non-regulated material when in small means of containment (<450 Litres), provided
TDG
the requirements of TDG section 1.33 are met. Section 1.33 of the Regulations is an exemption permitting the
Additional
transportation of this product in small means of containment as not regulated.
information
Combustible.
Combustible liquid, n.o.s. (Contains: Methanol;
NA1993
49CFR/DOT III
Formaldehyde)
Not regulated for road or rail shipment if packaged in non-bulk containers (450 Litres or less each). Refer to 49 CFR
49CFR/DOT
Section 173.150(f)(2). The 'label' appearing here is the placard to be used for bulk shipments.
Additional
US CERCLA Reportable quantity (RQ): Methanol (5000 lbs / 2270 kg); formaldehyde (100 lbs / 45.4 kg).
information
SECTION 15 - REGULATORY INFORMATION
US Federal Information:
TSCA: All listed ingredients appear on the Toxic Substances Control Act (TSCA) inventory.
CERCLA Reportable Quantity (RQ) (40 CFR 117.302): formaldehyde (100 lbs / 45.4 kg); Methanol (5000 lbs / 2270 kg).
SARA TITLE III: Sec. 302, Extremely Hazardous Substances, 40 CFR 355: This product contains an Extremely
Hazardous Substance under SARA Section 302. Contains: formaldehyde.
SARA TITLE III: Sec. 311 and 312, MSDS Requirements, 40 CFR 370 Hazard Classes: Fire Hazard; Acute Health
Hazard; Chronic Health Hazard. Under SARA Sections 311 and 312, the EPA has established threshold quantities for the
reporting of hazardous chemicals. The current thresholds are 500 pounds for the threshold planning quantity (TPQ),
whichever is lower, for extremely hazardous substances and 10,000 pounds for all other hazardous chemicals.
SARA TITLE III: Sec. 313, Toxic Chemicals Notification, 40 CFR 372: This product may be subject to SARA notification
requirements, since it contains Toxic Chemical constituents above their de minimus concentrations. This product
contains: formaldehyde; Methanol.
US State Right to Know Laws:
California Proposition 65: This product contains a chemical known to the State of California to cause cancer. Contains:
formaldehyde.
Other U.S. State "Right to Know" Lists: The following chemicals are specifically listed by individual States: formaldehyde
(CA, MA, MN, NJ, PA, RI); Methanol (CA, MA, MN, NJ, PA, RI); Methyl salicylate (NJ, PA, RI).
International Information:
WHMIS information: This product is a WHMIS Controlled Product. It meets one or more of the criteria for a controlled
product provided in Part IV of the Canadian Controlled Products Regulations (CPR). Refer to Section 2 for a WHMIS
Classification for this product.
Canadian Environmental Protection Act (CEPA) information: All ingredients listed appear on the Domestic Substances List
(DSL).
This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations
(CPR) and this MSDS contains all the information required by the CPR.
SPECTRUM CAVITY CHEMICAL
Page 6 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
SECTION 16 - OTHER INFORMATION
- Chronic hazard 0 - Minimal 1 - Slight 2 - Moderate 3 - Serious 4 - Severe
*
HMIS Rating :
Health: *3 Flammability: 2 Reactivity: 0
ACGIH: American Conference of Governmental Industrial Hygienists
Legend :
CA: California
CAS: Chemical Abstract Services
CERCLA: Comprehensive Environmental Response, Compensation, and Liability Act
of 1980
CFR: Code of Federal Regulations
DOT: Department of Transportation
EPA: Environmental Protection Agency
HMIS: Hazardous Materials Identification System
HSDB: Hazardous Substances Data Bank
IARC: International Agency for Research on Cancer
Inh: Inhalation
LC: Lethal Concentration
LD: Lethal Dose
MA: Massachusetts
MN: Minnesota
MSHA: Mine Safety and Health Administration
N/Ap: Not Applicable
N/Av: Not Available
NFPA: National Fire Protection Association
NJ: New Jersey
NTP: National Toxicology Program
NIOSH: National Institute of Occupational Safety and Health
OSHA: Occupational Safety and Health Administration
PA: Pennsylvania
PEL: Permissible exposure limit
RCRA: Resource Conservation and Recovery Act
RI: Rhode Island
RTECS: Registry of Toxic Effects of Chemical Substances
SARA: Superfund Amendments and Reauthorization Act
STEL: Short Term Exposure Limit
TCC: Tagliabue Closed Cup
TDG: Canadian Transportation of Dangerous Goods Act & Regulations
TLV: Threshold Limit Values
TWA: Time Weighted Average
WHMIS: Workplace Hazardous Materials Identification System
1. ACGIH, Threshold Limit Values and Biological Exposure Indices for 2009.
References :
2. International Agency for Research on Cancer Monographs, searched 2009.
3. Canadian Centre for Occupational Health and Safety, CCInfoWeb databases, 2009
(Chempendium, HSDB and RTECs).
4. Material Safety Data Sheet from manufacturer.
5. US EPA Title III List of Lists - October 2006 version.
6.California Proposition 65 List - December 18, 2009 version.
Prepared for:
The Dodge Chemical Company (Canada) Ltd.
1265 Fewster Drive
Mississauga, ON, Canada
L4W 1A2
Telephone: (905) 625-0311
Please direct all enquiries to The Dodge Chemical
Company (Canada).
Prepared by:
ICC The Compliance Center Inc.
http://www.thecompliancecenter.com
SPECTRUM CAVITY CHEMICAL
Page 7 of 7
MSDS Revision Date (dd/mm/yyyy): 06/01/2010
DISCLAIMER OF LIABILITY
This Material Safety Data Sheet was prepared by ICC The Compliance Center Inc using information provided by /
obtained from The Dodge Chemical Company (Canada) Ltd. and CCOHS' Web Information Service. The information in
the Material Safety Data Sheet is offered for your consideration and guidance when exposed to this product. ICC The
Compliance Center Inc and The Dodge Chemical Company (Canada) Ltd. expressly disclaim all expressed or implied
warranties and assume no responsibilities for the accuracy or completeness of the data contained herein. The data in this
MSDS does not apply to use with any other product or in any other process.
This Material Safety Data Sheet may not be changed, or altered in any way without the expressed knowledge and
permission of ICC The Compliance Center Inc and The Dodge Chemical Company (Canada) Ltd.
Preparation Date (dd/mm/yyyy)
: 28/12/2006
Reviewed Date (dd/mm/yyyy)
: 06/01/2010
2
Revision No. :
Converted from 9 section format to 16 section format. All sections modified.
Revision Information :
END OF DOCUMENT
|