Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HIGH STREGTH THREADLOCKER RED GEL 5 GR
Item No: 27005
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH TLV: TWA OSHA PEL:
POLYGLYCOL DIMETHACRYLATE 50-70 Not Listed Not Listed
25852-47-5
POLYESTER RESIN 20-40 Not Listed Not Listed
MIXTURE
10 mg/m3 total dust TLV 10 mg/m3 total dust
TREATED SILICON DIOXIDE, 1-10
SYNTHETIC, CRYSTALLINE-FREE
67762-90-7
DIMETHYLBENZYL <4 Not Listed Not Listed
HYDROPEROXIDE
80-15-9
PROPYLENE GLYCOL <3 Not Listed Not Listed
57-55-6
10mg/m3 nuisance dust
SACCHARIN 0.5-5.0 Not Listed
81-07-2
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. At elevated temperatures may cause irritation of the respiratory tract.
Toxicity:
Irritates mucous membranes. Ingestion may irritate digestive tract and cause nausea, vomiting and
diarrhea. High concentrations may cause central nervous system (CNS) depression. May cause skin
sensitization. Note: This product does not contain microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. Skin redness. Ingestion may cause nausea and
Signs and Symptoms of Exposure:
vomiting. Inhalation overexposure may cause irritation, coughing and flu-like symptoms. May cause pain,
redness or swelling of the eyes and excessive blinking and tear production.
Component Weight% NTP ACGIH Carcinogens IARC
SACCHARIN 0.5-5.0 Delisted April 2000 Group 3: Vol 73, 1999
81-07-2
Preexisting skin disorders
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋
Flash Point (癋/C):
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus
Special Fire-Fighting Procedures:
Irritating vapors
Hazardous Products of Combustion:
Closed containers may rupture or explode when exposed to extreme heat
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
1 of 3
Product Name: HIGH STREGTH THREADLOCKER RED Item No: 27005
GEL 5 GR
5. FIRE FIGHTING MEASURES
Not determined
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal
Spill Procedures:
7. HANDLING AND STORAGE
Store below 100 degrees F
Storage:
Avoid prolonged skin contact. Keep away from eyes
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Red gel
Appearance:
MILD
Odor:
>150癈
Boiling Point:
Does not apply
pH:
Insoluble
Solubility in Water:
1.1
Specific Gravity:
<2% by weight
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Strong oxidizers, free radical initiators, inert gases
Incompatabilities:
Heat
Conditions to Avoid:
Irritating vapors
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/NA Number:
2 of 3
Product Name: HIGH STREGTH THREADLOCKER RED Item No: 27005
GEL 5 GR
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: July/26/2007
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 1
Company: Revision
Number: