MATERIAL SAFETY DATA SHEET
200V15
PRODUCT NAME: MIL-P-23377G TYPE II CLASS N CATALYST
HMIS CODES: H F R P
2 3 0 H
SECTION I: MANUFACTURER IDENTIFICATION
MANUFACTURER' NAME: MACH-DYNAMICS
S
ADDRESS: 3870 La Sierra Avenue, Suite 212, Riverside, CA 92505
INFORMATION PHONE: (951) 515-3748 Fax (775) 599-4585
NAME OF PREPARER: Mark Gingerella
DATE REVISED: October 3, 2007 (12-01-99)
REASON REVISED: Format (Prop 65 Statement)
EMERGENCY PHONE: CHEMTRC 1-800-424-9300
SECTION II: HAZARDOUS INGREDIENTS / SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS VAPOR PRESSURE WEIGHT
HAZ .COMP. CAS # OSHA PEL ACCIW TLV OTHER mm Hg @ Temp PERCENT
*N/BUTYL 71-36- 100 PPM 50 PPM 4.3 @ 68 Deg F 5
3
ALCOHOL
108- NOT ESTB NOT ESTB 3.7 @ 68 Deg F 5
PROPYLENE
65-6
GLYCOL
MONOMETHYL
ETHER
ACETATE
*ETHYLENE 111- 50 PPM 75 PPM 0.6 @ 68 Deg F 6
76-2
GLYCOL
MONOBUTYL
ETHER
*METHYL 78-93- 200 PPM 200 PPM 70.0 @ 68 Deg F 2
3
ETHYL
KETONE
67-64- 1000 PPM 11.6 @ 68 Deg F 25
ACETONE
1
*INDICATES TOXIC CHEMICAL(S) SUBJECT TO REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III AND
OF 40 CFR 372.
*WARNING THIS PRODUCT CONTAINS CHEMICALS KNOW TO THE STATE OF CALIFORNIA TO CAUSE CANCER
AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
SECTION III: PHYSICAL / CHEMICAL CHARACTERISTICS
Boiling Range: 131 to 336 Deg F
Specific Gravity: (H2O=1) 0.9
Vapor Density: Heavier than air
Evaporation Rate: Slower than Ether
Material V.O.C.: 2.03 Lb/GL (243 G//L)
Solubility In Water: Essentially Nil
Appearance and Odor: Viscous Liquid With Strong Solvent Odor.
SECTION IV: FIRE AND EXPLOSION HAZARD DATA
Flash Point: -4 Deg F Method Used: TCC
Flammable Limits In Air By Volume: Lower: 1.1% Upper: 12.8%
Extinguishing Media: Foam, CO2, Dry Chemical, Water Fog
SPECIAL FIRE FIGHTING PROCEDURES: Use air supplied equipment for enclosed areas. Cool exposed containers
with water.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Heat/Fire Conditions: Vapors form flammable/explosive mixtures in air
vapors heavy, may travel to ignition source. Open/Closed containers may contain flammable/explosive vapors.
Under fire conditions: May emit irritant/toxic gas and/or fumes. Closed containers may exposed when exposed to
extreme heat (fire).
Page 1 of 4
MATERIAL SAFETY DATA SHEET
200V15
SECTION V: REACTIVITY DATA
STABILITY: Stable
CONDITIONS TO AVOID: Flames, sparks, smoking and heat
INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents.
HAZARDOUS DECOMPOSITION OR BY PRODUCTS: Carbon Monoxide and Carbon Dioxide.
HAZARDOUS POLYMERIZATION: Will not occur.
SECTION VI: HEALTH HAZARD DATA
INHALATION HEALTH RISK AND SYMPTOMS OF EXPOSURE:
Prolonged and/or repeated exposure to high concentrations of airborne particles may lead to lung changes.
Inhalation of high concentrations may also cause nausea, vomiting, cough, pulmonary irritation and headache.
SKIN AND EYE CONTACT HEALTH RISK AND SYMPTOMS OF EXPOSURE:
EYE: Direct contact and/or contact with vapors may cause irritation.
SKIN: Prolonged and/or repeated contact may cause irritation and/or dermatitis. May be absorbed through the skin.
SKIN ABSORPTION HEALTH RISK AND SYMPTOMS OF EXPOSURE:
Contact may cause irritation and/or dermatitis. May be absorbed through the skin leading to systemic effects.
INGESTION HEALTH RISK AND SYMPTOMS OF EXPOSURE:
Aspiration of this product into the lungs may cause pneumontitis, pulmonary edema and hemorrhage. Ingestion
may cause gastrointestinal disturbances.
HEALTH HAZARDS (ACUTE AND CHRONIC):
Direct contact to eyes may cause irritation, prolonged and/or repeated contact may cause skin irritation. Inhalation
of high concentrations of vapors may lead to lung changes, nausea, vomiting, cough, pulmonary irritation, and
central nervous system depression. Ingestion may cause gastrointestinal disturbance. Aspiration of this product
into the lungs may cause pneumontitis, pulmonary edema and hemorrhage.
CARCINOGENICITY: NTP? No IARC MONOGRAPHS? No OSHA REGULATED? NO
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
Individuals with preexisting diseases in or history of ailments involving skin, central nervous system, liver, and
kidney.
EMERGENCY AND FIRST AID PROCEDURES:
EYE CONTACT: IMMEDIATELY FLUSH WITH LARGE AMOUNTS OF WATER FOR 15 MINUTES, SEEK MEDICAL
AID.
SKIN: WASH THOROUGHLY WITH SOAP AND WATER. SEEK MEDICAL AID IF IRRITATION PERSIST.
INGESTION: IMMEDIATELY SEEK MEDICAL AID, DO NOT INDUCE VOMITING. GIVE 1 GLASS OF MILK OR 1-2
OUNCES OF ACTIVATED CHARCOAL IN WATER TO VICTIM.
DO NOT ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
Page 2 of 4
MATERIAL SAFETY DATA SHEET
200V15
SECTION VII: PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Stop leak if no risk involved. Remove all sources of ignition, stay upwind. Absorb with inert material. Flush area
with water. Ventilate area for at least 24 hours or until area has been declared safe.
WASTE DISPOSAL METHOD: Use inert absorbent materials on spills. Dispose of in accordance with all Federal,
State, and Local Regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Keep containers closed and upright to prevent
leakage. Avoid flames, welding, open lights, etc.
Avoid breathing of vapor and spray mist.
Avoid skin and eye contact.
OTHER PRECAUTIONS:
Maintain good personal hygiene.
Do Not Use in confined areas, tank or pit, without adequate ventilation.
SECTION VIII: CONTROL MEASURES
RESPIRATORY PROTECTION: If ventilation does not maintain inhalation exposures below TLV (PEL), use
MSHA/NIOSH approved units.
Use units per current 29 CFR1910.134 and follow manufacturer' instructions and warnings.
s
If within OSHA protection factor, air purifying OV/filter units OK for use.
VENTILATION: Local and mechanical exhaust.
PROTECTIVE GLOVES: Rubber gloves.
EYE PROTECTION: Safety glasses with side shields or goggles.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Eye bath and safety shower.
WORK/HYGIENIC PRACTICES: Maintain good personal hygiene. Do not use in confined areas without adequate
ventilation.
SECTION IX: DISCLAIMER
AS THE CONDITIONS OR METHODS ARE BEYOND OUR CONTROL WE DO NOT ASSUME ANY RESPONSIBILITY
REGARDING USE OF PRODUCT. WE EXPRESSLY DISCLAIM ANY LIABILITY FOR ANY USE OF THE MATERIAL.
INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE, ALL STATEMENTS OR SUGGESTIONS ARE
MADE WITHOUT ANY WARRANTY, EXPRESSED OR IMPLIED TO THE ACCURACY OF THE DOCUMENT.
Page 3 of 4
MATERIAL SAFETY DATA SHEET
200V15
SECTION X: TRANSPORTATION DATA
GROUND
PROPER SHIPPING NAME: Paint
HAZARD CLASS: 3 Pkg. Grp. I I .
UN/NA NUMBER: UN 1263
APPLICABLE REGULATION: 49 CFR 171 - 179
U.S. POSTAL REGULATION: Not Shippable
LABEL: Flammable Liquid.
DISPOSAL INFORMATION:
THIS PRODUCT IS A US EPA DEFINED IGNITABLE HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE
HAZARDOUS WASTE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. AVOID STORING
MATERIAL NEXT TO OR NEAR OXIDIZING MATERIALS. EPA IGNITABLE.
AIR
PROPER SHIPPING NAME: Paint.
HAZARD CLASS: 3 Pkg. Grp. I I
UN/NA NUMBER: UN 1263
LABEL: Flammable Liquid.
PACKING GROUP: Consult IATA manual
APPLICABLE REGULATION: IATA
U.S. POSTAL REGULATION: Not Shippable.
DISPOSAL INFORMATION:
THIS PRODUCT IS A US EPA DEFINED IGNITABLE HAZARDOUS WASTE. DISPOSE OF AS AN IGNITABLE
HAZARDOUS WASTE IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. AVOID STORING
MATERIAL NEXT TO OR NEAR OXIDIZING MATERIALS. EPA IGNITABLE.
END OF DOCUMENT
Page 4 of 4
|