MATERIAL SAFETY DATA SHEET
Share Corporation
P.O. Box 245013
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: 414-355-4000
EMERGENCY TELEPHONE NUMBER: (800) 776-7192 REVISION DATE: April 7, 2005
CHEMTREC: (800) 424-9300 DATE OF ISSUE: May 13, 2005
I - Product Identification
HDIC Ultra Aerosol
PRODUCT CODE: 8419
CHEMICAL FORMULATION: Pressurized water based alkaline cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 2 FLAMMABILITY: 2 REACTIVITY: 0
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
2-Butoxy Ethanol 15.0-25.0 25 ppm (skin) 25 ppm (skin) Y N Y 111-76-2
Tetrasodium EDTA 0.50-1.00 N/E N/E N N N 64-02-8
3
Organic Phosphate Ester 1.00-3.00 N/E 1 mg/m N N N 51811-79-1
Liquified Petroleum Gas 5.00-10.0 1000 ppm 1000 ppm N N N 68476-85-7
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): <1.00*
BOILING POINT (癋): N/D
VAPOR PRESSURE (mm Hg): 115 ?5@130?F* VOC CONTENT (% by weight): N/D
VAPOR DENSITY (AIR = 1): >1.0* EVAPORATION RATE (Ether = 1): <1.0*
SOLUBILITY IN WATER: Slight* pH: N/D
APPEARANCE AND ODOR: Semi-stable, foaming spray; pine solvent fragrance.
*Tested using the liquid component (excluding the propellant).
IV - Fire and Explosion Hazard Data
FLASH POINT (癋): N/A (TEST METHOD): FLAME EXTENSION: N/D
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: 9.2 LOWER: 1.8 NFPA 30B Rating: 1
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Exposure to temperature above 120癋 may cause bursting.
PRODUCT NAME: HDIC Ultra Aerosol PRODUCT CODE: 8419
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers, reactive metals.
CONDITIONS TO AVOID: Excess heat and open flame, direct sunlight. Dropping of containers may cause bursting.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Irritation, redness tearing and burning.
IF ON SKIN: Irritation, chapping and dermatitis, with prolonged or repeated exposure. Possible skin absorption.
IF SWALLOWED: This product contains 2-Butoxyethanol, which if ingested in significant quantities may result in read blood cell
hemolysis. .
IF INHALED: Irritation to upper respiratory tract. High concentrations may product headache, dizziness and nausea.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Remove contaminated clothing. Flush skin with water, followed by washing with soap and water. If irritation persists,
obtain medical attention. Launder clothing separately before reuse.
IF SWALLOWED: Contact physician or poison control center immediately. Ingestion of large quantities may result in red blood cell
hemolysis
IF INHALED: Remove person to fresh air. If breathing has stopped, administer artificial respiration. If irritation persists, obtain
medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Contain
spill. Soak up spilled material with inert absorbent material and place in a properly marked closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities. Dispose of cans in non-incinerated trash only.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH
approved respirator, following manufacturer's recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses.
OTHER PROTECTIVE EQUIPMENT: Impervious clothing.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat or open flame. Do
not expose to direct sunlight or store at temperatures above 120癋.
OTHER PRECAUTIONS: Keep out of reach of children. Do not puncture or incinerate container.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: Consumer Commodity
DOT CLASS: ORM-D DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: April 7, 2005 Prepared by: Technical Dept. DATE OF ISSUE: May 13, 2005
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the
results to be obtained from the use thereof. Share Corporation assumes no responsibility for personal injury or property damage to the vendee, users or third
parties caused by the material such vendees or users assume all risks associated with the use of this material.
|