Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: PENETRATING GRADE THREADLOCKER GREEN 36ML
Item No: 29040P
Product Type: Anaerobic
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredient Weight Percent ACGIH TLV: OSHA PEL:
METHACRYLATE MONOMER 80-90 Not Listed Not Listed
25852-47-5
DIMETHYLBENZYL <10 Not Listed Not Listed
HYDROPEROXIDE
80-15-9
ALKYL TOLUIDINE <5 Not Listed Not Listed
613-48-9
10mg/m3 nuisance dust
SACCHARIN <5 Not Listed
81-07-2
AROMATIC AMINE <3 Not Listed Not Listed
609-72-3
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. At elevated temperatures may cause irritation of the respiratory tract.
Toxicity:
Ingestion may irritate digestive tract and cause nausea, vomiting and diarrhea. May cause skin
sensitization.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Repeated skin contact may cause allergic skin reactions. Ingestion may cause nausea and vomiting.
Signs and Symptoms of Exposure:
Inhalation overexposure may cause irritation, coughing and flu-like symptoms. May cause pain, redness
or swelling of the eyes and excessive blinking and tear production.
Ingredient Weight NTP ACGIH Carcinogens IARC
Percent
SACCHARIN <5 Delisted April 2000 Group 3: Vol 73, Page 517:
81-07-2 1999
Preexisting skin disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
More than 200 degrees F. Method: PMCC
Flash Point (癋/C):
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus.
Special Fire-Fighting Procedures:
Irritating vapors
Hazardous Products of Combustion:
None.
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
1 of 3
Product name: PENETRATING GRADE THREADLOCKER Item No: 29040P
GREEN 36ML
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store below 100 degrees F.
Storage:
Avoid prolonged skin contact. Keep away from eyes.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses
Eyes:
Rubber or plastic gloves.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Green liquid
Appearance:
MILD
Odor:
More than 200 degrees C.
Boiling Point:
Does not apply
pH:
Insoluble
Solubility in Water:
0.8
Specific Gravity:
Not determined
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur.
Hazardous Polymerization:
Strong oxidizers
Incompatabilities:
Heat.
Conditions to Avoid:
Irritating vapors
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
IATA
Not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/NA Number:
IMDG
2 of 3
Product name: PENETRATING GRADE THREADLOCKER Item No: 29040P
GREEN 36ML
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
DIMETHYLBENZYL HYDROPEROXIDE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 1 , REACTIVITY 1
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 08/16/2006
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 2
Company: Revision
Number: