Material Safety Data Sheet U. S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA's Hazard Communication Standard, (Non-Mandatory Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for the specific requirements. OMB No. 1218-0072
NOTE: Blank spaces are not permitted. If any item is not applicable
IDENTIFY (As used on label) FX2 or no information is available; the space must be marked to indicate it.
Section I
CHEMENCE INC Emergency Telephone Number 1-800-424-9300
Manufacture's Name
(International Number) 703-527-3887
Address (Number, Street, City, State and ZIP Code) (770)-664-6624
Telephone Number for Information
185 BLUEGRASS VALLEY PARKWAY 4/7/05
Data Prepared
Signature of Preparer (Optional)
ALPHARETTA, GA 30005-2222
Section II ?Hazardous Ingredients/Identity Information
Hazardous Components (Specify Chemical Identity: Common Name(s) OSHA PEL ACGIH TLV Other Limits Recommended % Optional)
Polyglycol Dimethacrylate (109-16-0) 60 ?65
Aromatic Dimethacrylate Ester (24448-20-2) 30 ?35
Surfactant (Proprietary) 1?
Cumene Hydroperoxide* (80-15-2) 1?
Saccharin (81-07-2) 0.1 ?1
*Listed as SARA Section 313 Toxic Chemical
Section III ?Physical/Chemical Characteristics
>300oF
Boiling Point Specific Gravity (H2O =1) 20癈 1.09
Vapor Pressure (mm Hg) Less than 5mmHG @ 72癋 Melting Point N/A
Clear, colorless to straw with a mild odor.
Appearance and Odor
Section IV ?Fire and Explosion Hazard Data
>200oF TCC
Flash Point (Method Used) Flammable Limits N/DA N/DA
LEL UEL
Extinguishing Media: Dry chemical, CO2, foam.
Special Fire Fighting Procedures: Wear suitable protective equipment. Water may be ineffective in fire
fighting due to low solubility. Use water/spray fog for cooling. Explosion proof electrical equipment.
Unusual Fire and Explosion Hazards: N/A
Section V ?Health Hazard Data
Threshold Limit Value: Cumene hydroperoxide 1ppm (6mg/m3) Skin (WEEL); ACGIH & OSHA: none
Effects of overexposure:
May cause irritation to eyes, respiratory system and skin.
May cause sensitization by skin contact. Prolonged/repeated exposure can result in significant absorption.
Emergency and First Aid Procedures:
Eyes: Rinse eyes immediately with plenty of water for 20-30 mins. Obtain medical attention.
Skin: Wash skin with plenty of soap and water for 15 min. If sticky, use a waterless cleaner first. Seek
medical attention if irritation develops.
Inhalation: Remove to fresh air and give O2/artificial respiration as necessary.
Ingestion: Do not induce vomiting, give water to drink. Seek medical attention.
Section VI ?Reactivity Data
Unstable
Stability Conditions to Avoid: High temperatures, direct sunlight, oxidizing conditions,
freezing conditions and UV radiation.
Stable
X (Under normal conditions)
Incompatibility (Materials to avoid) As below.
Hazardous Decomposition Products: Acrid smoke, fumes of CO, CO2 and small quantities of NOx.
May occur
Hazardous X Conditions to Avoid: If over-catalyzed or insufficiently aerated after
catalyzation. This polymerization is exothermic.
Polymerization
Will not
occur
Section VII ?Spill or Leak Procedures
Steps to be taken in case material is to be released or spilled: Evacuate/limit access. Ensure adequate
protective equipment. Kill all ignition sources. Plug sewer/public water outlets. Blanket large spill will fire
fighting foam and remove/recover. Absorb small spill with inert material (sand, sawdust etc.). Wash area.
Waste Disposal Method: Contaminated product/soil/water may be hazardous waste due to the potential
for internal heat generation. Landfill solids at permitted sites. Use registered transporters. Burn
concentrated liquids in systems that use compatible fuel. Ensure emissions comply with regulation. Dilute
aqueous waste may be biodegradable. Ensure effluent complies with applicable regulations.
Section VIII ?Special Protective Information
Respiratory Protection (Specify Type) For high concentrations: Approved air purifying or supplied air
respirator in positive mode.
Local Exhaust Recommended Special None
Ventilation
Mechanical Not Applicable Other None
Protective Gloves: Chemical resistant gloves. Eye Protection: Splash goggles or Safety Glasses.
Other Protective Equipment: N/A
Section IX ?Special Precautions
Precautions to be taken in handling and storing: Store in air atmosphere, sheltered from light and at
temperatures <35癈. Avoid proximity of flames and heat sources. Prevent freezing, prevent moisture
contact. Store in original closed containers.
Other Precautions: Keep away from strong oxidizers, radiation and other initiators. Avoid long storage
times.
Section X ?Regulatory Information
All components are listed or are exempt from listing on the TSCA Inventory and the DSL
CA Proposition 65: Warning! This product contains or may contain trace chemicals known to the State of
California to cause cancer and birth defects or other reproductive harm.
Estimated HMIS Code: Health Hazard (2) Fire Hazard (1) Reactivity (2)
Section XI ?Transportation Information
DOT (49 CFR 172) Unrestricted
IATA: Unrestricted
Information presented herein has been compiled from sources considered to be accurate and reliable, but is not guaranteed to be so.
Nothing herein shall be considered as recommending practices or products in violation of any patent, law or regulation. It is the user's
responsibility to determine the suitability of any material for a specific purpose and to adopt such safety precautions as may be
necessary. WE MAKE NO WARRANTIES REGARDING THE PRODUCTS AND DISCLAIM ALL EXPRESS OR IMPLIED
WARRANTIES, INCLUDING ANY WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.
REVISED 12/05/05