Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: HEAVY DUTY ALUMINUM RADIATOR FLUSH 22 FL.OZ.
Item No: 80032
Product Type: Cleaner
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL:
CITRIC ACID 10-30 Not listed Not Listed
77-92-9
TETRASODIUM EDTA 5-15 Not listed Not Listed
64-02-8
N-METHYL-2-PYRROLIDONE <5 Not listed Not Listed
872-50-4
25 ppm TWA; 240 mg/m3 TWA
2-BUTOXYETHANOL <5 20 ppm
111-76-2
2 mg/m3
POTASSIUM HYDROXIDE <5 Not Listed
1310-58-3
DODECYLBENZENE SULFONIC <5 Not listed Not Listed
ACID
27176-87-0
3. HAZARDS IDENTIFICATION
Harmful if swallowed. Causes burning sensation of the mouth, throat, and stomach. Contact with eyes
Toxicity:
may cause irritation, burns and risk of eye damage. Severe irritation or burns, necrosis, blistering and
permanent injury. Excessive inhalation causes headache, dizziness, nausea, and incoordination.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
May cause pain, redness or swelling of the eyes and excessive blinking and tear production. Skin
Signs and Symptoms of Exposure:
redness. Excessive exposure may cause headache, nausea, vomiting and weakness. May cause
inflammation of mucous membranes and irritation.
Component Weight% NTP ACGIH Carcinogens IARC
2-BUTOXYETHANOL <5 male rat-no evidence; A3 Group 3; Monograph 88,
111-76-2 female rat-equivocal 2006
evidence; male mice-
some evidence;
female mice-some
evidence
None known.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Drink water or milk. Seek medical attention immediately. Never
Ingestion:
give fluids or induce vomiting if the victim is unconscious or having convulsions.
If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
Inhalation:
breathing is difficult give oxygen. Get medical attention..
In case of contact, immediately flush skin with plenty of soap and water for at least 15 minutes. Get
Skin Contact:
medical attention. Remove contaminated clothing and launder before reuse.
Flush eyes with clean water for at least 20 minutes while gently holding eyelids open, lifting upper and
Eye Contact:
lower lids.
5. FIRE FIGHTING MEASURES
None
Flash Point 癋(C?:
Water fog, carbon dioxide, foam, dry chemical.
Recommended Extinguishing Media:
1 of 3
Product Name: HEAVY DUTY ALUMINUM RADIATOR Item No: 80032
FLUSH 22 FL.OZ.
5. FIRE FIGHTING MEASURES
Firefighters should wear self-contained breathing apparatus. Water spray
Special Fire-Fighting Procedures:
may be ineffective on flames but should be used to keep fire-exposed
containers cool.
Oxides of carbon
Hazardous Products of Combustion:
None.
Unusual Fire/Explosion Hazards:
Not determined.
Lower Explosive Limit:
Not determined.
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Neutralize with alkaline material such as soda ash or lime. Maintain good
Spill Procedures:
ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal. Prevent from
entering waterways or sewers. Wear appropriate protective and respiratory equipment.
7. HANDLING AND STORAGE
Store in a cool, dry area. Keep containers closed when not in use.
Storage:
Avoid contact with skin and eyes. Avoid breathing vapors, if exposed to high vapor concentration, leave
Handling:
area at once. Wash hands before eating, drinking, chewing gum, using tobacco or using the toilet.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Chemical goggles; also wear a face shield if splashing hazard exists.
Eyes:
Heavy rubber gloves needed.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Yellow liquid
Appearance:
MILD
Odor:
>200癋
Boiling Point:
4.5-6.0
pH:
SOLUBLE
Solubility in Water:
1.09
Specific Gravity:
4.2%
VOC Content(Wt.%):
Not Determined
Vapor Pressure:
>1 (air = 1)
Vapor Density (Air=1):
Slower than ether
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Active metals, Strong oxidizers, Strong alkalis
Incompatabilities:
Heat
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Dispose of in accordance with local, state and federal regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
2 of 3
Product Name: HEAVY DUTY ALUMINUM RADIATOR Item No: 80032
FLUSH 22 FL.OZ.
14. TRANSPORTATION INFORMATION
Unrestricted
DOT Shipping Name:
None
Hazard Class:
None
UN/ID Number:
IATA
Unrestricted
Proper Shipping Name:
None
Class or Division:
None
UN/ID Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
None
Marine Pollutant:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
2-Butoxyethanol, N-Methyl-2-pyrrolidone
CALIFORNIA PROP 65:
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm
.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 0 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 0, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: November/18/2008
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 1
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|