SAF-T-LOK Material Safety Data Sheet
International Corporation CONTACT-CLEAN
Issue Date: 1/19/09
SECTION I - PRODUCT AND COMPANY INFORMATION
Product Name: CCC-11 CONTACT-CLEAN
Product Type: Electric Contact Cleaner
85556
Part Numbers:
Hazard Rating: Health: 1 Fire: 3 Reactivity: 0
Company Identification: SAF-T-LOK International Corporation
300 EISENHOWER LANE NORTH
LOMBARD, IL 60148
Contact: Helen Sherry
Telephone/ Fax: (630) 495-2001
Emergency Phone (24 Hour): (703) 527-3887
Chemtrec (24 Hour): (800) 424-9300
Preparer: Ind. Hygiene Department
Internet: www.saftlok.com
Product Class: Mixture
DOT Hazard Class: Aerosols
Shipping Name: Flammable Gas
SECTION II - INGREDIENT AND HAZARD INFORMATION
Components CAS# OSHA PEL ACGIH TLV Percent
Isohexane 8030-30-6 100 ppm 400 ppm 45
3-Methylpentane 96-14-0 N.E. 500 ppm 20
2, 3-Dimethylbutane 79-29-8 N.E. 500 ppm 20
2, 2-Dimethylbutane 75-83-2 N.E. 500 ppm 15
Methyl alcohol 67-56-1 200 ppm 200 ppm 5
Carbon dioxide 124-38-35000 ppm 500 ppm 5
N-Hexane 110-54-350 ppm 50 ppm 5
SECTION III - HAZARD IDENTIFICATION AND EMERGENCY OVERVIEW
EMERGENCY OVERVIEW
Physical appearance: Aerosol HMIS
Health: 1
Flammability: 3
Reactivity: 0
Personal Protection: B
WARNING; MAY CAUSE: EYE IRRITATION
SKIN IRRITATION
RESPIRATORY TRACT IRRITATION
MAY IRRITATE EXISTING ALLERGIC SKIN CONDITIONS
Relative routes of entry: Skin, Inhalation, Eyes
Skin Contact: Prolonged or repeated contact can result in defatting and drying of the skin which may result in
skin irritation and dermatitis (rash).
Page 1 of 4 Product: CCA-11
Eye Contact: Liquid, aerosols, and vapors of this product are irritating and can cause pain, tearing,
reddening and swelling accompanied by a stinging sensation and / or a feeling like that of fine dust in the
eye.
Respiratory/ Inhalation: Dizziness, Headache, Nausea, decreased blood pressure, changes in heart rate
and cyanosis may result from over-exposure to vapor or skin exposure.
Ingestion: This material may be harmful or fatal if swallowed. May cause severe and permanent damage to
mouth, throat and stomach.
Medical conditions generally aggravated by exposure: Liver and Kidney disease, Anemia, Coronary disease
SECTION IV ?FIRST AID INSTRUCTIONS
Skin Contact: Remove contaminated clothing. Wash affected area with soap and rinse with plenty of water.
Get medical attention if symptoms occur. Wash clothing before reuse.
Eye Contact: Flush with water for at least 15 minutes holding eyelid open. Get medical attention if
symptoms persist.
Respiratory / Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is
difficult, give oxygen. Get immediate medical attention.
Ingestion: Do not induce vomiting. Get medical attention immediately. Give victim a glass of water or milk.
Never give anything by mouth to an unconscious person.
SECTION V ?FIRE FIGHTING INSTRUCTIONS
Flash Point: -20癋 (Setaflash Closed Cup)
Unusual Fire and Explosion Hazards: Closed containers may explode from internal pressure build-up
when exposed to extreme heat and discharge contents.
Vapors can travel to a source of ignition and flash back.
Flammable Limits: LEL: 1.0, UEL: 36
Extinguishing Media: Alcohol foam, Foam, Dry Chemicals, Water fog
Fire Fighting Procedures: Air mask, goggles, and procedures for fighting chemical fires
SECTION VI -ACCIDENTAL RELEASE MEASURES
Special Precautions: Avoid breathing vapors. Ventilate area. Remove all sources
of ignition.
Clean up methods: Absorb spill with inert material (e.g. dry sand or earth), then
place in a chemical waste container.
SECTION VII - HANDLING AND STORAGE
Handling: Avoid contact with eyes, skin, and clothing. Avoid
breathing vapors. Wash hands thoroughly at mealtime
and end of shift.
Storage: Store in a cool location (60-90癋) in a well ventilated
area away from sources of heat. Do not puncture or
Incinerate (burn) cans. Do not stick pin, nail or any other
sharp object into opening on top of can. Do not spray in
Eyes.
Personal Protection: Wear personal protective equipment as outlined in
Section VIII of this MSDS.
Page 2 of 4 Product: CCA-11
SECTION VIII ?EXPOSURE CONTROLS AND PERSONAL PROTECTION
Respiratory Protection: A NIOSH / MSHA approved air purifying respirator with an
Organic vapor cartridge may be permissible under certain
circumstances where airborne concentrations are expected
to exceed exposure limits.
Skin Protection: Use impermeable gloves (neoprene, butyl rubber,
natural rubber), as necessary to avoid skin contact, as
well as proper clothing or plastic apron. Wash hands
before eating, drinking, or using restroom.
Eye Protection: None under normal use, however, use of safety glasses with
splash guards or full face shield is recommended.
Eye Washes: Eye wash stations should be located within 100 feet or
10 second walk of the work area.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Aerosol
Odor: Solvent
Boiling Range: 122癋 ?159癋
Freeze Point: 32癋
Specific Gravity: 0.6829
Vapor Density (Air = 1): Heavier than air
Vapor Pressure (mm Hg.): 95 - 105
Melting Point: N/A
Evaporation Rate: Faster than Butyl Acetate
Solubility in Water: Complete
Volatile Organic Compounds (VOC): 5.43 lbs / gal , 651 grams / ltr
SECTION X 璖TABILITY AND REACTIVITY
Stability: Stable under normal storage conditions
Hazardous Polymerization: Will not occur.
Hazardous decomposition byproducts: Oxides of carbon, oxides of nitrogen, and may produce forms
of chloride, chlorine, and phosgene
Incompatibility: Strong acids, alkalis, oxidizers, and amines
SECTION XI ?TOXICOLOGICAL INFORMATION
Product LD 50: 5 mg / kg Product LC50: 3 ppm
Component Toxicological Information:
CHEMICAL NAME LD50 LC50
Isohexane >5 GM/KG/RAT LCLO 3 PPH/5M/MAN
3-Methylpentane NE NE
2, 3-Dimetylbutane NE NE
2, 2-Dimethylbutane NE NE
Methyl alcohol 64000/PPM/4H/RAT
Carbon dioxide NE RCLO 9 PPH/5M/MAN
N-Hexane 48,000 PPM/4H/RAT 28,710 MG/KG/RAT
SECTION XIi ?ECOLOGICAL INFORMATION
No Information
Page 3 of 4 Product: CCA-11
SECTION XIII ?DISPOSAL CONSIDERATIONS
Recommended method of disposal: Dispose of according to Federal, State and local regulations.
SECTION XIV ?SHIPPING AND TRANSPORTATION INFORMATION
U.S. Department of Transportation Ground (49 CFR)
Proper Shipping Name: Aerosol / Consumer Commodity
Hazard Class or Division: Flammable Gas/ ORM-D
Identification Number: UN 1950
SECTION XV ?REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS: AS FOLLOWS:
OSHA: Hazardous by definition of Hazard Communication Standard (29 CFR 1910.1200)
CERCLA ?SARA HAZARD CATEGORY:
This product has been reviewed according to the EPA "Hazard Categories" promulgated under Sections 311
and 312 of the Superfund Amendment and Reauthorization Act of 1986 (SARAA Title III) and is considered,
under applicable definitions, to meet the following categories:
IMMEDIATE HEALTH HAZARD CHRONIC HEALTH HAZARD FIRE HAZARD REACTION HAZARD
PRESSURIZED GAS HAZARD
SARA SECTION 313:
This product contains the following substances subject to the reporting requirements of Section 313 of Title
III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part 372:
CHEMICAL NAME CAS NUMBER WT/WT % IS LESS THAN
Methyl Alcohol 67-56-1 5
N-Hexane 110-54-3 5
TOXIC SUBSTANCES CONTROL ACT:
This product contains the following chemical substance subject to the reporting requirements of TSCA 12 (B)
if exported from the United States:
CHEMICAL NAME CAS NUMBER
Methyl Alcohol 67-56-1
CALIFORNIA PROPOSITION 65:
No Proposition 65 chemicals exist in this product.
NEW JERSEY RIGHT TO KNOW:
No NJ right to know chemicals exist in this product.
PENNSYLVANIA RIGHT TO KNOW:
No PA right to know chemicals exist in this product
SECTION XVI ?OTHER INFORMATION
Revision date: 1/19/09
DISCLAIMER: The information on this material safety data sheet represents our current data and best
opinion as to the proper use in handling of this product under normal conditions. Any use of the product
which is not in conformance with this data sheet or which involves using the product in combination with any
other product or any other process is the responsibility of the user. SAF-T-LOK International Corporation
specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness
for a particular purpose, arising from sale or use of SAF-T-LOK International Corporation products.
Page 4 of 4 Product: CCA-11
|