Material Safety Data Sheet Date entered: 8/1/08
Date Revised: 11/17/09
Serum Products, LLC Emergency Numbers:
System Date:
850-F Pickens Industrial Drive (866)-791-9595
8667919595
Medical:
Marietta Ga. 30062 U.S.A.
(800)-535-5053
8005355053
Transportation:
(678)-290-1880
Section 1 PRODUCT IDENTIFICATION
(2.) Product Number: 5-222-05
Serum CU
(1.) Product Name:
EPA Reg. No.:
(3.) Chemical name/synonyms: Hydrogen Peroxide Compound (H2O2) EPA Est. No.:
(4.) Chemical family: Organic stain remover and cleaner (5.) Chemical formula: Proprietary
(6.) NFPA & HMIS acute hazard rating: Health: 2 Flammability: Reactivity: (7.) Preparer Name: Bill Lyon Phone: (866)-791-9595
8667919595
0 1
(8.) Personal Protective Equipment: SAFETY GLASSES, CHEMICAL RESISTANT GLOVES
Section 2 CHEMICAL COMPOSITION
Note: list all CERCLA hazardous substances at 1% or greater and carcinogens at 0.1% or greater.
(2.) SARA (3.)
(1.) (4.) (5.) (6.) (7.)
Ingredient: Note 313 : CAS Number: % range: PEL: LD50: TLV:
hydrogen peroxide No 7722-84-1 17-22 n/d n/d n/d
1
Propylene Glycol Monomethyl Ether No 107-98-2 4-8 100 ppm-TWA n/a 100 ppm-TWA
Note Balance: Non hazardous
Section 3 PHYSIOLOGICAL EFFECTS
(1.) Primary routes(s) of entry into body: (2.) Eyes: (3.) Skin: X (4.) Inhalation: (5.) Ingestion:
(6.) Acute effects:
(7.) Eyes: tissue irritation and damage, swelling, blurred vision, blindness
(8.) Skin: Skin burning and or blistering, whitening of skin, pain and soreness
(9.) Inhalation: some tissue irritation, shortness of breath
(10.) Ingestion: Harmful or fatal if ingested in large amounts.
(11.) Chronic effects: none known
Section 4 EMERGENCY AND FIRST AID PROCEDURES
(1.) Eyes: rinse for 15 minutes with potable water while seeking immediate medical attention.
(2.) Skin: wash affected area with soap & water, then rinse with clean, clear water.
(3.) Inhalation: remove victim to fresh air, while seeking immediate medical attention.
(4.) Ingestion: give large amounts of potable water while seeking immediate medial attention.
(5.) Special instructions to physician: Inform medical team that product contains 17% Hydrogen Peroxide
Section 5 FIRE AND EXPLOSION HAZARD DATA
(1.) Flash point: n/a 0 (4.) Auto ignition temperature: n/d 0
F (2.) Method: TOC (3.) Flammable limits in air: n/d C
(5.) Suitable extinguishing media: water, foam or CO2 (6.) Hazardous combustion biproducts: oxygen
(7.) Rec. fire fighting procedures: normal procedures (8.) Unusual fire explosion hazards: when heated will yield flammable vapor
Section 6 ENVIRONMENTAL INFORMATION
(1.) Spill or leak procedures:
(2.) Small spill leak: stop leak. mop or vacuum to disposal container or rinse to sanitary sewer.
(3.) Large spill leak: stop leak. mop or vacuum to disposal container or rinse to sanitary sewer.
(4.) Spill reportable quantity: 1000 pounds
(5.) Waste disposal method:follow local, state and federal guidelines.
(6.) EPA appropriate waste classification: none
(7.) RCRA appropriate characteristic waste: n/a (8.) if so EPA hazardous waste number: n/a
(9.) RCRA appropriate listed waste: n/a (10.) if so EPA hazardous waste number: n/a
(11.) non RCRA regulated waste: n/a
(12.) Procedure for handling empty containers: do not reuse. give container to licensed drum reconditioner.
(13.) Environmental toxicity data: BIODEGRADABLE - decomposes to water and oxygen
(14.) Other regulatory controls: none
1
continued from page 1
(15.) Is material classified under the CLEAN WATER ACT (USA) or appropriate water regulations as a:
(16.) Toxic pollutant (section 307): No
(17.) Hazardous substance (section 311)?: No
(18.) if yes, reportable quantity (R.Q.): n/a
(18.) Oil section 311? No
(19.) Is material classified under the CLEAN AIR ACT (USA) or appropriate CLEAN AIR regulations as a:
(20.) Hazardous air pollutant section (12)?: No
(21.) Comments: none
Section 7 STORAGE AND HANDLING PRECAUTIONS
(1.) Storage: store at temperatures below 120 F and above 32 F
(2.) Handling: use chemical resistant gloves and eye protection when handling concentrate
(3.) Precautionary labeling: OXIDIZER, CORROSIVE
Section 8 OCCUPATIONAL CONTROL PROCEDURES
(1.) Ventilation: (2.) local exhaust X (3.) general exhaust (4.) none required
(5.) Personal protective equipment:
(6.) Respirator type: FULL FACE WITH 3M 60926 OR EQUIVALENT CARTRIDGES (CHEMICAL VAPOR WITH P100 PREFILTER)
(7.) Gloves: (8.) Natural rubber: (9.) plastic: (10.) nitrile: (11.) neoprene: X (13.) other:
(12.) butyl:
(18.) other:
(14.) Eye protection: (15.) glasses with side shield: X (16.) full face shield: (17.) chemical splash goggles:
Section 9 PHYSICAL DATA
Liquid
(1.) Appearance: Water Clear (2.) Odor:None (3.) Physical state:
(4.) Boiling Point: 212 (5.) Freeze Point: 32 (6.) Specific Gravity: 1.05 (7.) pH Neat: 3.5 (8.) pH 1%: 4.5 (9.) % Solids: 12.7%
(10.) % Volatiles: 87.3% (11.) Solubility Water: Complete (12.) Vapor pressure: n/d (13.) Vapor density: n/d
(14.) Evaporation rate: <1 (15.) VOC Less Exempt (theoretical): 0.00 lbs./gal (16.) VOC As Packaged (theoretical): 0.00 lbs./gal.
(17.) Foam Potential: (18.) Ozone Depleting Compounds: (19.) Hazardous Air Pollutants:
(20.) Carcinogens, Mutagens, Teratogens (NTP, IARC, OSHA): (21.) EPA Clean Water Act:
0
(22.) SARA Title III, Section 313 Reportable: (22.) Boiling Point: 212 F Initial (23.) Flammability:
Section 10 REACTIVITY DATA
(1.) Thermal stability: Stable
(2.) Condition to avoid: none
(3.) Hazardous decomposition products: none
(4.) Hazardous polymerization: may occur: X
will not occur:
(6.) Materials to avoid: none
(7.) Corrosive action on materials: none
Section 11 TOXICOLOGICAL INFORMATION
(1.) Summary of health effects:
Immediate irritation of skin, skin turns white upon contact with liquid. No long term damage to epidermis or dermas expected. Symptoms disappear within 30-60 minutes
Section 12 SHIPPING REQUIREMENTS
(1.) Indicate country/regulatory agency which specifies requirements: U.S.A.-DOT
(2.) Proper Shipping name:
Hydrogen Peroxide, Aqueous Solution with not less than 8%, but less than 20% hydrogen peroxide, 5.1, UN-2984, PG III, ERG#60, Item Name: Serum CU, Item
Number: 5-222-05, NMFC#:48580-03, Container:Pail
(3.) Hazardous class: (4.) Identification number: (5.) Packaging group: (6.) Emergency response guide number:
5.1, UN-2984, PG III, ERG 6
(7.) Labels required: Oxidizer
(8.) Other requirements: none
(9.) Note: Product above 180 degrees F will yield large amounts of pure oxygen to create an explosive condition.
Product Name: Serum CU DOT Hazard Classification: OXIDIZER 5.1
Product Number: 5-222-05 n/d = not determined; n/a = not applicable
2
|