MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT: Gagekote 5 Part A November 13, 2008
Vishay Micro-Measurements MSDS # MGM086B
Post Office Box 27777
Raleigh, NC 27611
919-365-3800
CHEMTREC 1-800-424-9300 (U.S.)
703-527-3887 (Outside U.S.)
NOTE: CHEMTREC numbers to be used only in the event of chemical emergencies involving a spill, leak, fire,
exposure or accident involving chemicals.
SECTION 2: HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
CAS NUMBER CHEMICAL IDENTITY %
90-72-2 2,4,6 Tri (dimethylaminomethyl) Phenol 1-5
NOTE: Balance of product components are non-hazardous.
SECTION 3: HEALTH HAZARD DATA
Routes of Entry:
Inhalation: Yes Skin: Yes Ingestion: Accidental
Health Hazards (Acute and Chronic): Product is considered a severe eye and skin irritant. The likelihood of
severe irritation is low.
Carcinogenicity: NTP: Not listed
IARC Monographs: Not listed
OSHA Regulated: Not listed
Signs and Symptoms of Exposure:
INHALATION: Due to very low vapor pressure this product is not normally considered an inhalation hazard. If
product is heated or sprayed, it may cause irritation to the nose, throat and upper respiratory tract.
DOCUMENT NO.: 14017 805-FRM011
Gagekote 5 Part A MSDS # MGM086B
EYE CONTACT: May cause moderate to severe irritation. If allowed to remain in the eye it could cause
permanent, irreversible eye injury.
SKIN CONTACT: Irritation is possible but unlikely. Continued or prolonged usage may cause irritation.
INGESTION: None listed.
Conditions Generally Aggravated by Exposure: None listed.
SECTION 4: EMERGENCY AND FIRST AID PROCEDURES
INHALATION: Move to fresh air. Aid in breathing if necessary.
EYE CONTACT: Immediately rinse eyes with running water for at least 15-30 minutes. Get immediate medical
attention.
SKIN CONTACT: Remove contaminated clothing. Launder clothing before re-use. Wash skin promptly with soap
and water. Get medical attention.
INGESTION: Drink 1-2 glasses of water or milk. Do NOT induce vomiting. Never give anything by mouth to an
unconscious person.
SECTION 5: FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): >200癋 ( 93.3癈) Setaflash Closed Cup
Flammable limits: LEL: Unknown UEL: Unknown
Extinguishing Media: Water, foam, dry chemical, carbon dioxide.
Special Firefighting Procedures: Full emergency equipment with self-contained breathing apparatus and full
protective clothing (turnout gear) should be worn by firefighters.
Unusual Fire and Explosion Hazards: Burning of this material will result in the release of toxic fumes.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Steps to be taken if material is released or spilled: Evacuate non-essential personnel. Remove all sources of
ignition and ventilate the area. Dike or impound spilled material and control further spillage if feasible. Absorb on
inert carrier. Sweep, scrape or vacuum up. Shovel into secure containers for proper disposal. Use appropriate
personal protective equipment.
2
DOCUMENT NO.: 14017 805-FRM011
Gagekote 5 Part A MSDS # MGM086B
SECTION 7: EXPOSURE CONTROLS -- PERSONAL PROTECTION
Respiratory Protection: In some situations, a respirator may be necessary in addition to ventilation. The use of a
NIOSH-certified or MSHA approved respirator for organic vapors is recommended when the level of vapors exceed
the TLV or when the level is unknown.
Ventilation: General mechanical exhaust and local ventilation, or isolation may be needed to keep airborne
concentrations or regulatory hazards within acceptable levels. Effective engineering controls should be used
whenever possible to eliminate or reduce worker exposure to all respiratory hazards. This product has a strong
odor, and although the vapors are not considered toxic, local exhaust is recommended for worker comfort.
Protective Gloves: Wear impervious gloves. Neoprene, polyvinyl chloride or nitrile gloves are recommended for
most normal handling operations.
Eye Protection: Safety glasses, splash goggles or faceshield. Contact lenses should not be worn.
Other Protective Clothing or Equipment: Safety showers and eyewash stations should be available.
Work / Hygienic Practices: Observe good hygiene practices. Wash hands after using and before eating, drinking
or smoking.
SECTION 8: HANDLING AND STORAGE
Precautions to be taken in handling and storing: Store away from sources of direct heat in a dry area.
Other Precautions: None listed.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point: NA
Vapor Pressure (mmHg): NA
Vapor Density (Air = 1): NA
Specific Gravity (H2O = 1): 1.2
Melting Point: NA
Evaporation Rate (BuAc = 1): Unknown
Volatile Organic Compounds: Unknown
Solubility in Water: Slightly soluble
Appearance and Odor: Red liquid, moderate viscosity, mercaptan odor.
SECTION 10: STABILITY AND REACTIVITY DATA
Stability: Stable.
Conditions to Avoid: Direct heat.
3
DOCUMENT NO.: 14017 805-FRM011
Gagekote 5 Part A MSDS # MGM086B
Incompatibility (Materials to Avoid): Strong oxidizing and/or reducing agent.
Hazardous Decomposition or By-products: Oxides of sulfur, carbon and nitrogen under burning conditions.
Hazardous Polymerization: Will not occur.
SECTION 11: TOXICOLOGICAL INFORMATION
2,4,6 Tri (dimethylaminomethyl) phenol
OSHA PEL: Not established
ACGIH TLV: Not established
OTHER: Not established
SECTION 12: DISPOSAL CONSIDERATIONS
Waste Disposal Method: Dispose of in accordance with local, state, and federal environmental regulations.
Classified as a non-hazardous waste under the criteria of RCRA (40CFR261). Keep out of public water supplies.
SECTION 13: TRANSPORTATION INFORMATION
SHIPPING NAME CLASS PACKING GROUP UN NUMBER
Chemical Kit* 9 II 3316
*When shipped as a kit containing Gagekote 5 Parts A & B.
SECTION 14: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION:
This product contains a toxic chemical or chemicals (as listed below) subject to the reporting requirements of
Section 313 Title III of the Superfund Amendment and Reauthorization Act of 1986 and 40 CFR Part 372.
CAS NUMBER CHEMICAL NAME % BY WEIGHT
NONE
TSCA NOTIFICATION:
All components of this product are listed in the Toxic Substance Control Act Chemical Substance Inventory (TSCA).
4
DOCUMENT NO.: 14017 805-FRM011
Gagekote 5 Part A MSDS # MGM086B
SECTION 15: OTHER INFORMATION
To the best of our knowledge, the information provided above meets the requirements of the United States
Occupational Safety and Health Act and regulations established under 29 CFR 1910.1200 (g)(2)(c)(1)-(4) for a
mixture of hazardous chemicals which has not been tested as a whole. The data provided on this Material Safety
Data Sheet is from manufacturers of the original components. Vishay Micro-Measurements specifically disclaims
any and all form of liability and/or responsibility for the application of this product.
5
DOCUMENT NO.: 14017 805-FRM011
|