PRO CHEM, INC. MATERIAL SAFETY DATA SHEET HEALTH 2
1475 BLUEGRASS LAKES PKWY.
TIRE BRITE / 1287
ALPHARETTA, GA 30004 FIRE 4
EMERGENCY/INFO # (800) 241-8180
NOVEMBER 2009 REACTIVITY 0
ADDITIONAL EMERGENCY # INFO TRAC 1-800-535-5053
PAGE 1 P.P.E. B
Complies With USDL Safety and Health Regulations, (29 CFR 1910.200)
SECTION 1 ?Chemical and Company Identification SECTION 5 ?Fire Fighting Measures
CHEMICAL FAMILY: Tire Dressing USA FLAME PROJECTION TEST (ASTM D-3065): Greater than 18", flashback, extremely flammable
FLAMMABLE LIMITS: No Data LEL: No Data UEL: No Data
EXTINGUISHING MEDIA: Foam or dry chemical. Treat as an oil fire. Fire may float on water and
SECTION 2 ?Composition on Ingredients
spread.
COMPONENTS CAS No. OSHA PEL ACGIH-TLV OTHER LIMITS % (Opt.)
SPECIAL FIRE FIGHTING PROCEDURES: Use water spray to keep containers cool and vapors
(Chemical Identity, RECOMMENDED
down. Do not allow runoff to enter sewers or public watercourses. Wear self-contained breathing
Common Name(s))
apparatus in chemical fires.
Acetone 67-64-1 1000 ppm 500 ppm STEL 750 40-70%
HAZARDOUS PRODUCTS OF COMBUSTION: Carbon dioxide, carbon monoxide, silicon dioxide,
Tert Butyl Acetate 540-88-5 200 ppm 200 ppm 10-30%
formaldehyde, smoke, soot and various organic oxidation by-products.
Aliphatic Petroleum 64742-49-0 None None 7-13%
UNUSUAL FIRE AND EXPLOSION HAZARDS: Aerosol container (pressurized) may burst if heated
Distillates
Carbon dioxide 124-38-9 5000 ppm 5000 ppm STEL 30000 ppm 5-10% over 120F. Extremely flammable liquid and vapor. Flammable vapors are heavier than air and may
Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or Texas is
travel along the ground to distant ignition sources where they may ignite or explode.
described above if known present in regulated concentrations.
SECTION 6 ?Accidental Release Measures
SECTION 3 ?Hazards Information
SMALL SPILL: Caution, slip hazard. Wipe up small releases with a dry absorbent cloth or other
ROUTE(S) OF ENTRY: EYES: YES INHALATION: YES SKIN: NO INGESTION: YES
absorbent material. Remove any residues with a safety solvent or suitable detergent. For large spills,
ACUTE HEALTH HAZARDS: Danger. Extremely flammable liquid and vapor. Harmful if inhaled or
isolate traffic and ventilate area.
swallowed. Contains petroleum distillates. Causes eye irritation. May cause skin irritation. Aspiration
LARGE SPILL: Eliminate all ignition sources. Ventilate area and block traffic. Absorb liquid with
hazard. Repeated or prolonged skin contact may cause dermatitis. Overexposure to vapors will
vermiculite, absorbent cloth, or other absorbent material. Wear protective gear as necessary. Dike to
induce central nervous system effects. Follow good chemical hygiene practices to avoid these
prevent spread. Prevent material from entering sewers or drains. Transfer contaminated material into
hazards. Contents under pressure.
suitable container for proper disposal.
NOTE: Do not use on or near steering wheels, gas, brake or clutch pedals or any other vehicle control
surface. Do not use on seats of motorcycles or bicycles or other surfaces compromised by slippery
SECTION 7 ?Handling and Storage
coatings. Use in warm areas (minimum 50癋) only to achieve acceptable spray pattern and even
coverage. HANDLING: Do not use around ignition sources such as heat, sparks, open flame, hot metal, static
CHRONIC HEALTH HAZARDS: None known electricity, electric motors and compressors, etc. Do not smoke while using. Do not deliberately
CARCINOGENITY: concentrate and inhale vapors. Use with adequate ventilation. Do not swallow. Wash thoroughly
OSHA: NO CHEMICAL: NO NTP: NO IARC: NO after handling. Do not allow eye contact. Avoid contact with skin and clothing. Direct spray away
SIGNS AND SYMPTOMS OF EXPOSURE: Redness, tearing, burning in eyes. Dryness, redness or from face.
cracking skin. Swallowing or inhalation may cause drowsiness, dizziness, fatigue, headache or loss of STORAGE: Store in a cool (under 120F) dry location away from heat, sparks, open flame, and direct
coordination. sunlight. Follow label directions carefully. Keep out of reach of children. Replace cap when not in use.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Pre-existing skin disorders Do not puncture or incinerate container.
may be adversely affected. May affect the central nervous system (CNS) and/or aggravate pre-
existing CNS disorders. Follow good chemical hygiene practices when using this and other chemical SECTION 8 ?Exposure Controls/Personal Protection
products.
EYE PROTECTION: Yes, if direct contact is possible use goggles or approved safety
glasses. (ANSI Z87)
SECTION 4 ?First Aid Measures SKIN PROTECTION: Yes, if direct contact is possible.
EYES: Flush with plenty of water for at least 15 minutes lifting eyelids to ensure complete RESPIRATORY PROTECTIONS: Not usually necessary. Use with adequate ventilation. Use
removal. See a physician immediately. NIOSH/MSHA approved respirator if PELs or TLVs are
SKIN: Wash thoroughly with soap and water while removing contaminated clothing and exceeded.
shoes. Launder contaminated clothing before reuse. If irritation arises and persists, ENGINEERING CONTROLS: Ventilation not usually necessary but should be provided in the
call a physician. event of overexposure.
INHALATION: Get to fresh air. If breathing has stopped, qualified personnel should administer
artificial respiration.
INGESTION: Do not induce vomiting. Aspiration hazard. Call a physician or poison control center
immediately.
THIS INFORMATION MUST BE ON ALL MSDS'S COPIED AND DISTRIBUTED FOR THIS MATERIAL.
NO WARRANTY IS EXPRESSED/IMPLIED REGARDING THE ACCURACY OF THIS DATA OR
RESULTS OBTAINED FROM USE. PROCHEM ASSUMES NO RESPONSIBILITY FOR PERSONAL
INJURY OR PROPERTY DAMAGE TO USER. VENDEE/USER ASSUMES ALL RISKS ASSOCIATED
WITH USE.
PRO CHEM, INC. MATERIAL SAFETY DATA SHEET HEALTH 2
1475 BLUEGRASS LAKES PKWY.
TIRE BRITE / 1287
ALPHARETTA, GA 30004 FIRE 4
EMERGENCY/INFO # (800) 241-8180
NOVEMBER 2009 REACTIVITY 0
ADDITIONAL EMERGENCY # INFO TRAC 1-800-535-5053
PAGE 2 P.P.E. B
Complies With USDL Safety and Health Regulations, (29 CFR 1910.200)
HAZARD CLASS: 2.1
SECTION 9 ?Physical and Chemical Properties
IDENTIFICATION NUMBER: UN 1950
APPEARANCE/ODOR: Clear colorless liquid with a light acetone odor in an aerosol can.
PACKING GROUP: None
pH: N/A SPECIFIC GRAVITY (70F): 0.812
MARINE POLLUTANTS: None
BOILING POINT: MELTING POINT: No Data
180F
SECTION 15 ?Regulatory Information
EVAPORATION RATE (Butyl Acetate = 1): No Data
US Federal Regulations:
PRESSURE (psig. @ 70F): 65+ 5 VAPOR DENSITY (AIR=1): Greater than one (1)
TSCA (Toxic Substances Control Act) Status: All ingredients are on the TSCA inventory or are
SOLUBILITY IN WATER: Negligible
not required to be listed on the TSCA inventory.
VOLATILE ORGANIC COMPOUNDS (VOCs): 84.23 grams per liter or 9.99% by weight VOC's.
CERCLA RQ ?40 CFR 372.6 (a) : Acetone ?5000 lbs.
SECTION 10 ?Stability and Reactivity SARA 313 Components ?40 CFR 372.65: Tert Butyl Alcohol (CAS 75-65-0) - < 0.5%
HAZARDOUS POLYMERIZATION: This product will not undergo hazardous polymerization.
State and Local Regulations:
HAZARDOUS DECOMPOSITION/BY-PRODUCTS: Carbon dioxide, carbon monoxide, silicon
California Proposition 65
dioxide, formaldehyde, smoke, soot and various organic oxidation by-products. Very long-term
Warning: This product contains a chemical (<1.5 mg/kg Benzene) known to the state of
storage may risk the formation of unstable peroxides.
California to cause cancer and birth defects or reproductive harm.
CHEMICAL STABILITY: Stable
INCOMPATIBILITY (Materials to Avoid): Extreme heat, sparks, open flame direct sunlight. Strong
SECTION 16 ?Other Information
oxidizing agents, alkaline materials, acids, nitrates, reactive metals (sodium, potassium, magnesium)
and their hydrides. WARNING! The use of this product is beyond the control of the manufacturer; therefore, no
guarantee, expressed or implied, is made as to the effects of such or the results to be obtained if not
SECTION 11 ?Toxicological Information used in accordance with directions or established safe practice. The user must assume all
No Data. responsibility, including injury or damage, resulting from its misuse as such, or in combination with
other materials. The manufacturer warrants only that this product meets the manufacturer's
specifications for such product. THIS WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES,
SECTION 12 ?Ecological Information
EXPRESS OR IMPLIED, AS TO DESCRIPTION, QUALITY, MERCHANTABILITY. FITNESS FOR
No Data
ANY PARTICULAR PURPOSE, PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS
PRODUCT. THE MANUFACTURER SHALL BE IN NO WAY RESPONSIBLE FOR THE IMPROPER
SECTION 13 ?Disposal Consideration USE OF THIS PRODUCT. The sole and exclusive remedy against the manufacturer for breach of
DISPOSAL METHOD: Dispose of in accordance with all applicable local, state, and warranty shall be reimbursement of the purchase price of the product in the event that a defective
federal regulations. condition of the product shall be found to exist. NO OTHER REMEDY (INCLUDING BUT NOT
RCRA WASTE INFORMATION: If this product becomes a waste, it would be a hazardous waste LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR INJURY TO PERSON OR
(D001) as defined by RCRA (40 CFR 261). However the waste PROPERTY OR ANY OTHER INCIDENTAL OR CONSEQUENTIAL LOSS) SHALL BE AVAILABLE.
should be properly characterized to evaluate whether its
composition has been modified prior to disposal.
SECTION 14 ?Transport Information
DOT INFORMATION: 49 CFR 172.101
PROPER SHIPPING DESCRIPTION: Consumer Commodity
HAZARD CLASS: ORM-D
IDENTIFICATION NUMBER None
PACKING GROUP: None
WATER TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: Aerosols
HAZARD CLASS: 2.1
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: None
AIR TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: Aerosols, Flammable
THIS INFORMATION MUST BE ON ALL MSDS'S COPIED AND DISTRIBUTED FOR THIS MATERIAL.
NO WARRANTY IS EXPRESSED/IMPLIED REGARDING THE ACCURACY OF THIS DATA OR
RESULTS OBTAINED FROM USE. PROCHEM ASSUMES NO RESPONSIBILITY FOR PERSONAL
INJURY OR PROPERTY DAMAGE TO USER. VENDEE/USER ASSUMES ALL RISKS ASSOCIATED
WITH USE.
|