GLUCAMTM P-10 HUMECTANT
Material Safety Data Sheet
GLUCAMTM P-10 HUMECTANT
Prepared according to 29CFR 1910.1200.
1 Chemical Product and Company Identification
The Lubrizol Corporation
29400 Lakeland Boulevard
Wickliffe, Ohio 44092
Tel: (440) 943-4200
GLUCAMTM P-10 HUMECTANT
Product Trade Name
61849-72-7
CAS Number
PPG-10 Methyl Glucose Ether
Synonyms
Propoxylated alcohol
Generic Chemical Name
Methyl Glucosides
Product Type
24 August 2009
Preparation/Revision Date
FOR TRANSPORT EMERGENCY call CHEMTREC: (+1) 703-527-3887 (outside the
Transportation Emergency
U.S.), 1-800-424-9300 (in the U.S.)
Phone No.
28881447-2121828-4020930-102103
MSDS No.
2 Hazards Identification
Yellow liquid.
Appearance
Mild
Odor
Principal Hazards
This material has no known health hazards.
See Section 11 for complete health hazard information.
3 Composition/Information on Ingredients
This material has no known hazards under applicable laws.
Hazardous Ingredients
4 First Aid Measures
Flush with water at least 30 minutes. Get medical attention if eye irritation develops or
Eyes
persists.
Wash with soap and water. Get medical attention if irritation develops. Launder
Skin
contaminated clothing before reuse.
Remove exposed person to fresh air if adverse effects are observed.
Inhalation
DO NOT INDUCE VOMITING. Get immediate medical attention.
Oral
Note to physician: Treat symptomatically.
Additional Information
5 Fire Fighting Measures
Page 1 of 6
GLUCAMTM P-10 HUMECTANT
271 癈, 519.8 癋 COC (Typical)
Flash Point
CO2, dry chemical, or foam. Water can be used to cool and protect exposed material.
Extinguishing Media
Wear full protective firegear including self-containing breathing apparatus operated in the
Firefighting Procedures
positive pressure mode with full facepiece, coat, pants, gloves and boots. A solid stream of
water will spread the burning material.
Unusual Fire & Explosion
Not determined.
Hazards
6 Accidental Release Measures
Personal Protective Equipment must be worn, see Personal Protection Section for PPE
Spill Procedures
recommendations. Ventilate area if spilled in confined space or other poorly ventilated areas.
Prevent entry into sewers and waterways. Pick up free liquid for recycle and/or disposal.
Residual liquid can be absorbed on inert material.
7 Handling and Storage
Not determined.
Pumping Temperature
Maximum Handling
Not determined.
Temperature
Keep containers closed when not in use. Avoid prolonged exposure to heat and air. Mix well
Handling Procedures
before using. Wash thoroughly after handling. Empty container contains product residue
which may exhibit hazards of product.
Maximum Storage
Not determined.
Temperature
No special storage precautions required.
Storage Procedures
Not determined.
Loading Temperature
8 Exposure Controls/Personal Protection
None established
Exposure Limits
None known.
Other Exposure Limits
Use with adequate ventilation.
Engineering Controls
Use nitrile or neoprene gloves.
Gloves Procedures
Safety Glasses.
Eye Protection
Use NIOSH/MSHA approved respirator with a combination organic vapor and high
Respiratory Protection
efficiency filter cartridge if recommended exposure limit is exceeded. Use self-contained
breathing apparatus for entry into confined space, for other poorly ventilated areas and for
large spill clean-up sites.
Long sleeve shirt is recommended. Launder contaminated clothing before reuse.
Clothing Recommendation
9 Physical and Chemical Properties
271 癈, 519.8 癋 COC (Typical)
Flash Point
Not determined.
Upper Flammable Limit
Not determined.
Lower Flammable Limit
Not determined.
Autoignition Point
Material does not have explosive properties. High temperatures can cause containers to
Explosion Data
rupture due to a build up of internal pressure.
Not determined.
Vapor Pressure
Page 2 of 6
GLUCAMTM P-10 HUMECTANT
5-8
pH
1.1 (20 癈)
Specific Gravity
Not determined.
Bulk Density
Soluble.
Water Solubility
Not determined.
Percent Solid
Not determined.
Percent Volatile
Not determined.
Volatile Organic Compound
Not determined.
Vapor Density
Not determined.
Evaporation Rate
Mild
Odor
Yellow liquid.
Appearance
Not determined.
Viscosity
Not determined.
Odor Threshold
> 316 癈, > 600.8 癋(Initial)
Boiling Point
Not determined.
Pour Point Temperature
Not determined.
Melting / Freezing Point
The above data are typical values and do not constitute a specification. Vapor pressure
data are calculated unless otherwise noted.
10 Stability and Reactivity
Material is normally stable at moderately elevated temperatures and pressures. Product can
Stability
oxidize at elevated temperatures.
Decomposition Temperature 300 癈, 572 癋
Strong acids. Strong oxidizing agents.
Incompatibility
Will not occur.
Polymerization
Smoke, carbon monoxide, carbon dioxide, aldehydes and other products of incomplete
Thermal Decomposition
combustion.
Not determined.
Conditions to Avoid
11 Toxicological Information
-- ACUTE EXPOSURE --
Not expected to cause eye irritation Based on data from components or similar materials.
Eye Irritation
Not expected to be a primary skin irritant. Based on data from components or similar
Skin Irritation
mateials.
No data available to indicate product or components may cause respiratory irritation under
Respiratory Irritation
normal workplace conditions and good industrial hygiene practices.
The LD50 in rabbits is > 2000 mg/Kg. Based on data from similar materials.
Dermal Toxicity
No data available to indicate product or components may be a toxic inhalation hazard.
Inhalation Toxicity
The LD50 in rats is > 5000 mg/Kg. Based on data from similar materials.
Oral Toxicity
Not expected to cause skin sensitization. Based on data from components or similar
Dermal Sensitization
materials.
No data available to indicate product or components may be respiratory sensitizers.
Inhalation Sensitization
-- CHRONIC EXPOSURE --
No data available to indicate product or components present at greater than 1% are chronic
Chronic Toxicity
health hazards.
Page 3 of 6
GLUCAMTM P-10 HUMECTANT
No data available to indicate any components present at greater than 0.1% may present a
Carcinogenicity
carcinogenic hazard.
No data available to indicate product or any components present at greater than 0.1% are
Mutagenicity
mutagenic or genotoxic.
No data available to indicate either product or components present at greater than 0.1% that
Reproductive Toxicity
may cause reproductive toxicity.
No data available to indicate product or any components contained at greater than 0.1% may
Teratogenicity
cause birth defects.
-- ADDITIONAL INFORMATION --
No other health hazards known.
Other
12 Ecological Information
-- ENVIRONMENTAL TOXICITY --
The acute LC50 is > 1000 mg/L based on actual data..
Freshwater Fish Toxicity
Freshwater Invertebrates
The acute EC50 is > 1000 mg/L based on actual data..
Toxicity
Not determined.
Algal Inhibition
Not determined.
Saltwater Fish Toxicity
Saltwater Invertebrates
Not determined.
Toxicity
The acute EC50 is > 1000 ppm based on actual data.
Bacteria Toxicity
Not determined.
Miscellaneous Toxicity
-- ENVIRONMENTAL FATE --
This product will biodegrade moderately based on OECD 302-type test data for similar
Biodegradation
products.
There is no data available to evaluate this material for bioconcentration.
Bioaccumulation
Not determined.
Soil Mobility
13 Disposal Considerations
This material, if discarded, is not a hazardous waste under RCRA Regulation 40 CFR 261.
Waste Disposal
Treatment, storage, transportation, and disposal must be in accordance with applicable
Federal, State/Provincial, and Local regulations.
14 Transport Information
Not regulated.
ICAO/IATA I
Not regulated.
ICAO/IATA II
Not regulated.
IMDG
Not applicable.
IMDG EMS Fire
Not applicable.
IMDG EMS Spill
Not applicable.
IMDG MFAG
Not determined.
MARPOL Annex II
Not determined.
USCG Compatibility
Not regulated.
U.S. DOT Bulk
Not regulated.
U.S. DOT Non-Bulk
Page 4 of 6
GLUCAMTM P-10 HUMECTANT
Not applicable.
DOT NAERG
Not regulated.
TDG Bulk
Not regulated.
TDG Non-Bulk
Not regulated.
Mexico
Not regulated.
Mexico Non-Bulk
85000 liters, 22457 gal.
Bulk Quantity
207.8 liters, 55 gal.
Non-Bulk Quantity
Review classification requirements before shipping materials at elevated temperatures.
15 Regulatory Information
-- Global Chemical Inventories --
All components of this material are on the US TSCA Inventory or are exempt.
USA
None known.
Other TSCA Reg.
All components are in compliance with the EC Seventh amendment Directive 92 /32/EEC.
EU
All components are in compliance with the Chemical Substances Control Law of Japan.
Japan
All components are in compliance with chemical notification requirements in Australia.
Australia
All components are in compliance with chemical notification requirements in New Zealand.
New Zealand
All components are in compliance with the Canadian Environmental Protection Act and are
Canada
present on the Domestic Substances List.
All components are in compliance with the Environmentally Hazardous Substances
Switzerland
Ordinance in Switzerland.
All components are in compliance in Korea.
Korea
All components are in compliance with the Philippines Toxic Substances and Hazardous and
Philippines
Nuclear Wastes Control Act of 1990 (R.A. 6969).
All components of this product are listed on the Inventory of Existing Chemical Substances
China
in China.
-- Other U.S. Federal Regulations --
This product does not contain greater than 1.0% of any chemical substance on the SARA
SARA Ext. Haz. Subst.
Extremely Hazardous Substances list.
This product does not contain greater than 1.0% (greater than 0.1% for carcinogenic
SARA Section 313
substance) of any chemical substances listed under SARA Section 313.
SARA 311 Classifications Acute Hazard No
Chronic Hazard No
Fire Hazard No
Reactivity Hazard No
CERCLA Hazardous
None known.
Substances
Not applicable.
FDA Approval
-- State Regulations --
This product contains the following chemical(s) known to the state of California to cause
Cal. Prop. 65
cancer and/or birth defects based on maximum impurity levels of components: < 1 ppm
Propylene oxide, CAS no. 75-56-9
-- Product Registrations --
Not applicable.
U.S. Fuel Registration
Page 5 of 6
GLUCAMTM P-10 HUMECTANT
This product has not been filed with the USDA to support H2 approvals.
U.S. Dept of Agriculture
NSF Nonfood Compounds
This product has not been filed with the NSF to support H1 or H2 approvals.
Registration
Finnish Registration
Not Registered
Number
Swedish Registration
Not Registered
Number
Norwegian Registration
Not Registered
Number
Danish Registration
Not Registered
Number
Not Registered
Swiss Registration Number
Not Registered
Italian Registration Number
Korean Registration
Not Registered
Number
-- Other / International --
None known.
TDG Regulated Limit.
16 Other Information
US NFPA Codes Health Fire Reactivity Special
0 1 0 N/E
(N/E) - None established
HMIS Codes Health Fire Reactivity
0 1 0
Precautionary Labels
This material has no known health hazards.
Revision Indicators Section: 1 Product type. Changed: 27 October 2008
Section: 8 Respiratory protection. Changed: 30 March 2009
Section: 9 Odor threshold. Changed: 27 October 2008
Section: 9 Percent volatile. Changed: 27 October 2008
Section: 9 Viscosity. Changed: 27 October 2008
As the conditions or methods of use are beyond our control, we do not assume any responsibility and expressly disclaim
any liability for any use of this product. Information contained herein is believed to be true and accurate but all
statements or suggestions are made without warranty, expressed or implied, regarding accuracy of the information, the
hazards connected with the use of the material or the results to be obtained from the use thereof. Compliance with all
applicable federal, state, and local regulations remains the responsibility of the user.
Page 6 of 6
|