PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 01 of 06
Decal & Paint Stripper
80577
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: Decal & Paint Stripper
Item No.: 80577
Part No.: 161DA
Product Type: Aerosol, Paint Remover
2. COMPOSITION, INFORMATION ON INGREDIENTS
Ingredients CAS No. %
METHYLENE CHLORIDE* 75-09-2 10-15
ISOBUTANE 75-28-5 5-15
ISOPROPYL ALCOHOL 67-63-0 5-15
PROPANE 74-98-6 5-15
ETHYL BENZENE* 100-41-4 1-5
ETHANOL, 2-AMINO- 141-43-5 1-5
Fatty acid diethanolamide 68604-35-3 1-5
STODDARD SOLVENT 8052-41-3 1-5
XYLENES* 1330-20-7 1-5
* This component is listed as a SARA Section 313 Toxic Chemical.
Ingredients which have exposure limits
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL)
METHYLENE CHLORIDE 50 ppm TWA 500 ppm TWA None
174 mg/m3 1000ppm ceiling
ISOPROPYL ALCOHOL 400 ppm TWA 400 ppm TWA None
983 mg/m3 980 mg/m3
PROPANE Asphyxiant 1000 ppm None
1800 mg/m3
ETHYL BENZENE 100 ppm 100 ppm None
434 mg/m3 435 mg/m3
ETHANOL, 2-AMINO- 3 ppm 3 ppm None
7.5 mg/m3 8 mg.m3
STODDARD SOLVENT 100 ppm 100 ppm None
525 mg/m3 525 mg/m3
XYLENES 100 ppm TWA 100 ppm TWA None
434 mg/m3 435 mg/m3
Exposure Limits (STEL) ACGIH OSHA
Ingredients (TLV) (PEL)
METHYLENE CHLORIDE None 300ppm 5minutes
in 3 hours
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 02 of 06
Product Name: Decal & Paint Stripper
Item No.: 80577
2. COMPOSITION, INFORMATION ON INGREDIENTS (continued)
ISOPROPYL ALCOHOL 500 ppm 500 ppm
1230 mg/m3 1225 mg/m3
ETHYL BENZENE 125 ppm 125 ppm
543 mg/m3 545 mg/m3
ETHANOL, 2-AMINO- 6 ppm 6 ppm
15 mg/m3 15 mg/m3
XYLENES 150 ppm 150 ppm
651 mg/m3 655 mg/m3
3. HAZARDS IDENTIFICATION
Toxicity: Eye and skin irritant. Moderately toxic by
inhalation or ingestion.
Primary Routes of Entry: Inhalation, ingestion, skin contact
Signs and symptoms
of Exposure: Headache, nausea, dizziness. Narcosis at high
concentrations.
Aqua Ammonia in this product contains vapors and
mists that are extremely corrosive to the nose,
throat and mucous membranes. Bronchitis,
pulmonary edema and chemical pneumonitis may
occur. Irritation, coughing, chest pain and
difficulty in breathing may occur wiht brief
exposure while prolonged exposure may result in
more severe irritation & tissue damage.
Existing Conditions
Aggravated by Exposure: Cardiovascular problems may be aggravated by
overexposure to methylene chloride.
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
METHYLENE CHLORIDE AC3 CNS IRR LIV YES 2B NO
ISOBUTANE CAR CNS LUN NO NO NO
ISOPROPYL ALCOHOL ALG CNS IRR NO N/A NO
PROPANE CAR CNS IRR NO NO NO
ETHYL BENZENE CNS IRR NO NO NO
ETHANOL, 2-AMINO- IRR KID LIV NO NO NO
Fatty acid diethanolamide No Data NO NO NO
STODDARD SOLVENT CNS IRR NO NO NO
XYLENES AC4 CAR CNS IRR KID LIV NO NO NO
-------------------------------------------------------------------------------
Abbreviations
N/A Not Applicable 2B Possibly carcinogenic to humans
AC3 ACGIH animal carcinogen. AC4 ACGIH-Unclassifiable as human carc.
ALG Allergen CAR Cardiac
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 03 of 06
Product Name: Decal & Paint Stripper
Item No.: 80577
3. HAZARDS IDENTIFICATION (continued)
CNS Central nervous system IRR Irritant
KID Kidney LIV Liver
LUN Lung
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Keep individual calm.
Obtain medical attention.
Inhalation: Remove to fresh air. If symptoms persist, obtain
medical attention.
Skin Contact: Wash with soap and water.
Eye Contact: Flush at least 15 minutes with water. Obtain
medical attention.
5. FIRE FIGHTING MEASURES
Flash Point: Below -20癋 (Propellant) Method: Tag Open Cup
Recommended
Extinguishing Agents: Carbon dioxide, dry chemical, water fog
Hazardous Products formed
by Fire or Thermal Decomp Carbon Monoxide, Carbon Dioxide, Hydrogen
Chloride, Phosgene Gas.
Unusual Fire or
Explosion Hazards: Heated cans may burst
Explosive Limits:
(% by volume in air)Lower Not available
(% by volume in air)Upper Not available
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Maintain adequate ventilation. Remove sources of
ignition. Soak up in an inert absorbent. Store in
a closed container disposal.
7. HANDLING AND STORAGE
Safe Storage: Keep away from heat, spark, or open flame.
Store below 120癋.
Keep at room temperature as exposure to direct
sunlight or heat may cause bursting.
(Contact Loctite Customer Service 1-800-243-4874 for shelf Life information)
Handling: Avoid prolonged breathing of vapors. Keep away
from eyes. Avoid prolonged skin contact.
Do not use near sources of ignition.
Do not puncture. Do not spray near fire or open
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 04 of 06
Product Name: Decal & Paint Stripper
Item No.: 80577
7. HANDLING AND STORAGE (continued)
flame
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Rubber or plastic gloves.
Ventilation: Sufficient to maintain vapor concentration below
TLV.
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Clear liquid
Odor: Mild
Boiling Point: Propellant below 0 Degrees F
pH: Does not apply
Solubility in Water: Insoluble
Specific Gravity Not Available
Volatile Organic Compound
(EPA Method 24) 93 %
Vapor Pressure: Not available
Vapor Density: Heavier than air
Evaporation Rate
(Ether = 1) More than 1
10. STABILITY AND REACTIVITY
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: Solvent may react with strong oxidizers and active
metals.
Conditions to Avoid: Not available
Hazardous Decomposition
Products (non-thermal): None
11. TOXICOLOGICAL INFORMATION
See Section 3.
12. ECOLOGICAL INFORMATION
No data available
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 05 of 06
Product Name: Decal & Paint Stripper
Item No.: 80577
13. DISPOSAL CONSIDERATIONS
Recommended methods of
disposal: Incinerate following EPA and local regulations.
Do not incinerate cans still under pressure.
EPA Hazardous Waste
Number D001/F002 - Hazardous waste per 40CFR 261.21 and
261.31/Methylene Chloride
14. TRANSPORTATION INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Consumer Commodity
Hazard Class or
Division: ORM-D
Identification Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Aerosols, flammable, n.o.s. containing
substances in Division 6.1, Packing Group III
Class or Division: Class 2.1 Subsidiary Risk 6.1
UN or ID Number: UN 1950
15. REGULATORY INFORMATION
CA Proposition 65: Warning: This product contains a chemical known to
the State of California to cause cancer.
Dichloromethane
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 3
Fire Hazard: 4
Reactivity Hazard: 1
Specific Hazard: Does not apply
Estimated HMIS(R) Code:
Health Hazard: 3
Flammability Hazard: 4
Reactivity Hazards: 1
Personal Protection: See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Jean B. Tobbe
Title: Environmental Health & Safety Specialist
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 06 of 06
Product Name: Decal & Paint Stripper
Item No.: 80577
16. OTHER INFORMATION (continued)
(24hr.) Phone: (860) 571-5100
Revision Date: April 15, 1997 Revision: 0004
|