MATERIAL SAFETY DATA SHEET
Page 1 of 6
303-1002
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/06
CHEMICAL RESPONSE CARD:
1. PRODUCT IDENTIFICATION
303 SONIC BLAST 鈩?
1.1 Product Name:
RESPONSE
TEAM PPE:
See ingredients listed in section 2
1.2 Chemical Name:
None reported by the manufacturer
1.3 Synonyms:
WHMIS:
303 SONIC BLAST
1.4 Trade Names:
1
Repairs/Restores HEALTH:
1.5 Product Use:
0
303 Products, Inc. FLAMMABILITY:
1.6 Manufacturer's Name:
REACTIVITY: 0
10801 Starwood Drive, Palo Cedro, CA 96073
1.7 Manufacturer鈥檚 Address:
PERSONAL PROTECTION: B
+1 (530) 549-5617
1.8 Business Phone:
CHEMTREC +1 (800) 424-9300 / +1 (703) 527-3887
1.9 Emergency Phone:
2. IDENTIFICATION OF RISKS
This product is not classified as a hazardous substance or as dangerous goods according
2.1 Hazard Identification:
to the classification criteria of NOHSC and the ADG Code (Australia). In the event of an
exposure or medical inquiry involving this product, please contact a physician or local
poison control center, who may seek advice from CHEMTREC or the U.S. manufacturer,
and show them this Material Safety Data Sheet.
INHALATION: NO SKIN & EYES: YES INGESTION: YES
2.2 Routes of Entry:
EYES: Possible irritation and burning sensation.
2.3 Effects of Exposure:
SKIN: Possible irritation and dermatitis (rash).
INGESTION: Possible gastrointestinal irritation, nausea, vomiting or diarrhea.
INHALATION: No adverse health effects expected.
EYES: Irritation and burning sensation.
2.4 Symptoms of Exposure:
SKIN: Possible irritation and dermatitis (rash), characterized by red, dry, itching skin.
INGESTION: Gastrointestinal discomfort, nausea, vomiting, and headache.
INHALATION: No adverse health effects expected.
EYES: Irritation.
2.5 Acute Health Effects:
SKIN: Possible irritation and dermatitis (rash).
INGESTION: Possible gastrointestinal irritation, nausea, vomiting or diarrhea.
INHALATION: No adverse health effects expected.
None known.
2.6 Chronic Health Effects:
None reported by the manufacturer.
2.7 Target Organs:
None reported by the manufacturer.
2.8 Toxicological Properties:
3. COMPOSITION & INGREDIENTS
EXPOSURE LIMITS IN AIR (mg/m3)
COMPOSITION CAS No. RTECs No. EINECS No. % ACGIH - ppm OSHA - ppm OTHERS
TLV STEL PEL STEL IDLH
Trade Secret NA NA NA NA NA NA NA NA NA
4. FIRST AID
EYES: Flush eyes thoroughly with copious amounts of water for at least 20 minutes, holding
4.1 First Aid:
eyelids open to ensure complete flushing. If irritation persists, contact a physician.
SKIN: Wash affected areas with soap and water. If irritation persists, contact a physician.
Launder clothing before reuse.
INGESTION: If vomiting occurs spontaneously, keep victim鈥檚 head lowered (forward) to
reduce the risk of aspiration.
INHALATION: Remove victim to fresh air at once.
4.2 Medical Conditions
None known.
Aggravated by
Exposure:
MATERIAL SAFETY DATA SHEET
Page 2 of 6
303-1002
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/06
5. FIRE & EXPLOSION HAZARDS
Not flammable.
5.1 Flashpoint & Method:
5.2 Autoignition
Not Applicable
Temperature:
Not Applicable Not Applicable
5.3 Flammability Limits: Lower Explosive Limit (LEL): Upper Explosive Limit (UEL):
5.4 Fire & Explosion
None known.
Hazards:
CO2, sand, dry chemical or other approved fire extinguishing media,
5.5 Extinguishing Methods:
foam, and indirect water spray or fog.
Poses no unusual fire or explosion hazard. Keep containers cool until
5.6 Firefighting Procedures:
well after the fire is out. Prevent runoff from fire control or dilution from
entering sewers, drains, drinking water supply, or any natural waterway.
Firefighters should wear full-face, self-contained breathing apparatus
(MSHA/NIOSH approved or the equivalent) and impervious clothing.
6. SPILLS & LEAKS
Secure spill area and maximize ventilation. Stop spill or leak at source if safely possible.
6.1 Spills:
Deny entry to all unprotected individuals. Individuals involved in the cleanup must wear
appropriate personal protective equipment. Recover free liquid or cover with inert
absorbent material and place into appropriate container(s) for disposal. If necessary,
dike well ahead of the spill to prevent runoff into drains, sewers or any natural waterway
or drinking supply.
7. STORAGE & HANDLING
Use normal hygiene practices. Avoid breathing vapors. Avoid direct skin contact. Wash
7.1 Work & Hygiene
Practices:
hands thoroughly after using this product and before eating, drinking, or smoking.
Use and store in a cool, dry, well-ventilated area. Keep away from excessive heat, open
7.2 Storage & Handling:
flames, sparks, and other possible sources of ignition. Do not store in unmarked
containers or storage devices.
Readily available emergency fire, first aid, and spill response equipment and/or measures
7.3 Special Precautions:
are highly recommended.
8. EXPOSURE CONTROL & PERSONAL PROTECTION
General mechanical ventilation is sufficient for use with this product. Local exhaust is
8.1 Ventilation &
Engineering Controls:
recommended in enclosed or confined spaces.
A respiratory protection program that meets ANSI Z88.2 requirements must be followed
8.2 Respiratory Protection:
whenever workplace conditions warrant a respirators use.
Safety glasses with side shields should be used with this product. If splashing is
8.3 Eye Protection:
anticipated, splash goggles and a faceshield are recommended.
Where contact is likely, impervious gloves are recommended. Do not wear rings,
8.4 Hand Protection:
watches, or jewelry that could entrap the material against the skin.
None required under normal conditions.
8.5 Body Protection:
MATERIAL SAFETY DATA SHEET
Page 3 of 6
303-1002
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/2006
9. PHYSICAL & CHEMICAL PROPERTIES
1.01 - 1.02
9.1 Density:
鈮? 100 掳C
9.2 Boiling Point:
鈮? 1.0 掳C
9.3 Melting Point:
鈮? 1.0 (water = 1)
9.4 Evaporation Rate:
17 mm Hg
9.5 Vapor Pressure @ 20掳C:
Not Available
9.6 Molecular Weight:
Milky, white liquid
9.7 Appearance & Colour:
Mild odor
9.8 Odour Threshold:
Fully soluble
9.9 Solubility:
9.79
9.10 pH:
Not Available
9.11 Viscosity:
9.12 Coefficient Oil/Water
Not Available
Distribution:
Vapor density 3.2 (Air =1.0)
9.13 Additional Information:
10. STABILITY & REACTIVITY
Stable under normal conditions.
10.1 Stability:
10.2 Decomposition
Heat and carbon dioxide.
Products:
Will not occur.
10.3 Polymerization:
Close proximity to incompatible substances (e.g., alkalies, strong oxidizers).
10.4 Conditions to Avoid:
10.5 Incompatible
None reported by the manufacturer.
Substances:
11. TOXICOLOGICAL INFORMATION
No general or specific toxicity data has been reported by the manufacturer other than
11.1 Toxicity Data:
the information presented in Section 2. However, good personal hygiene practices, such
as washing any skin contact areas and removing contaminated clothing, are
recommended.
See section 2.5
11.2 Acute Toxicity:
See section 2.6
11.3 Chronic Toxicity:
No
11.4 Suspected Carcinogen:
This product is not expected to cause reproductive harm in humans.
11.5 Reproductive Toxicity:
This product is not expected to cause mutagenic effects in humans.
Mutagenicity:
This product is not expected to cause embryotoxic effects in humans.
Embryotoxicity:
This product is not expected to cause teratogenic effects in humans.
Teratogenicity:
This product is not expected to cause reproductive harm in humans.
Reproductive Toxicity:
Not Available
11.6 Irritancy of Product:
11.7 Biological Exposure
Not Available
Indices:
11.8 Medical
Treat symptomatically.
Recommendations:
12. ECOLOGICAL INFORMATION
The manufacturer has not reported detailed studies on the environmental fate of the
12.1 Environmental Stability:
material. However, prudent practice would dictate the material not be allowed to enter
the environment.
12.2 Effect on Plants &
The manufacturer has not reported any plant and animal effects.
Animals:
The manufacturer has not reported any aquatic life effects.
12.3 Effect on Aquatic Life:
MATERIAL SAFETY DATA SHEET
Page 4 of 6
303-1002
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/2006
13. DISPOSAL CONSIDERATIONS
Dispose of in accordance with regional, federal, state & provincial hazardous waste laws.
13.1 Waste Disposal:
Refer to manufacturer/supplier for information on recovery/recycling. If the material is
13.2 Special Considerations:
unsuitable for recycling or reclamation, enclosed-controlled incineration is
recommended unless otherwise prohibited by local ordinance or other statute.
14. TRANSPORTATION INFORMATION
NOT REGULATED
14.1 49 CFR (GND):
NOT REGULATED
14.2 IATA (AIR):
NOT REGULATED
14.3 IMDG (OCN):
NOT REGULATED
14.4 TDGR (Canada GND):
NOT REGULATED
14.5 ADR/RID (EU):
NOT REGULATED
14.6 MEXICO (SCT):
15. REGULATORY INFORMATION
15.1 SARA Reporting Requirements:
This product does not contain any substances subject to SARA Title III reporting requirements.
15.2 SARA Threshold Planning Quantity:
Not applicable
15.3 TSCA Inventory Status:
All components of this product are listed in the TSCA Inventory or are exempt.
15.4 CERCLA Reportable Quantity (RQ):
Not Applicable
15.5 Other Federal Requirements:
Not Applicable
15.6 Other Regulations
This product has been classified according to the hazard criteria of the CPR and
the MSDS contains all of the information required by the CPR. The components of
this product are listed on the DSL/NDSL. None of the components of this product
are listed on the Priorities Substances List.
15.7 State Regulatory Information:
Ingredients in this mixture are not found on any of the following state criteria lists:
California OSHA Hazardous Substances List, California Proposition 65, Delaware Air Quality Management
List, Florida Toxic Substances List, Massachusetts Hazardous Substances List, Michigan Critical Substances
List, Minnesota Hazardous Substances List, New Jersey Right to Know Hazardous Substances List,
Pennsylvania Hazardous Substances List, Wisconsin Hazardous Substances List.
15.8 67/548/EEC (European Union) Requirements:
The primary components of this product are not listed in Annex I of EU Directive
67/548/EEC. Safety Phrases (S): 2-3/9-20/21-45-59 鈥? Keep out of the reach of
children. Keep in a cool, well ventilated place. When using, do not eat, drink or
smoke. In case of accident or if you feel unwell, seek medical advice immediately
(show the label where possible). Refer to manufacturer/supplier for information on
recovery/ recycling.
MATERIAL SAFETY DATA SHEET
Page 5 of 6
303-1001
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/06
16. OTHER INFORMATION
Sonic Blast can repair most mistracking and skipping caused by minor surface
16.1 Other Information:
scratches. Just Spray on, Wipe Off, a Quick Polish with a soft cloth - that's
all you need to do. Unlike any other CD Repair product on the market.
Please see last page of this Material Safety Data Sheet.
16.2 Terms & Definitions:
This Material Safety Data Sheet complies with U.S. OSHA鈥檚 Hazard Communication
16.3 Disclaimer:
Standard, 29 CFR 搂1910.1200 and Health Canada's Workplace Hazardous Materials
Information System (WHMIS. To the best of ShipMate's or 303 Products' knowledge, the
information contained herein is reliable and accurate as of this date; however, accuracy,
suitability or completeness are not guaranteed and no warranties of any type, either
expressed or implied, are provided. The information contained herein relates only to the
specific product. For additional information regarding use, storage and handling or
disposal, contact the manufacturer.
16.4 Prepared for:
303 Products, Inc.
10801 Starwood Drive
Palo Cedro, CA 96073-0966
Phone: +1 (530) 549-5617
Web: http://www.303products.com/
16.5 Prepared by:
ShipMate, Inc.
18436 Hawthorne Blvd, Suite 201
Torrance, CA 90504
Phone: +1 (310) 370-3600
Fax: +1 (310) 370-5700
E-mail: shipmate@shipmate.com
Web: http://www.shipmate.com/
MATERIAL SAFETY DATA SHEET
Page 6 of 6
303-1002
Prepared according to the WHMIS, ANSI, NOHSC, ACC, OSHA & 2001/58/EC standards. Revision 1.1 11/01/2006
DEFINITION OF TERMS
A large number of abbreviations and acronyms appear on a MSDS. Some of these that are commonly used include the following:
GENERAL INFORMATION: NATIONAL FIRE PROTECTION ASSOCIATION: NFPA
CAS No. Chemical Abstract Service Number FLAMMABILITY LIMITS IN AIR:
EXPOSURE LIMITS IN AIR: Autoignition Minimum temperature required to initiate combustion
Temperature in air with no other source of ignition
ACGIH American Conference on Governmental Industrial Hygienists
LEL Lower Explosive Limit - lowest percent of vapor in air,
TLV Threshold Limit Value by volume, that will explode or ignite in the presence
OSHA U.S. Occupational Safety and Health Administration of an ignition source
PEL Permissible Exposure Limit UEL Upper Explosive Limit - highest percent of vapor in air,
IDLH Immediately Dangerous to Life and Health by volume, that will explode or ignite in the presence
of an ignition source
FIRST AID MEASURES:
FLAMMABILITY
CPR Cardiopulmonary resuscitation - method in which a person REACTIVITY
whose heart has stopped receives manual chest
compressions and breathing to circulate blood and provide
oxygen to the body.
HMIS庐
HAZARDOUS MATERIALS IDENTIFICATION
SYSTEM: HMIS
HEALTH
HEALTH, FLAMMABILITY & REACTIVITY RATINGS:
SPECIAL
HEALTH
FLAMMABILITY PRECAUTIONS
0 Minimal Hazard
1 Slight Hazard
REACTIVITY
2 Moderate Hazard HAZARD RATINGS:
3 Severe Hazard PERSONAL PROTECTION
4 Extreme Hazard 0 Minimal Hazard
NCCHL44T 漏 NPCA Printed by Labelmaster, A, American Labelmark Co., Chicago, IL 60646 (800) 621-5808
1 Slight Hazard
PERSONAL PROTECTION RATINGS:
2 Moderate Hazard
3 Severe Hazard
A G 4 Extreme Hazard
ACD Acidic
B H
ALK Alkaline
COR Corrosive
C I W Use No Water
OX Oxidizer
D J
TOXICOLOGICAL INFORMATION:
E K LD50 Lethal Dose (solids & liquids) which kills 50% of the
exposed animals s
Consult your supervisor or S.O.P. for
F X LC50 Lethal concentration (gases) which kills 50% of the
special handling directions.
exposed animal
ppm Concentration expressed in parts of material per
million parts
TDlo Lowest dose to cause a symptom
Face Shield &
TCLo Lowest concentration to cause a symptom
Safety Glasses Splash Goggles Gloves
Eye Protection
TDlo, LDlo, & LDo Lowest dose (or concentration) to cause lethal or
or toxic effects
TC, TCo, LClo, & LCo
Boots Dust Respirator
Synthetic Apron Full Suit IARC International Agency for Research on Cancer
NTP National Toxicology Program
RTECS Registry of Toxic Effects of Chemical Substances
Full Face
Dust & Vapor Airline Hood/Mask
BCF Bioconcentration Factor
Vapor Respirator Respirator
Respirator or SCBA
TLm Median threshold limit
log KOW or log KOC Coefficient of Oil/Water Distribution
Note: the dotted circle indicates that this respiratory protective
equipment is required for high concentrations or for large
volume spills or releases of product. REGULATORY INFORMATION:
WHIMS Canadian Workplace Hazardous Material Information
OTHER STANDARD ABBREVIATIONS:
System
NA Not Available DOT U.S. Department of Transportation
NR No Results TC Transport Canada
NE Not Established EPA U.S. Environmental Protection Agency
ND Not Determined DSL Canadian Domestic Substance List
ML Maximum Limit NDSL Canadian Non-Domestic Substance List
SCBA Self-Contained Breathing Apparatus TSCA U.S. Toxic Substance Control Act
|