Search    ENTER KEYWORD
MSDS Material Safety Data Sheet
CAS

8052-42-4
8052-41-3

File Name: 8052-42-4.asp

 SECTION 1 鈥? PRODUCT IDENTIFICATION

PRODUCT NAME: ASPHALTUM BLACK PAINT
CHEMICAL FAMILY: ASPHALT BASED ROOF COATING
PRODUCT NUMBER: 0805, 0801
EMERGENCY TELEPHONE: CHEMTREC (800) 424-9300
DATE PREPARED: 02/28/02
PREPARED BY: ACT-GS


SECTION 2 鈥? HAZARDOUS INGREDIENTS

CHEMICAL NAME CAS NO. OSHA PEL ACGIH TLV WT%

5 mg/m3 5 mg/m3
PETROLEUM ASPHALT 8052-42-4 <55
respirable fraction fumes
MINERAL SPIRITS 8052-41-3 500 ppm 100 ppm <65


CONTAINS NO CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III SECTION 313

SECTION 3 鈥? PHYSICAL DATA

BOILING POINT (0F): 300 initial MELTING POINT: N.A.
SPECIFIC GRAVITY: 0.90 EVAPORATION RATE (BUAC=1): 0.1
2.1 mm Hg @ 200C
VAPOR PRESSURE: VAPOR DENSITY: Heavier than air
% VOLATILE BY VOL 57 SOLUBILITY, WATER: Insoluble
pH N.A.
APPEARANCE/ODOR: Black liquid, petroleum odor

SECTION 4 鈥? FIRE AND EXPLOSION DATA

FLASH POINT: 105 0F TCC FLAMMABILITY LIMITS: LEL 0.9 UEL 6.7
AUTOIGNITION TEMPERATURE: 540 OF
EXTINGUISHING MEDIA: Foam, Carbon Dioxide, Dry Chemical, Water Fog.

SPECIAL FIREFIGHTING INSTRUCTIONS: Material will float on water and can be reignited. Use water to cool
containers to prevent bursting. Wear full firefighting gear including self-contained breathing apparatus.

UNUSUAL FIRE AND EXPLOSION HAZARDS: Intense heat can cause pressure build-up in containers and can
result in bursting. Vapors are heavier than air and can travel along the ground to remote sources of ignition. Empty
containers may contain residual vapors or liquid that could be ignited by heat, flame, sparks or other ignition sources.




PAGE 1
ASPHALTUM BLACK PAINT
SECTION 5 - REACTIVITY DATA

STABILITY: Stable. CONDITIONS TO AVOID: Heat, flame, sparks, or other sources of ignition.
INCOMPATABILITY: Avoid strong oxidizers.

HAZARDOUS DECOMPOSITION BYPRODUCTS: Carbon Dioxide, Carbon Monoxide, Oxides of Nitrogen, Hydrogen
Sulfides, and Smoke.

HAZARDOUS POLYMERIZATION: Will not occur.

SECTION 6 鈥? HEALTH HAZARD DATA

ROUTES OF EXPOSURE: Inhalation, Skin Contact, and Eye Contact.

HEALTH HAZARDS (ACUTE): Vapors may be irritating to nose, throat, and respiratory tract. High concentrations
may cause headaches, dizziness, nausea, drowsiness, anesthesia, and unconsciousness and can result in death.
Vapors and liquid can cause eye irritation, redness, tearing and blurred vision. Ingestion can cause irritation of mouth,
throat, and gastrointestinal tract. May cause nausea and vomiting. Aspiration of petroleum distillates into the lungs
can cause severe chemical pneumonitis, which can be fatal.

HEALTH HAZARDS (CHRONIC): Prolonged or repeated contact can cause skin dryness, irritation and dermatitis.

MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: Central nervous system diseases, skin disorders, eye
disorders or chronic respiratory diseases may be worsened by exposure.

Ingredients are not considered carcinogenic by OSHA or NTP. IARC monographs list refined bitumens as possibly
carcinogenic to humans based upon animal studies. IARC regards it prudent to treat a material for which there is
sufficient evidence of carcinogenicity in animals as if it is possibly carcinogenic in humans.

EMERGENCY AND FIRST AID PROCEDURES: IF INHALED: Remove person to fresh air. If breathing is difficult,
administer oxygen. If breathing has stopped, administer artificial respiration. Seek emergency medical attention.
SKIN CONTACT: Remove material using waterless hand cleaner. Wash skin with mild soap and water. If irritation
persists, seek medical attention. Remove and launder contaminated clothing before reuse. EYE CONTACT: Flush
eyes with cool running water for at least 15 minutes while holding eyelids open. Seek immediate medical attention.
IF INGESTED: DO NOT INDUCE VOMITING. Call a doctor or Poison Control Center immediately. Aspiration can
cause chemical pneumonitis that is potentially fatal.

SECTION 7 鈥? PRECAUTIONS FOR SAFE HANDLING AND USE

STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED: Eliminate sources of ignition. Ventilate area.
Wear appropriate safety equipment. Restrict access to area of spill. Contain spill using sand or other inert material.
Recover free material to a secure container. Use inert absorbent to pick up residue. Wash area with soap and water.

WASTE DISPOSAL: Dispose of material in accordance with applicable Federal, State and local regulations. This
material is a RCRA regulated hazardous waste.

PRECAUTIONS FOR STORAGE AND HANDLING: Do not store containers near heat, sparks, open flames or other
sources of ignition. Keep container closed when not in use. Wear appropriate personal protective equipment when
handling product. Grounding is required for pumping or spraying of material. Wash hands after using product and
before eating or smoking.




PAGE 2
ASPHALTUM BLACK PAINT
SECTION 8 鈥? CONTROL MEASURES

RESPIRATORY PROTECTION: FOR OUTDOOR USE ONLY. Avoid breathing vapors or spray mist. If vapors
exceed TLV, use a NIOSH/MSHA approved respirator equipped with an Organic Vapor cartridge or self-contained
breathing apparatus.

EYE PROTECTION: Wear safety goggles or full-face shield.

PROTECTIVE GLOVES: Impervious plastic or rubber gloves.

PROTECTIVE CLOTHING: Wear long pants and long sleeved shirt. Remove contaminated clothing and launder
before reuse.

OTHER PROTECTIVE MEASURES: Use waterless hand cleaner to remove material from skin. Avoid breathing of
vapors and spray mist. Equipment must be grounded for pumping or spraying. Use explosion-proof equipment. Eye
wash stations and safety showers should be available.


SECTION 9 鈥? OTHER INFORMATION

NFPA HMIS
ABBREVIATIONS NA=NOT APPLICABLE HEALTH 2 2
ND=NOT DETERMINED FLAMMABILITY 2 2
NE=NOT ESTABLISHED REACTIVITY 0 0
PERSONAL PROTECTION B


VOC Content: 3.70 lbs/gal or 443 g/l. Complies with California, Massachusetts and Federal regulations in effect on
date of issuance.


California Proposition 65: WARNING: This product contains a chemical known to the State of California to cause
cancer.


DOT Proper Shipping Name: Combustible Material, NOS, 3, NA 1993, PG III
Contains Petroleum Distillates


The information contained herein is believed to be accurate and complete to the best of ALCM鈥檚 knowledge at the time of issuance. ALCM does
not warranty the accuracy of this data and shall not be liable for any loss or damage arising from the use thereof.




PAGE 3
ASPHALTUM BLACK PAINT

ALL Chemical Analysis PAGES IN THIS GROUP
NAMECAS
13463-67-7.asp 13463-67-7 60-35-5
1344-28-1.asp 1344-28-1
14808-60-7.asp 14808-60-7 471-34-1
13463-67-7.asp 13463-67-7 60-35-5
7782-42-5.asp 7782-42-5 14808-60-7 64-17-5 108-39-4 68476-85-7 110-54-3 106-44-5
aitkenfreeman_com_zincprimer.asp N/A
872-50-4.asp 872-50-4 121-44-8
7440-02-0.asp 7440-02-0 1313-99-1 872-50-4 98-00-0 108-01-0
8052-42-4.asp 8052-42-4 8052-41-3
alconox_com_msds_alcotabs_english_osha.asp N/A
77-92-9.asp 77-92-9
alexlind_com_au_Estapol7008A15232msds.asp N/A
alfaklebstoffe_com_D_179_MSDS_DE.asp N/A
alfredo_octavio_net_soft_drink_formula.asp N/A
7439-89-6.asp 7439-89-6 7439-96-5 7447-47-3 7440-02-0 7440-44-0 7439-98-7 7440-50-8 7440-21-3 7723-14-0 1314-62-1 7429-90-5 7440-25-7 13463-67-3
555-31-7.asp 555-31-7
7439-89-6.asp 7439-89-6 7439-90-5 7440-44-0 7440-47-3 7440-48-4 7440-50-8 7439-92-1 7439-96-5 7439-98-7
16079-88-2.asp 16079-88-2 497-19-8
010043-52-4.asp 010043-52-4 007647-14-5 007447-40-7 007732-18-5
70693-62-8.asp 70693-62-8 10058-23-8 7646-93-7 7778-80-5 7727-21-1 546-93-0
497-19-8.asp 497-19-8
8052-41-3.asp 8052-41-3 74-98-6 75-28-5
64-17-5.asp 64-17-5
67-68-5.asp 67-68-5
1344-28-1.asp 1344-28-1 1305-78-8 12068-85-8 78-79-5 7704-34-9 1309-38-2 15096-52-3
109-99-9.asp 109-99-9 28064-14-4 78-93-3
7732-18-5.asp 7732-18-5 64-02-8 26447-10-9 27323-41-7 34398-01-1
70693-62-8.asp 70693-62-8 5329-14-6 25155-30-0
8003-34-7.asp 8003-34-7 51-03-6
7732-18-5.asp 7732-18-5 108-05-4 9004-62-0
7732-18-2.asp 7732-18-2 1119-40-0 627-93-0 25498-49-1 67-64-1 107-98-2 111-76-2 628-63-7 106-65-0
almit_com_ms_tipcleaner.asp N/A
1344-28-1.asp 1344-28-1 18282-10-5 1308-38-9 7440-44-0 9010-98-4 9003-35-4
1344-28-1.asp 1344-28-1 1306-38-3 1308-38-9 15096-52-3 7439-89-6 7440-02-0 7440-44-0 9003-35-4 25036-53-7
116565-74-3.asp 116565-74-3
alsacorp_com_MSDS_ChromeFX_AB.asp N/A
71-23-8.asp 71-23-8 7647-01-0 7772-99-8 7732-18-5
10-66-6.asp 10-66-6 10-37-5 53-65-6
7439-92-1.asp 7439-92-1
811-97-2.asp 811-97-2
26628-22-8.asp 26628-22-8
altrotransflor_com_altrosf_msds.asp N/A
altrumonline_com_NLL.asp N/A
142-82-5.asp 142-82-5 69006-04-6
7732-18-5.asp 7732-18-5 65997-18-4 1332-58-7 14808-60-7 9004-32-4
amalie_com_HPO.asp N/A
68649-42-3.asp 68649-42-3
41575-94-4.asp 41575-94-4 69-65-8
33069-62-4.asp 33069-62-4 61791-12-6 64-17-5
75-09-2.asp 75-09-2 64-18-6 108-95-2


HBCChem,Inc

Chemical Information Net chemcas.orgCopyright Reserved

Trading Lead

Leputech HPLC Laboratory