MATERIAL SAFETY DATA SHEET
Osmocote庐 Plus
Controlled Release Fertilizer
15-9-12
90330-6
Scotts-Sierra Horticultural Products Co. In Case of Emergency call:
The Scotts Company 1-937-644-0011 (USA)
14111 Scottslawn Road For non-Emergency calls:
Marysville, Ohio 43041 1-937-644-0011 (USA)
I. MATERIAL IDENTIFICATION
NFPA Hazard Ratings 0 Least
Product Name: Osmocote庐 Plus Controlled Release Fertilizer
Health 2 1 Slight
Analysis: 15-9-12 2 Moderate
Flammability 0 3 High
Stock Number: 90330-6 Reactivity 1 4 Severe
II. HAZARDOUS INGREDIENTS
OSHA ACGIH
MATERIAL CAS # PEL TLV
Ammonium Nitrate 6484-52-2 None None
Ammonium Phosphates 7783-28-0/7722-76-1 None None
Calcium Phosphates 7758-23-8/7757-93-9/7758-87-4 None None
Calcium Fluoride 7789-75-5 2.5 mg(F)/m3 2.5 mg(F)/m3
Potassium Nitrate 7757-79-1 None None
Magnesium Sulfate 10034-99-8/7487-88-9 None None
Boric Acid 10043-35-3 None None
Copper Sulfate 7758-98-7 None 1.0mg(Cu)/m3
Ferrous Sulfate 7782-63-0 1mg(Fe)/m3 1mg(Fe)/m3
Iron EDTA 15708-41-5 None None
Manganese Sulfate 7785-87-7 5mg(Mn)/m3 5mg(Mn)/m3
Sodium Molybdate 7631-95-0 5mg(Mo)/m3 5mg(Mo)/m3
Zinc Sulfate 7733-02-0 None None
Zinc Oxide 1314-13-2 5mg/m3 10mg/m3
This product consists of prills coated with a resin made from a vegetable oil (linseed oil or soybean oil) reacted
with a cyclic diene.
All exposure limits are for airborne 8-hour time-weighted averages and apply only to occupational exposures.
Product coating is expected to minimize airborne exposures.
The ACGIH Threshold Limit Values for nuisance (inert) dusts containing <1% crystalline silica and no asbestos
are: 10 mg/m3 total, 5 mg/m3 respirable.
III. FIRST AID PROCEDURES
If in eyes, flush with water for 15 minutes holding eyelids open. Get medical attention if irritation persists.
Eyes:
Never give anything by mouth to an unconscious or convulsing person. Have conscious person drink
Ingestion:
1 to 2 glasses of water, then induce repeated vomiting until vomit is clear. Call physician.
Wash with plenty of soap and water.
Skin:
Inhalation: Remove to fresh air. Treat symptomatically.
Product Name: OSMOCOTE庐 PLUS CONTROLLED RELEASE FERTILIZER (St. # 90330-6) Page 2 of 3
IV. HEALTH HAZARD INFORMATION
Summary of Risks
Ammonium nitrate is an allergen. Prolonged or repeated direct contact with fertilizer may irritate eyes and skin.
Inhalation of dust may irritate nose, throat, and lungs. Prolonged exposure may cause weakness, depression,
headache, mental impairment, anemia, methemoglobinemia, and kidney injury. Ingestion of product can cause severe
gastrointestinal irritation, muscular weakness, and blue-tinged skin (cyanosis). Infants and children are especially at
risk for cyanosis. Ingestion of large amounts may result in death.
Inhalation of heavy concentrations of manganese-containing dusts over very prolonged periods of exposure (usually
one to three years) has been reported to cause damage to the central nervous system.
Medical conditions which may
be aggravated by contact: Skin abrasions and sores. Inhalation of dust may aggravate asthma.
Target Organs: Skin, eyes, respiratory tract, gastrointestinal tract, and central nervous system.
Primary Entry Route(s): Ingestion, inhalation.
Chronic Effect(s): See Summary:
Ingredients Listed as a Carcinogen
IARC Monographs: No
NTP: No
OSHA: No
V. PERSONAL PROTECTION AND PRECAUTIONS
Warning Properties of Uncoated Fertilizer: Irritation of eyes, nose, or mouth.
None required for routine use as fertilizer. High airborne dust levels or mists of product dissolved
Goggles:
in liquid may be irritating; use chemical goggles.
None required for normal use. If prolonged or repeated use irritates skin, use neoprene or
Gloves:
PVC gloves.
Respirator: If airborne dust levels are high or product does not remain intact, use a combination of engineering
controls (e.g. ventilation) and personal protection (e.g. NIOSH/MSHA approved respirator for
dusts, mists, and fumes) to reduce exposures to acceptable levels.
Ventilation and personal protection are recommended whenever dust levels are high or
Ventilation:
product does not remain intact.
Workplace Considerations
Ventilation and personal protection are recommended whenever dust levels are high or
Ventilation:
product does not remain intact.
Safety Stations: Running water should be available in case material gets in eyes.
Ingredients with occupational exposure limits comprise a small percentage of the total
Other:
product. For this reason, it is not expected that these limits will be exceeded unless the
nuisance dust standards are exceeded.
Product Name: OSMOCOTE庐 PLUS CONTROLLED RELEASE FERTILIZER (St. # 90330-6) Page 3 of 3
VI. PHYSICAL HAZARD INFORMATION
Flammable Limits (% in Air): Not Applicable Color: Mixed light/dark tan
Extinguishing Media: Water Odor: None
Auto Ignition Temperature: Not Applicable Melting Point: Decomposes on heating
Flash Point (method): Decomposes on heating Boiling Point: Decomposes on heating
Solubility in H2 0 80-85%
Specific Gravity: (H2 0 = 1) 1.1
Reactivity Vapor Pressure: Not Known
Stability: Stable Evaporation Rate: Not Applicable
Hazardous Polymerization: Will Not Occur
Extreme heat. Contact with strong alkalies, oxidizers, and reducing agents. Contact
Conditions to Avoid:
with fuels and other organic or combustible materials. Active metals such as
aluminum and magnesium.
In a fire, may produce oxides of nitrogen, phosphorus, potassium, and sulfur, as well
Hazardous Decomposition
as ammonia.
Products:
Strong oxidizing (permanganate, dichromate, nitrate, chlorine) and reducing agents,
Chemical Incompatibilities:
sodium nitrite and many chlorine compounds (including household bleach and other
cleaning products). Active metals such as aluminum and magnesium.
Decomposes on heating to emit toxic oxides of nitrogen, phosphorus, potassium, and
Unusual Fire, Explosion
sulfur, as well as ammonia. High airborne dust concentrations have the potential for
and Reactivity Hazards:
explosion.
Evacuate area. Flood with water to cool containers. Wear self-contained breathing
In Case of Fire:
apparatus to fight large fires.
VII. REGULATORY INFORMATION
DOT Classification: Not DOT regulated.
VIII. STORAGE AND SPECIAL PRECAUTIONS
Precautions to be taken in handling and storage
Store in a cool, dry area away from incompatible materials and heat sources. Store away from feed and foodstuffs, as
well as household cleaning products. Wash hands with soap and water after handling product. Keep out of reach of
children.
In case of spills
Avoid dusting or misting conditions during cleanup. If material is uncontaminated, collect and reuse as
recommended for product. If contaminated, put in appropriate container and dispose. Keep spills away from
drinking water supplies. After cleaning up spill, flush area with water.
Waste Management/Disposal
Apply as fertilizer to field. If product is contaminated, dispose of in an approved landfill disposal facility, in
accordance with applicable federal, state, and local regulations.
Date revised: 3/6/2000
Date Issued: 3/26/1998
The information contained herein is, to the best of Scott's knowledge and belief, accurate and reliable as of the date of preparation of this document.
However, no warranty or guarantee, express or implied, is made as to the accuracy or reliability, and Scotts shall not be liable for any loss or damage arising
out of the use thereof. No authorization is given or implied to use any patented invention without a license. In addition, Scotts shall not be liable for any
damage or injury resulting from abnormal use, from any failure to adhere to recommended practices or from any hazards inherent in the nature of the product.
|