MSDS # 3800
Page 1 of 3
MATERIAL SAFETY DATA SHEET
December 01, 2001
_____________________________________________________________________________________
SECTION I
MANUFACTURER鈥橲 NAME: Tibbetts Newport Corp.
STREET ADDRESS: 2337 S. Birch Street, Santa Ana, CA 92707
EMERGENCY TELEPHONE #: 714/546-6661
100% Acrylic Traffic Paint
PRODUCT CLASS:
FAST LANE
NAME:
3800
PRODUCT NUMBER:
COLOR: White & Colors
------NON-MERCURIAL-----
SECTION II - HAZARDOUS INGREDIENTS
- NONE LISTED -
This product鈥檚 ingredients DOES NOT contain any suspected cancer agent found on the following
lists/ federal OSHA / NTP / IARC.
SECTIO N III - PHYSICAL CHARACTERISTICS
BOILING POINT: 212 degrees F COATING V.O.C.: 65.35Gms/Liter
VAPOR DENSITY: Heavier than Air MATERIAL V.O.C.: 43.50Gms/Liter
EVAPORATION RATE: Slower than Ether
WEIGHT PER GALLON: 14.00
SOLUBILITY IN WATER: Yes
APPEARANCE & ODOR: Viscous liquid and mild odor
SECTION IV - FIRE & EXPLOSION HAZARD DATA
DOT Category: Non-
Combustible (Aqueous System)
FLASH POINT: N/A
FLAMMABLE LIMITS IN AIR BY VOLUME: 1. Lower explosion level - N/A
2. Upper explosion level N/A
EXTINGUISHING MEDIA: Water Fog, CO2, Dry Chemical
USUAL FIRE & EXPLOSION HAZARD: Closed containers exposed to extreme heat may
explode due to steam pressure buildup.
SPECIAL FIRE FIGHTING PROCEDURES: Follow recommended procedures in handling fire
areas. Wear fire fighting equipment and self
contained breathing apparatus.
MSDS # 3800
Page 2 of 3
SECTION V - REACTIVITY DATA
STABILITY: Stable
CONDITIONS TO AVOID: N/A
MATERIALS TO AVOID: N/A
HAZARDOUS DECOMPOSITION PRODUCTS: N/A
HAZARDOUS POLYMERIZATION: N/A
SECTION VI - HEALTH HAZARD
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Prolonged overexposure to the
product鈥檚 vapor or mist can cause nausea, headache, and irritation to nose, throat, lungs.
SKIN CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Wash with soap and water.
Remove contaminated clothing. Wash with copious amounts of water to rinse the product away.
EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Flush with fresh water for at
least 15 minutes, lifting upper and lower eyelids occasionally. If irritation persists, seek medical
attention.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: May be harmful if swallowed.
Ingestion may cause nausea, vomiting, diarrhea, and gastrointestinal irritation. Consult physician,
emergency center or poison center.
HEALTH HAZARDS (ACUTE & CHRONIC): None expected.
CARCINIGENICITY: NTP? No. IARC MONOGRAPHS? No. OSHA
REGULATED? No.
MEDICAL CONDITIONS AND AGGRAVATED BY EXPOSURE: Overexposure to vapors or mist
can cause headache, nausea or dizziness.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: Overexposure to vapors or mists can
cause headache, nausea or dizziness.
EMERGENCY & FIRST AID PROCEDURES
SKIN: Clean with soap and water.
INGESTION: Consult a physician.
INHALATION: Remove to fresh air.
EYE: Flush with water. Consult a physician.
SECTION VII - ENVIRONMENTAL INFORMATION
STEPS TO BE TAKEN IN CASE MATERIAL IS SPILLED OR RELEASED: Pick up immediately and
safely discard absorbents. In the event of large spills, dike the area and pump the material to a nearly
permitted waste tank in accordance with current regulations.
WASTE DISPOSAL METHOD: Dispose in accordance with current local, state and federal regulations
governing latex based paint.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Use with adequate ventilation.
Avoid prolonged breathing of vapor or skin contact. Keep away from excessive heat.
OTHER PRECAUTIONS: Avoid all sources of heat.
MSDS # 3800
Page 2 of 3
SECTION VIII- CONTROL METHODS
RESPIRATORY PROTECTION: When spraying this product, use a properly fitted NIOSHI approved
respirator to remove spray mist. When using in a poorly ventilated and confined spaces, use fresh air
supplying respirator or self-contained breathing apparatus.
VENTILATION: Maintain good ventilation.
PROTECTIVE GLOVES: Not required. If protection is desired, latex gloves will reduce excessive skin
contact.
EYE PROTECTION: Goggles or safety glasses or face shields are recommended.
OTHER PROTECTION: Eye washes and barrier creams, daily showers and change of clothes.
SECTION IX - DISCLAIMER
NOTICE: To the best of our knowledge, this information is accurate. However, we do not guarantee its
accuracy and cannot be liable for any damages actual and consequential which might result from reliance
thereon.
|