Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: SENSOR SAFE ULTRA GREY RTV 3.5 OZ
Item No: 82194
Product Type: Silicone
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
POLY (DIMETHYLSILOXANE), 40-50 Not Listed Not Listed
HYDROXY TERMINATED
70131-67-8
10 mg/m3 total dust 15 mg/m3 dust; 5 mg/m3 respir
CALCIUM CARBONATE 20-30
471-34-1
GARNET MINERAL 20-30 Not Listed Not Listed
1302-62-1
VINYL OXIMINOSILANE 1-10 Not Listed Not Listed
2224-33-1
10 mg/m3 inhal; 3 mg/m3 respir
SILICA, AMORPHOUS TREATED 1-10 20 mppcf
68909-20-6
STEARIC ACID 1-10 Not Listed Not Listed
57-11-4
2-BUTANONE OXIME **** Not Listed Not Listed
96-29-7
3. HAZARDS IDENTIFICATION
Note: This product does not contain microcyrstalline silica. May cause eye and skin irritation. ****When
Toxicity:
this product if exposed to moisture, butanone oxime may be formed. When heated to temperatures
above 300 degrees F. in the presence of air, this product can form formaldehyde vapors.
Formaldehyde is a potential cancer hazard and a known skin and respiratory sensitizer. Safe handling
conditions may be maintained by keeping vapor concentrations below the OSHA permissible limit for
formaldehyde. May be harmful if swallowed. May irritate lips, gums, tongue, mouth, nose and throat.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Butanone oxime produced during curing is toxic and irritates eyes, nose and throat. Overexposure to
the silane may cause coma and respiratory failure.
Medical Conditions Recognized as None known
Being Aggravated by Exposure:
4. FIRST AID MEASURES
Rinse mouth If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapors. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wipe off paste with paper towel or cloth. Wash off with soap and water If skin irritation persists, call a
Skin Contact:
physician
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
More than 200 degrees F. Method: Tag Closed Cup
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Water spray may be ineffective on flames but should be used to keep
Special Fire-Fighting Procedures:
fire-exposed containers cool.
Oxides of nitrogen, Methyl ethyl ketone, possibly methyl ethyl ketoxime.
Hazardous Products Formed by Fire or Thermal
Silica fume, Oxides of carbon. Formaldehyde,
Decomposition:
None
Unusual Fire/Explosion Hazards:
Not determined
Lower Explosive Limit:
Not determined
Upper Explosive Limit:
1 of 3
Product name: SENSOR SAFE ULTRA GREY RTV 3.5 Item 82194
OZ
6. ACCIDENTAL RELEASE MEASURES
Wipe or scrape up spill material. Maintain good ventilation for large spills. Place scrap material in a
Spill Procedures:
well-ventilated area and allow to cure to rubber. Clean up spills thoroughly as residue is slippery.
7. HANDLING AND STORAGE
Store in a dry area below 90 degrees F. Keep container closed when not in use.
Storage:
Avoid contact with skin and eyes. Do not wear contact lenses. Do not inhale vapors.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
rubber or plastic gloves
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits during the use of this product.
Not required under normal use. An approved respirator (i.e. NIOSH, etc.) should be worn when
Respiratory Protection:
exposures are expected to exceed the applicable limits..
9. PHYSICAL AND CHEMICAL PROPERTIES
Grey paste
Appearance:
MILD
Odor:
Not applicable, polymeric material
Boiling Point (癋):
Does not apply
pH:
Polymerized
Solubility in Water:
1.5
Specific Gravity:
7.1% by weight
VOC Content(Wt.%):
Less than 5 mm Hg @ 70 degrees F.
Vapor Pressure:
Not determined
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur
Hazardous Polymerization:
Polymerized by contact with moisture. Strong oxidizers. Acids, Iron.
Incompatabilities:
Exposure to moisture
Conditions to Avoid:
Oxides of nitrogen, Methyl ethyl ketone, possibly methyl ethyl ketoxime.
Hazardous Products Formed by Fire or Thermal
Silica fume, Oxides of carbon. Formaldehyde,
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
NONE
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
not regulated
Proper Shipping Name:
None
Class or Division:
None
UN/NA Number:
2 of 3
Product name: SENSOR SAFE ULTRA GREY RTV 3.5 Item 82194
OZ
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
NONE
CALIFORNIA PROP 65:
WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1, INSTABILITY 1
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 02/15/2005
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 4
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839
3 of 3
|