MATERIAL SAFETY DATA SHEET MSDS 826
Page 1
MSDS
ITEM NUMBER: C-826
Version 3 Effective Date 10/30/05 Supercedes 4/12/01 Prepared by: Regulatory Compliance
Section (s) Revised: HMIS, II, III, IV, V, VI, VII, VIII, IX
IDENTITY (As Used On Label and List): DE VERE OVEN & GRILL CLEANER
E M E R G E N C Y M E D I C A L Telephone# 1-866-836-8855 (24 HRS)
Outside the U.S.A. Call 952-852-4646
PRODUCT HAZARD RATINGS (NFPA): - Health = 3, Fire =2, Reactivity =0, Protective Equipment = B
(Rating Legend: 4 = Severe, 3 = Serious, 2 = Moderate, 1 = Slight, 0 = Minimal, *= Chronic Hazard)
SECTION I
DE VERE COMPANY TELEPHONE NUMBER FOR INFORMATION: 1-608-752-0576
JANESVILLE, WI 53547-8444 DATE PRINTED: December 23, 2005
NAME OF PREPARER: Regulatory Compliance
SECTION II - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
Chemical Names SARA Title III ACGIH OSHA % By Wt.
SEC 313 TLV-TWA/STEL PEL-TWA//STEL
Sodium Hydroxide (CAS# 1310-73-2) NO 2mg/m3/ NE 2mg/m3/NE 5-10
2-(2-Butoxyethoxy) ethanol (112-34-5) YES NE/NE NE/NE 5-10-
Monoethanolamine (CAS# 141-43-5) NO 3ppm/6ppm 3ppm/NE 1-5
Liquified Petroleum Gas NO
(CAS# 68476-86-8)
Propane (74-98-6) NO 1000 ppm/NE 1000ppm/NE -
n-Butane (106-97-8) NO 1000 ppm/NE NE/NE -
Balance of ingredients are non-hazardous or below reportable levels.
SECTION III - PHYSICAL CHARACTERISTICS
Boiling Point: NA Vapor Pressure (psig)(?5): 146 @ 130癋 / 66 @ 70癋
Specific Gravity ?calculated (H20=1): 1.0082 ?0.005 pH: 13-14 Solubility/Water: Soluble
Vapor Density (AIR=1): ND Evaporation Rate (Ether=1): ND
Appearance and Odor: Caustic blue gel packaged as an aerosol spray.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Aerosol Flammability: Product is not required to be labeled as flammable as described in 16 CFR 1500.3 and
1500.45.
Flashpoint: <0癋 (Propellant); >214癋 (Concentrate)
Flammable Limits - % Volume In Air (Propellant): LEL: 1.9% (propellant) UEL: 9.8% (propellant)
Extinguishing Media: Use foam, carbon dioxide or dry chemical.
Special Fire Fighting Procedures: Wear approved, positive pressure, self-contained breathing apparatus and full protective
clothing. Cool fire exposed containers with water. Protect against bursting cans
Unusual Fire and Explosion Hazards: Contents under pressure. Keep away from heat and open flames. Container may rupture or
explode in the heat of a fire. Prolonged exposure to temperatures above 120篎(48.9篊) may cause cans to burst.
SECTION V - REACTIVITY DATA
Stability: Stable Hazardous Polymerization: NA
Hazardous Decomposition Products: Carbon dioxide, carbon monoxide.
Incompatibility/Conditions to Avoid: Avoid strong oxidizing agents, acids, metals and sugars. Keep away from heat, sparks,
flames and other sources of ignition. Dropping containers may cause bursting.
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: Inhalation: Y Eyes: Y Skin: Y Ingestion: N
HAZARDS IDENTIFICATION:
Eye: Causes severe irritation and burns. Permanent corneal damage is possible.
Skin: Causes severe irritation and burns.
Inhalation: Breathing vapors or mists may cause severe irritation of the mucous membranes and upper respiratory tract.
Excessive overexposure to propellant may cause headache, dizziness, depressed respiration and heart rate, heart rhythm
irregularities, shortness of breath, unconsciousness or death.
Ingestion: Ingestion is an unlikely route of exposure for aerosol products. May cause severe gastrointestinal irritation or
burns, nausea, vomiting, abdominal pain and shock. Large amounts swallowed may be fatal.
AGGRAVATED MEDICAL CONDITIONS: Persons with pre-existing skin, respiratory and cardiovascular disorders.
CHRONIC EXPOSURE: Prolonged overexposure to monoethanolamine may cause liver and kidney damage.
EMERGENCY AND FIRST AID PROCEDURES:
Eye: Rinse thoroughly with water for at least 15 minutes, holding the eye lids open to be sure the material is washed out. Get
immediate medical attention.
MATERIAL SAFETY DATA SHEET MSDS 826
Page 2
Skin: Immediately remove contaminated clothing. Flush skin thoroughly with water for at least 15 minute, until all traces of
the chemical are removed. Get immediate medical attention.
Inhalation: Remove victim to fresh air. Give artificial respiration if needed. If breathing is difficult, oxygen should be
administered by qualified personnel. Get immediate medical attention.
Ingestion: Ingestion is an unlikely route of exposure for aerosol products. If ingestion occurs rinse mouth with a small
amount of water. Immediately call local poison control center or go to an emergency department. DO NOT INDUCE
VOMITING. Never give anything by mouth to an unconscious or drowsy person.
CARCINOGENICITY:
None of the components of this product are listed as carcinogens by IARC, NTP or OSHA.
TOXICOLOGICAL INFORMATION:
2-Butoxyethanol:
Chronic exposure may affect the liver and kidneys and may increase red blood cell hemolysis, which
could cause jaundice, fatigue, shortness of breath, and rapid heart rate.
LD50 Oral (Rat): >2000 mg/kg
LD50 Dermal (Rabbit): 220 mg/kg
LC50 Inhalation (Rat): 400 ppm/4 hr.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Releases or Spills: Remove all sources of ignition and ventilate area. Soak up spill with an inert
absorbent and place into a designated disposal container. Consult local regulatory agency for proper
disposition of material.
Waste Disposal Method: Do not puncture or incinerate containers. When contents are depleted continue to
Depress button until all gas is expelled. Dispose of container in accordance with local, state, and
federal regulations. Disposal regulations may be different for each state and/or locality.
Handling And Storing: Prevent contact with eyes, skin and clothing. Avoid breathing vapors and mists. Wash thoroughly after
handling. Do not taste or swallow. Do not take internally. Use only with adequate ventilation. Keep away from heat sources.
Contents under pressure. Do not puncture or incinerate container.
Please read and follow the directions on the product label; they are your best guide to using this product in the most effective way,
and give the necessary safety precautions to protect your health.
Store in a cool, well ventilated area at temperatures below 120篎 (48.9篊). Do not store in direct sunlight. Store away from
incompatible materials. Do not expose to direct sunlight or store at temperatures above 120癋 (48.9癈). Store as Level 1 Aerosol
(NFPA 30B).
Other Precautions: Please read and follow the directions on the product label; they are your best guide to
using this product in the most effective way, and give the necessary safety precautions to protect
your health.
SECTION VIII - EMPLOYEE PROTECTION
Respiratory Protection (Type): None needed under normal use conditions. For operations where the occupational exposure limit
may be exceeded, a NIOSH approved organic vapor/dust/mist respirator or supplied air respirator is recommended. Equipment
selection depends on contaminant type and concentration, select in accordance with OSHA 1910.134, ANSI Z88.2 and good industrial
hygiene practice. For firefighting, use self-contained breathing apparatus.
Ventilation: General ventilation should be adequate for normal use. For operations where the occupational exposure limit may be
exceeded, mechanical ventilation such as local exhaust may be needed to maintain exposure levels below applicable limits.
Protective Gloves: Impervious gloves are required.
Eye Protection: Wear chemical safety goggles to prevent eye contact.
Other Protective Clothing or Equipment: Protective clothing if needed to avoid skin contact. Suitable washing and eye flushing
facilities should be available in the work area. Contaminated clothing should be removed and laundered before re-use.
Work/Hygienic Practices: Ensure strict sanitary conditions are conformed to when working ar
SECTION IX - OTHER REGULATORY CONTROLS
FEDERAL:
Toxic Substance Control Act (TSCA): Ingredients of this product are listed on the EPA/TSCA Inventory
of Chemical Substances.
STATE RIGHT-TO-KNOW:
Pennsylvania/New Jersey Right-To-Know (Chemical and CAS No.):
Chemical CAS Number
Butyl Carbitol 112-34-5
Sodium Hydroxide 1310-73-2
Monoethanolamine 141-43-5
Liquefied Petroleum Gas 68476-86-8
SECTION X - TRANSPORTATION REQUIREMENTS (D.O.T. CLASSIFICATION)
Shipping Name: Consumer Commodity Hazard Class: ORM-D
NG-- Negligible NA-- Not Applicable NE-- Not Established UN-- Unavailable ND-- Not Determined
While the information set forth herein is believed to be accurate as of the date hereof, the Company makes no warranty or
guarantee, express or implied, and disclaims all liability arising out of the use of this information.
Effective Date 10/30/05 Supercedes 4/12/01 Prepared by: Regulatory Compliance
MATERIAL SAFETY DATA SHEET MSDS 826
Page 3
|