MATERIAL SAFETY DATA SHEET
Total Solutions
P.O. Box 240014
Milwaukee, WI 53224
GENERAL INFORMATION NUMBER: (414) 354-6417 REVISION DATE: March 26, 2004
CHEMTREC: (800) 424-9300 DATE OF ISSUE: April 1, 2004
I - Product Identification
Oven Cleaner
PRODUCT CODE: 8316
CHEMICAL FORMULATION: Pressurized water based alkaline cleaner.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 3 FLAMMABILITY: 3 REACTIVITY: 1
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
2 mg/m3 C 2 mg/m3 C
Sodium Hydroxide 20.0-30.0 Y N N 1310-73-2
Butyl Carbitol 5.00-15.0 N/E N/E N N Y 112-34-5
Monoethanolamine 1.00-5.00 3 ppm 3 ppm N N N 141-43-5
Liquefied Petroleum Gas 5.00-10.0 1000 ppm 1000 ppm N N N 68476-85-7
Key: PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
SPECIFIC GRAVITY (WATER = 1): Approximately 1.00
BOILING POINT (癋): Approximately 212 F
VAPOR PRESSURE (psig): 160 @ 130 F VOC CONTENT (% by weight): N/D
VAPOR DENSITY (AIR = 1): > 1.00 EVAPORATION RATE (WATER = 1): N/D
SOLUBILITY IN WATER: Appreciable pH: N/D
APPEARANCE AND ODOR: Coarse wet spray; butyl odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (癋): N/D (TEST METHOD): FLAME EXTENSION: N/D
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: 9.2 LOWER: 1.8
EXTINGUISHING MEDIA: Foam, carbon dioxide and dry chemical. NFPA 30B Rating: 1
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Contents under pressure! Exposure to temperatures above 120o F may cause
bursting.
PRODUCT NAME: Oven Cleaner PRODUCT CODE: 8316
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizers.
CONDITIONS TO AVOID: Heat, direct sunlight, open flames or sparks. Dropping of containers may cause bursting.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon flammable hydrogen gas
will be liberated upon contact with metals such as aluminum, tin or zinc. Additional toxic chemicals may be formed in small amounts.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Corrosive. Severe irritation and permanent tissue damage to eyes.
IF ON SKIN: Severe irritation, burns, tissue damage. Possible skin absorbtion.
IF SWALLOWED: Corrosive. May cause severe injury to mouth, throat and stomach.
IF INHALED: Irritation to the respiratory tract, nausea, dizziness, fatigue, confusion unconsciousness.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation persists, obtain medical
attention.
IF ON SKIN: Flush skin with water for at least 15 minutes while removing contaminated clothing. Launder clothing separately before
reusing. Obtain medical attention if irritation persists.
IF SWALLOWED: Contact physician or poison control center immediately. Rinse mouth with water. Do not induce vomiting unless
instructed by a physician or poison control center. Never give anything to an unconscious person.
IF INHALED: Remove person to fresh air. Administer artificial respiration. Obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area. Contain spill. Soak up material with inert
absorbent material and place in a labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities. Dispose of cans in non-incinerated trash only.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. Do not breathe vapors or mists. If recommended Exposure Limits
are exceeded, wear a NIOSH approved respirator, following manufacturer's recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant.
EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat, sparks or open
flame. Do not store at temperatures above 120 F.
OTHER PRECAUTIONS: Keep out of reach of children. Do not puncture or incinerate container.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: Consumer Commodity
DOT CLASS: ORM-D DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further
intended, different shipping names and labeling may apply.
REVISION DATE: March 26, 2004 Prepared by: PMR DATE OF ISSUE: April 1, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the
vendee, users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
|