MATERIAL SAFETY DATA SHEET
SECTION 1 ?PRODUCT/MANUFACTURER'S IDENTITY
Super Stripper Concentrate Formula ID Number: FM-20
Product Name:
MSDS File Name: SUPER STRIPPER CONC HAZARD RATING
Concentrate In Dilution
ST-940 EPA Reg #: None
Synonyms:
4 = Extreme
DOT Hazard Class: 8, Corrosive 0 0
Flammability 3 = High
DOT Shipping Name: Compounds, cleaning, liquid,
Stearns Packaging Corporation 2 = Moderate
Company: 3 1
Health
(containing monoethanolamine), 8, NA1760, 1 = Slight
4200 Sycamore Avenue (53714) 1 0
PG III, Ltd Qty. Item 48580, Sub. 3 Reactivity 0 = Insignificant
PO Box 3216
USDA Acceptance Date & Category Code: None None None
Madison, WI 53704-0216 Special Hazard
800-655-5008 Hazard Label: Corrosive (None for Ltd Qty)
Phone:
608-246-5149 Abbreviation Key: N.A.=Not Applicable,
Emergency Contact: CHEM-TEL, 800-255-3924
Fax:
N.D.=Not Determined
SECTION 2 ?HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
CHEMICAL IDENTIFICATION CAS NO. HAZARD OSHA OSHA ACGIH ACGIH %(Optional)
TWA8 STEL TWA8 STEL
Corrosive
Monoethanolamine, 2-aminoethanol 141-43-5 3 ppm 6 ppm 3 ppm 6 ppm
Combustible
Ethylene glycol monobutyl ether 111-76-2 50 ppm 20 ppm 40
Vegetable oil alkanolamide blend 68603-42-9 and others N/A
SARA Section 313 Title III Notification Required: Yes; Chemical in Product: Ethylene glycol monobutyl ether (glycol ether category); CAS#: 111-76-2; Weight % of Chemical: 40%
SECTION 3 ?PHYSICAL DATA
Solubility in water: Complete Vapor Pressure (mm Hg): N.D. pH (Concentrate): 12.5?.5
Appearance and Odor:
Clear amber liquid, Boiling Point: 130?F Vapor Density (Air=1): N.D. pH (Use Dilution): N/A
amine and butyl odor Melting/Freezing Point: < 0?F Evaporation Rate (n-butyl acetate=1): much slower than 1 Specific Gravity (Water=1): 0.965
SECTION 4 ?FIRE AND EXPLOSION HAZARD DATA
Flash Point and Method: >200癋, Closed cup. Special Fire Fighting Procedures: If quantities of material are stored near fire,
LEL: N.D. self-contained breathing device should be used.
Flammable Limits 3
UEL: N.D.
Extinguishing Media: Water spray, CO2, dry chemical, alcohol foam. Treat Unusual Fire & Explosion Hazards: No special hazards known to exist.
primary cause of fire.
SECTION 5 ?REACTIVITY DATA
Chemical Stability: Stable: X Unstable: Hazardous Polymerization: May Occur Will Not Occur X
Conditions to Avoid: Long exposure to materials containing copper,
Conditions to Avoid: None known
aluminum and strong oxidizing agents may cause discoloration.
Incompatibility (Materials to Avoid): Strong oxidizing or reducing agents. Hazardous Decomposition or By-Products: If heated to decomposition, CO, CO2,
NOx, and ammonia may be produced.
SECTION 6 ?HEALTH HAZARD DATA/FIRST AID PROCEDURES
Health Hazards (Acute and Chronic): INHALATION: Not determined for Emergency and First Aid Procedures:
formulation. SKIN: Not known for formulation; Rabbit Skin LD50
Eyes: PROMPTLY flush with large amounts of water occasionally lifting the
1.0g/Kg for MEA in formulation.
lower and upper lids. Get medical attention immediately.
Signs and Symptoms of Exposure: SKIN: May cause dermatitis or irritation
upon prolonged contact. Localized skin defatting can be expected Skin: As for all foreign materials, wash off concentrate or diluted use solution
from any detergent on long contact. EYES: Causes painful stinging or with water. Remove clothing, which has been saturated by concentrate.
burning of eyes and lids, watering of eyes, conjunctivitis, and in Do not allow prolonged contact with the concentrated undiluted material
concentrated undiluted form, lengthy exposure may cause as toxic amounts can be absorbed.
opaqueness of cornea, possibly leading to loss of sight. INGESTION: Inhalation: Remove from exposure.
May cause nausea, vomiting, and abdominal pain, incoordination, Ingestion of Concentrate: DO NOT induce vomiting. Immediately give two
diarrhea and general weakness. Ingestion of significant quantities may glasses of water or milk to dilute. NEVER give anything to an unconscious
cause red blood cell hemolysis and possible liver and kidney injury. person. Call a physician.
INHALATION: If misted in concentrated form, which is improper use, Ingestion of Use Solution: Give two glasses water to dilute. Call physician.
can cause irritation of mucous membrane, nose, eye and throat. Severe consequences should not be expected.
Medical Conditions Aggravated by Exposure: No data found. NOTE TO PHYSICIAN: Treatment should be directed at the control of
NTP? Yes No X OSHA Regulated? Yes No X symptoms and the clinical condition of the patient. There is no specific
Carcinogenicity: IARC Monographs? Yes No X antidote. Main hazard is due to irritant properties of amines.
Bronchodilators, expectorants and antitussives may be of help.
SECTION 7 ?PREVENTATIVE AND CONTROL MEASURES
Ventilation: Use with adequate ventilation. Working solution should not Steps to be Taken if Material is Spilled or Released: Concentrated materials only
present any specific hazard. If misted or an aerosol is generated, use come in unit-dosed bags limiting any spills to very small quantities.
local or mechanical ventilation to maintain vapor concentration below Paper toweling or mopping is usually sufficient.
TLV. Under normal working conditions, TLV will not be reached. Waste Disposal: Comply with all local, state and federal regulations. Consult
your state DNR or the EPA for specific questions. Wastewater should
Skin Protection: Use gloves if hands will be continuously in solution. Not
never enter a fresh water body without treatment. Recycle after rinsing
normally necessary in general use. As in handling any detergent, wash
package.
thoroughly after using.
Eye Protection: Not normally required. Use if in specific applications splashes Handling and Storage: Avoid contact with eyes and prolonged contact of
or mists will get into eyes. concentrate with skin. Avoid breathing misted vapors.
Respiratory Protection: No required under normal working/use conditions.
Other Precautions: Always keep out of the reach of children.
SECTION 8 ?OTHER REGULATORY INFORMATION
State Right-to-Know Regulations: State Right-to-Know
Monoethanolamine, 2-aminoethanol 141-43-5 CT, FL, IL, MA, NJ, PA, RI
Ethylene glycol monobutyl ether 111-76-2 PA
rev. 11/01/06
This MSDS data relates only to the material designated and does not relate to its use with any other material or process. The data is believed to be accurate. However, since use conditions
vary and are outside our control, Stearns Packaging Corporation makes no warranties, expressed or implied, and assumes no liability for failure to follow directions and safety precautions.
|