MATERIAL SAFETY DATA SHEET 24 HOUR EMERGENCY
PortionPac Chemical Corporation
RESPONSE PHONE:
400 N. Ashland Avenue, Chicago, IL 60622-6382
1-800-535-5053
Voice: 312/226-0400 Fax: 312/226-5400
Internet: www.portionpaccorp.com
SECTION 01 IDENTIFICATION
MSDS NO. 1800 Series REVIEWED: January 2009
MopPacLITE pH Neutral Floor Cleaner No. 1802 & 1804
TRADE NAME:
NOTE: CAS Registry numbers are not applicable to formulated products.
SECTION 02 PHYSICAL & HEALTH HAZARDOUS INGREDIENTS
Hazardous Material as defined by 29 CFR 1910.1200 Reportable under CERCLA or SARA TITLE III Sec. 304 Regulations.
Common Names: isopropanol, IPA, 2-propanol CAS# 67-63-0
Chemical Name: isopropyl alcohol
Hazard % in Formula: in concentrate: 4.5% in working/use solution: 0.013%
TLV:TWA 400ppm, (980 mg/m3) NIOSH 400ppm 10hrTWA IDLH 20,000ppm
Hazard Reference:
Common Name: DPM CAS# 34590-94-8
Chemical Name: dipropylene glycol monomethyl ether
Hazard % in Formula: in concentrate: 9.0% in working/use solution: 0.026%
Hazard Reference: 100 ppm OSHA PEL
SECTION 02A OTHER INGREDIENTS NOT CONSIDERED HAZARDOUS IN FORMULATION
water CAS# 7732-18-5
blend of alcohol ethoxylates CAS# 34398-01-1 & others n.a.
propylene glycol monomethyl ether CAS# 107-98-2
trace fragrance and colorant n.a.
SECTION 03 PHYSICAL & CHEMICAL CHARACTERISTICS
Boiling Point: 200 deg. F. (initial)
Vapor Pressure: Not determined.
Vapor Density (air=1): Not determined.
Water Solubility: Complete.
Melting/Freezing Point: < 0 deg. F.
Appearance: Bright yellow clear liquid.
Specific Grav. (water=1): 0.990 ?0.003
Percentage Volatiles : in concentrate: 7.5 in working/use solution: 0.03
Evaporation Rate: Much slower than 1 (n-butyl acetate = 1)
pH: in concentrate: 5.5 - 7.5 in working/use solution: 6.0 - 7.5
Odor: Floral.
SECTION 04 PHYSICAL HAZARD DATA
Flash Point: > 212 deg. F. closed cup.
Flammable Limits: Not determined.
Fire Fighting Media: Water spray, CO2, dry chemical. Treat primary cause of fire.
Special Fire Fighting Procedures: None.
Fire/Explosion Hazards: None known.
SECTION 05 REACTIVITY DATA
Stability: Stable.
Hazardous Polymerization: Will not occur.
Conditions to Avoid: None known.
Incompatible Materials: Strong oxidizing or reducing agents.
Hazardous Decomposition Products: If heated to decomposition CO, CO2 and NOx may be produced.
SECTION 06 HEALTH HAZARD DATA
Oral Toxicity: Not determined for formulation.
Skin Toxicity: Not known for formulation.
Carcinogenicity: None of the individual materials in this formulation are listed as carcinogens in NTP, IARC
Monographs, or are OSHA Regulated carcinogens.
SECTION 07 SYMPTOMS OF OVEREXPOSURE
Symptoms of Inhalation: If misted in concentrated form, which is improper use, can cause irritation of mucous membrane, nose, eye and throat.
Symptoms of Skin Contact: May cause dermatitis or irritation in some individuals upon prolonged contact. Localized skin defatting can be
expected from concentrated detergent on long contact.
Symptoms of Eye Contact: Concentrate will cause stinging or burning of eyes and lids, watering of eye, conjunctivitis.
SECTION 08 EMERGENCY FIRST AID PROCEDURES
For Ingestion: DO NOT attempt to induce vomiting. Have the individual drink one or more full glasses of milk or water. If vomiting
occurs, give fluids again. NEVER give anything to an unconscious person. Call a physician or your local Poison Control
Center. Treatment should be directed at the control of symptoms and the clinical condition of the patient. There is no
specific antidote.
For Skin: As for all foreign materials, wash off concentrate or diluted use solution with copious amounts of water. Remove clothing,
which has been saturated by concentrate. Thoroughly wash affected clothing and shoes.
For Eyes: PROMPTLY flush with large amounts of water for at least 15 minutes, occasionally lifting the lower and upper lids. See a
physician if irritation persists.
Medical Conditions
Aggravated by Exposure: No data found.
SECTION 09 OCCUPATIONAL CONTROL PROCEDURES
Ventilation: None normally required.
Respiratory Protection: Not required under normal working/use conditions.
Eye Protection: Not normally required. Use if in specific applications splashes or mists might get into eyes.
Skin Protection: Not normally required.
Personal Hygiene: As in handling any detergent, wash thoroughly after using.
SECTION 10 PRECAUTIONS FOR SAFE HANDLING STORAGE AND USE
Precautionary Measures: Avoid contact of concentrate with eyes and prolonged contact of concentrate with skin. Avoid breathing misted vapors.
Spills Clean-up Procedures: Concentrated materials are packed in small unit dosed bags limiting any spills to very small quantities. Paper toweling
or mopping is usually sufficient.
Disposal Method: Normal waste disposal of empty bags in accordance with state and local regulations or recycle after rinsing package
HAZARD RATINGS
NFPA Concentrate NFPA Dilution
Health 1 0
Flammability 1 0
Reactivity 0 0
GENERAL NOTE ABOUT PRODUCTS
?br>
MopPacLITE pH Neutral Floor Cleaner detergent formulation is not substantially different from any other commercially available neutral hard surface
cleaner. The unique packaging of PortionPac materials in unit dosed bags limits the amount of exposure of the concentrate to very small amounts.
Spills can be cleaned up with paper toweling or plain mopping as this product is made for floor mopping. We know of no hazards associated with the
proper use and handling of this product.
PortionPac Chemical Corporation makes no warranty, expressed or implied, as to the accuracy, completeness or reliability of this information, except
that such information is, to the best of our knowledge and belief, accurate as of the date indicated.
PELIGRO: SI NO PUEDE LEER EN INGLES, PREGUNTE A SU SUPERVISOR SOBRE LAS INSTRUCCIONES DE
USO APROPIADAS ANTES DE TRABAJAR CON ESTE PRODUCTO.
24 HOUR EMERGENCY RESPONSE PHONE: 1-800-535-5053
MSDS: 1800 REVIEWED: 01/09
This document is part of the PortionPac Sanitation Program and is proprietary material of PortionPac Chemical Corp. PortionPac? and the "Pac?Family" names and images
?br>
are the intellectual property of PortionPac Chemical Corp. ?005-2009 PortionPac Chemical Corp. All rights reserved.
|