PRODUCT NAME : ULTRA-GLO - RESIN
PRODUCT CLASS: EPOXY RESIN
PRODUCT NUMBER: 00027, 00027C, 00035, 00035C, 00043, 00043C, 00078, 00078C
SECTION I - MANUFACTURER IDENTIFICATION
ENVIRONMENTAL TECHNOLOGY, INC.
300 SOUTH BAY DEPOT ROAD
FIELDS LANDING, CA 95537
DEPARTMENT OF TRANSPORTATION INFORMATION:
NON-HAZARDOUS
PHONE NUMBER FOR INFORMATION:
(707) 443-9323
TRANSPORTATION EMERGENCY PHONE NUMBER:
CHEMTREC (800) 424-9300
DATE PREPARED:
01/31/02
PREPARED BY:
TECHNICAL DIRECTOR
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
CAS APPROX ACGIH OSHA VAPOR
HAZARDOUS COMPONENTS
REG.NO. WT.% TWA/TLV PEL PRESSURE
mm Hg
BISPHENOL T/S T/S N/S N/E <1
A/EPICHLOROHYDRIN RESIN
ALIPHATIC AND AROMATIC T/S T/S N/E N/E <1
GLYCIDL ETHERS
ALTHOUGH NO EXPOSURE STANDARDS HAVE BEEN ESTABLISHED FOR THIS PRODUCT, AIR CONTAMINANT
CONCENTRATIONS MUST BE MAINTAINED AT LOWEST POSSIBLE LEVELS.
T/S = TRADE SECRET N/A = NOT AVAILABLE N/E = NOT ESTABLISHED
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING RANGE 掳F >350 PERCENT VOLATILE BY T/S
VOLUME
MELTING OR N/A PERCENT VOLATILE BY T/S
FREEZING POINT WEIGHT
VAPOR DENSITY >1 EVAPORATION RATE (SLOWER LBS./GAL 9.6
(AIR=1) THAN ETHER)
SOLUBILITY IN WATER: VOC T/S
SLIGHTLY SOLUBLE LBS/GAL
APPEARANCE AND ODOR: CLEAR, COLORLESS, VISCOUS VOC T/S
LIQUID WITH CHARACTERISTIC, EPOXY RESIN ODOR GRAMS/LITER
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): TOC >160掳F
FLAMMABLE LIMITS: LEL: N/E UEL: N/E
EXTINGUISHING MEDIA: X FOAM X ALCOHOL FOAM X CO2 X DRY CHEMICAL XWATER SPRAY OTHER
SPECIAL FIRE FIGHTING PROCEDURES: USE NIOSH APPROVED PROTECTIVE CLOTHING INCLUDING POSITIVE PRESSURE
SELF CONTAINED BREATHING APPARATUS(SCBA). COOL UNOPENED CONTAINERS WITH WATER SPRAY.
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE EXPECTED
SECTION V - REACTIVITY DATA
STABILITY: UNSTABLE X STABLE / CONDITIONS TO AVOID:
|INCOMPATIBILITY (MATERIALS TO AVOID): AVOID CONTACT WITH STRONG ACIDS, AMINES OR OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: BURNING PRODUCT WILL EMIT TOXIC FUMES INCLUDING OXIDES OF
CARBON AND NITROGEN, AND VARIOUS CHLORINATED COMPOUNDS.
HAZARDOUS POLYMERIZATION: MAY OCCUR X MAY NOT OCCUR.
SECTION VI - HEALTH HAZARD DATA
ROUTE(S) OF ENTRY: INHALATION? YES SKIN? YES INGESTION? UNLIKELY
HEALTH HAZARDS (ACUTE AND CHRONIC): MILDLY IRRITATING TO EYES AND SKIN, VAPORS AND/OR SKIN CONTACT
COULD CAUSE SENSITIZATION. VAPORS ARE IRRITATING TO RESPIRATORY TRACT. REACTIONS TO INGESTION ARE
UNDETERMINED.
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
SIGNS AND SYMPTOMS OF EXPOSURE: SENSITIZATION MAY CAUSE HIVE-LIKE RASH AND BREATHING DIFFICULTIES. EYE
OR SKIN CONTACT WOULD PRODUCE REDNESS AND IRRITATION.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: PRE-EXISTING SKIN OR EYE PROBLEMS MAY BE
WORSENED BY EXPOSURE TO THIS PRODUCT. EXISTING ALLERGIES MAY INCREASE THE POSSIBILITY OF ALLERGIES TO
THIS MATERIAL.
EMERGENCY AND FIRST AID PROCEDURES: ORAL: INDUCE VOMITING. CALL PHYSICIAN IMMEDIATELY! EYES:
SEVERE IRRITANT TO EYES. IN CASE OF EYE CONTACT, FLUSH THOROUGHLY WITH WATER FOR 15 MINUTES AND GET
PROMPT MEDICAL ATTENTION. SKIN: WASH IMMEDIATELY WITH SAOP AND RINSE WITH THOROUGHLY WITH WATER. DO
NOT USE SOLVENTS OR ALCOHOL TO REMOVE PRODUCT FROM SKIN. INHALATION: MOVE TO FRESH AIR. IF NOT
BREATHING ADMINISTER CPR. IF BREATHING IS DIFFICULT GET MENDICAL ATTENTION.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: VENTILATE AREA. WEAR PROTECTIVE CLOTHING AND
NIOSH APPROVED RESPIRATOR. DIKE AND CONTAIN SPILL. SPREAD ABSORBENT MATERIAL. KEEP SPECTATORS AWAY.
WASTE DISPOSAL METHOD: NOT A RCRA HAZARDOUS WASTE AS SUPPLIED; USER MUST DETERMINE RCRA STATUS AT
TIME OF DISPOSAL. LANDFILL OR INCINERATE IN ACCORDANCE WITH EXISTING FEDERAL, STATE, AND LOCAL
REGULATIONS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: STORE IN COOL DRY AREA, AWAY FROM STRONG OXIDANTS,
HEAT OR IGNITION SOURCES. ALWAYS KEEP CONTAINERS CLOSED. DO NOT GET ON SKIN OR BREATHE VAPORS.
OTHER PRECAUTIONS: CLEAN UP ANY SPILLS IMMEDIATELY. WASH ANY AREAS OF BODY CONTACT IMMEDIATELY.
SECTION VIII - CONTROL MEASURES
RESPIRATORY PROTECTION (SPECIFY TYPE): NIOSH APPROVED TO PREVENT INHALATION OF VAPORS; IF VENTILATION
IS INADEQUATE, SCBA MAY BE REQUIRED.
VENTILATION: LOCAL EXHAUST: IF REQUIRED. SPECIAL VENTILATION MUST BE ADEQUATE TO AVOID BREATHING
VAPORS. USE IN SEALED EQUIPMENT AS MUCH AS POSSIBLE. MECHANICAL (GENERAL): REQUIRED
PROTECTIVE GLOVES: NEOPRENE OR RUBBER
EYE PROTECTION: SAFETY GOGGLES
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: TO AVOID ALL SKIN CONTACT. WEAR PROTECTIVE APRON AND AVOID
FOOT CONTACT.
WORK/HYGIENIC PRACTICES: WASH AT END OF WORK SHIFT, BEFORE EATING, SMOKING OR USING RESTROOM. DO NOT
RE-USE CONTAMINATED CLOTHING.
REGULATORY INFORMATION: THIS PRODUCT IS REGULATED UNDER SARA TITLE III SECTION 311 AS ACUTELY
HAZARDOUS.
Disclaimer: All information, recommendations, and suggestions appearing herein concerning our product are based upon tests and
data believed to be reliable. However, it is the user's responsibility to determine the safety, toxicity, and suitability for his or her own use
of the product described herein. Since the actual use by others is beyond Environmental Technology, Inc.'s control, no guarantee,
expressed or implied, is made by Environmental Technology, Inc. as to the effects of such use, the results to be obtained, or the safety
and toxicity of the product.
|