MATERIAL SAFETY DATA SHEET
Texas Correctional Industry NFPA HAZARD RATING
T
A division of the Fire Hazard
4- SEVERE
C Texas Department of Criminal Justice
3- SERIOUS 0
I
Health Hazard Reactivity
2- MODERATE 1 0
1- SLIGHT
Date Issued: December 2007
Specific Hazard
0- INSIGNIFICANT
Supersedes: January 2004
SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION
Product Name: Germguard 鈥? Soap Bar Antibacterial
General Use: Body bar soap Emergency Telephone Numbers
Manufacturer Name: Texas Correctional Industry Galveston Texas Poison Control: 1-800-764-7661
Soap & Detergent Plant Soap & Detergent Plant Lab: 281-490-1111
One Circle Drive MSDS available at: www.tci.tdcj.state.tx.us
Sugar Land, Texas 77478 Monday thru Thursday: 7a.m. - 3 p.m.
SECTION 2 - HAZARDOUS INGREDIENT
ACGIH/OSHA
Chemical/Common Name CAS No. PERCENT TWA PEL WHMIS
3,4,4-Trichlorocarbanilide (TCC) 101-20-2 ~0.4 鈥? 1.5 3 mg/m3 N/D N/A
N/A= Not Applicable N/E= Not Established N/D = Not Determined
WHMIS 鈥? minimum amount necessary in a mixture to trigger reporting: 1% (hazardous chemical); 0.1% (extremely hazardous chemical)
SECTION 3 - PHYSICAL PROPERTIES
Vapor Pressure : None
Density (g/ml) : N/D
Solubility in Water : Complete
pH (1% aqueous solution) : N/D
Boiling Point : N/A
Appearance and Odor : Blue with 鈥淚cy Blast鈥?-type fragrance
SECTION 4 - FIRE AND HAZARD DATA
Flash Point (T.C.C.) : Not flammable
Flammable Limit : N/A
Physical Hazard : None
Extinguishing Media : Water, Foam, Dry Chemicals, or Carbon Dioxide
Fire Extinguishing Procedure : None
Fire and Explosive Hazard : None
Germguard, SAS; Date Issued: December 2007
SECTION 5 - REACTIVE DATA
Hazardous Decomposition : None
Stability : Stable
Incompatibility : None
SECTION 6 - HEALTH HAZARD
Primary Route of Exposure : Eyes, skin, or oral
Signs and Symptoms of Over Exposure (acute)
Eyes : May cause eye irritation
Skin : No usual reaction
Ingestion : May cause gastrointestinal irritation, with nausea, vomiting, or diarrhea
Inhalation : May be an irritant to the respiratory tract
Signs and Symptoms of Over Exposure (chronic) : None known
Medical condition aggravated by over exposure : Not known
Carcinogen or suspect of carcinogen ingredients : None
SECTION 7 - EMERGENCY AND FIRST AID PROCEDURE
Eyes : Flush eyes with plenty of water until irritation subsides. If irritation persists, get medical attention.
Skin : Flush skin with large amount of water. Seek medical attention if any irritation persists.
Ingestion : Rinse mouth thoroughly and drink plenty of water. Treat symptomatically and do not induce vomiting unless directed
by physician.
Inhalation : Move patient to fresh air immediately
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection : None required with normal use
Ventilation Requirement : Not required
Protective Gloves : Not required
Eye Protection : Not required
SECTION 9 - SPILL OR LEAK PROCEDURES
Steps to be taken if released or spilled : Sweep all materials practical for salvage or disposal. Rinse residue with water.
Waste disposal method : Any unsalvageable material must be disposed in compliance with local, state, and
federal laws and regulations. Do not dump into sewers, on the ground, or into any
bodies of water.
SECTION 10 - STORAGE AND HANDLING
Store in a cool, dry area. Do not get in eyes. Wash thoroughly after handling.
|