MATERIAL SAFETY DATA SHEET
(Essentially similar to OSHA form 174, Sept. 1985 - For Compliance with OSHA鈥檚 Hazard Communication Standard, 29CFR 1910.1200)
Section I - Product Identity: Lead-Prep庐 II (5496)
Date of Preparation: March 7, 2007
Manufacturer鈥檚 Name:
Fiberlock Technologies, Inc. Information Telephone Number: (978) 623-9987
150 Dascomb Road Emergency Telephone Numbers:
Andover, MA 01810 Weekdays: (978) 623-9987
After hours, weekends & holidays: 鈥淐HEM-TEL鈥?
Emergency Contact Number: (800) 255-3924
Section II - Hazardous Ingredients/Identity Information
HAZARDOUS COMMON CAS. OSHA OR ACGIH
COMPONENT NAME(S) % NO. PEL TLV
None
Section III - Physical/Chemical Characteristics
1.00 approx.
212掳F Specific Gravity @ 60/65掳F
Boiling Point
Vapor Pressure Unknown Melting Point Water (Ice) 32掳F
Vapor Density (AIR=1) % Volatile Above 95%
Heavier Evaporation Rate
X Less than Ether
Lighter (Butyl Acetate=1)
Appearance Yellow liquid VOC (% by wt.) <1
Total
Solubility in Water and Odor Mild pH: 9-10
Section IV - Fire and Explosion Hazard Data
Flammable Limits:
Flash Point: DOT Hazard Class: Marking:
Unknown
None Cleaning Compound/ Not Regulated 鈥淜eep From Freezing鈥?
Extinguishing Media: Water fog, regular foam, carbon dioxide, or dry chemical.
Hazardous Decomposition Products: May form toxic materials: carbon dioxide, carbon monoxide, various hydrocarbons, etc.
Special Firefighting Procedures: Wear self-contained breathing apparatus with full face piece operated in pressure-demand or other
positive pressure mode.
Unusual Fire and Explosion Hazards: None
Section V - Reactivity Data
Hazardous Polymerization: Will not occur.
Stability: Stable
Incompatibility (materials to avoid): Strong acids (e.g. HCl), strong oxidizing agents (e.g. nitric acid, permanganates).
Conditions to Avoid: See 鈥淪ection 4 - UNUSUAL FIRE AND EXPLOSION HAZARDS.鈥?
Section VI - Health Hazard Data, Toxicity Data
Route(s) of Entry: Eyes, Skin, Inhalation, Swallowing
Carcinogenicity: NTP? No IARC MONOGRAPH? No OSHA Regulated? No
EFFECTS OF OVEREXPOSURE -- ACUTE (immediate): Inhalation: No effects expected. Skin Contact: Short contact- no irritation.
Prolonged or frequently repeated contact can cause irritation, defatting, dermatitis. Eye Contact: Can cause irritation, redness and
tearing. Ingestion: Can cause internal irritation. CHRONIC (delayed): Eyes: No chronic effects expected. Skin: No chronic effects
expected. Inhalation: When used as intended, no chronic effects expected.
EMERGENCY AND FIRST AID PROCEDURES: Inhalation: If illness occurs remove patient to fresh air. If breathing is difficult, give
oxygen. If breathing has stopped, start artificial respiration. Call physician immediately. Eye Contact: Flood with plenty of water with
eyelids open for at least 15 minutes and get medical attention promptly.
Skin Contact: Wash skin thoroughly with soap and water. Thoroughly launder contaminated clothing before reuse. If irritation and
redness persists, see physician. Swallowing: DO NOT INDUCE VOMITING. Immediately give large quantities of water. Keep person
warm and quiet and get medical attention. Aspiration of material into lungs due to vomiting can cause chemical pneumonitis which can
be fatal.
SUPPLEMENTAL INFORMATION
To comply with New Jersey DOH Right-To-Know labeling law
(N.J.A.C. 8:59 - 5.1 & 5.2)
CAS. No.: CHEMICAL INGREDIENTS: HMIS HAZARD RATING
7732-18-5 Water Health 1 Flammability 0 Reactivity 0 Personal Protection B
57018-52-7 1-t-butoxy-2-propanol
HAZARD INDEX: 0=Minimal, 1=Slight, 2=Moderate, 3=Serious, 4=Severe
533-96-0 Sodium sesquicarbonate
1303-96-4 Sodium tetraborate PERSONAL PROTECTION CODE
61790-63-4 Coco diethanolamide B=Safety Glasses, Gloves
Section VII: Precautions for Safe Handling and Use
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Review Section IV 鈥淯nusual Fire and
Explosion Hazards鈥?
SMALL SPILLS: Absorb liquid on paper, vermiculite, floor absorbent, or other absorbent material and shovel into
containers.
LARGE SPILLS: Same as small spill.
DISPOSAL OF WASTE: Contaminated absorbent must be disposed of in accordance with local, state and
federal regulations.
EMPTIED CONTAINERS: Emptied containers may retain product residues (e.g. vapor and liquid or solids);
therefore, all precautions given in this sheet must be observed.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Store in a cool place - out of hot sun and below
100掳F.
NOTE: Judgement of potential hazards of this mixture is based on information available about individual compo-
nents listed under SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION. Direct testing of a
mixture has not been done. Flashpoint has been tested.
Section VIII: Control Measures
VENTILATION: None required.
RESPIRATORY PROTECTION: None required.
GLOVES: Wear protective gloves such as neoprene.
EYE PROTECTION: Safety glasses recommended.
OTHER PROTECTIVE EQUIPMENT: None required.
|