Commercial Food Equipment Service Association P_0000299127 D_0000323968
BLAST-A-COIL
Material Safety Data Sheet
SECTION I - COMPANY IDENTIFICATION
PRODUCT: Blast-A-Coil CAT. NO.: BAC20i
MANUFACTURED BY: TELEPHONE NUMBERS:
Virginia KMP Corporation Office: 1-(214) 330-7731
4100 Platinum Way Emergency Only: 1-(800) 424-9300
Dallas, Texas 75237
SECTION II - HAZARDOUS INGREDIENTS
OSHA Hazardous Components (29 CFR 1910.1200) EXPOSURE LIMITS: 8 HR. TWA
OSHA PEL ACGIH TLV
Carbon Dioxide (CAS # 124-38-9) 5,000 ppm 5,000 ppm
Trichloroethylene (CAS # 79-01-6) 50 ppm 50 ppm
SECTION III - HAZARDS IDENTIFICATIONS
EMERGENCY OVERVIEW:
DANGER! Vapor harmful. Harmful or fatal if swallowed. Aerosol, contents under pressure.
Irritating to eyes, skin, mucous membranes, and respiratory tract.
POTENTIAL HEALTH EFFECTS:
INHALATION: Excessive inhalation of vapors can be harmful and may cause headache, dizziness, asphyxia, anesthetic effects and
possible unconsciousness.
EYE CONTACT: Vapors and liquids irritating to eyes.
SKIN CONTACT: Irritant to skin.
INGESTION: Possible chemical pneumonitis if aspirated into lungs. Nausea.
CHRONIC Effects: (Effects due to excessive exposure to the raw materials of this mixture) May cause liver abnormalities, kidney,
spleen, lung or brain damage, cardiac abnormalities.
CARCINOGENICITY: LISTED IN NTP? Yes IARC? Yes OSHA Regulated? Yes
1910.1-000 Table Z-2
SECTION IV - FIRST AID MEASURES
INHALATION: Remove to fresh air. If not breathing, apply artificial respiration. Keep victim warm. Seek medical advice.
EYE CONTACT: Flush with large amounts of running water for 15 minutes occasionally lifting lower and upper eyelids. Seek medical advice.
SKIN CONTACT: Wash exposed area with soap and water. Remove contaminated clothing. Seek medical advice if symptoms develop.
INGESTION: Give water. Do NOT induce vomiting. Aspiration into lungs may cause chemical pneumonia. Seek immediate medical attention. Do
not give anything by mouth to an unconscious person. If spontaneous vomiting occurs, keep head below hips.
SECTION V - FIRE FIGHTING MEASURES
FLAMMABILITY: (per the USA Flame Projection Test (aerosols)): Non-Flammable
FLASHPOINT (TEST METHOD): Not Applicable
FLAMMABLE LIMITS: LOWER: Not Applicable UPPER: Not Applicable
AUTOIGNITION TEMPERATURE(non-aerosol i.e. base stock): Not Applicable
GENERAL HAZARD: WARNING! Product under pressure, may explode from excessive heat. Water may be ineffective to fight fire. Toxic gases
may be produced in fire.
FIRE FIGHTING INSTRUCTIONS: Do not enter without full bunker of equipment including self contained breathing apparatus. Stay upwind, keep all
personnel away. Cool fire exposed containers with water.
EXTINGUISHING MEDIA: Use carbon dioxide, alcohol foam, dry chemical.
HAZARDOUS COMBUSTION PRODUCTS: Smoke, fumes, oxides of carbon, and small amounts of fumes of phosgene and chlorides.
SECTION VI - ACCIDENTAL RELEASE MEASURES
Isolate hazard area. Keep unnecessary and unprotected personnel away. Clean up spills and leaks immediately to prevent soil and water
contamination.
LAND SPILL: Absorb spill with inert, non-combustible material, then place in a chemical waste container.
WATER SPILL: Contain material. Collect and store in a chemical waste container.
SECTION VII - HANDLING AND STORAGE
HANDLING: Use with adequate ventilation. Avoid skin/eye contact and breathing vapors. DO NOT CUT, WELD, BRAZE, SOLDER, DRILL, OR
EXPOSE TO HEAT, FLAME, SPARKS, STATIC ELECTRICITY.
Store in a cool, dry place away from heat (< 120oF.), ignition sources, oxidizers, and strong acids.
STORAGE:
Commercial Food Equipment Service Association P_0000299127 D_0000323968
BLAST-A-COIL
SECTION VIII - EXPOSURE CONTROLS/ PERSONAL PROTECTION
ENGINEERING CONTROLS: Adequate ventilation to control vapor accumulation.
PERSONAL PROTECTION: If TLV exceeded, NIOSH approved respirator for organic vapors.. Wear chemical goggles or full face shield and
chemical impervious apron to protect from splashing. Wear chemical impervious gloves. Wash clothing before
reuse.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
VAPOR PRESSURE: psig @ 70of (aerosols): 85-100 VAPOR DENSITY (Air=1) : Not Applicable
SPECIFIC GRAVITY: Concentrate only: 1.45 EVAPORATION RATE (N-BUTYL ACETATE=1): 2.6 concentrate
only
SOLUBILITY IN WATER: Insoluble pH: NA
FREEZING POINT: Not Applicable BOILING POINT: Not Applicable
APPEARANCE & ODOR: Clear, colorless spray with lemon chlorinated solvent odor.
SECTION X - STABILITY AND REACTIVITY
STABILITY: Stable
CONDITIONS TO AVOID: Avoid excessive heat, ignition sources, and flames. Isolate from oxidizers and strong acids.
MATERIALS TO AVOID: Reactive metals, aluminum, magnesium and strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Monoxide, Carbon Dioxide, Hydrochloric Acid, small amounts of phosgene and chlorine
fumes.
HAZARDOUS POLYMERIZATION: Will not occur.
SECTION XI - TOXICOLOGICAL INFORMATION
Carbon Dioxide (CAS # 124-38-9) LD50 / LC50: Not Known
Trichloroethylene (CAS # 79-01-6) LD50: 4.92 ml/kg (oral-rat)
LC(4hrs): 8000 ppm (rats)
SECTION XII - ECOLOGICAL INFORMATION
No Data Available.
SECTION XIII - DISPOSAL CONSIDERATIONS
Classification of waste required before disposal. Follow all local, state,
and federal regulations. Aerosol cans when vented to atmosphere pressure through normal use, pose no disposal hazard.
SECTION XIV - TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Aerosols,non-flammable,(each not exceeding 1 L capacity)
HAZARD CLASS: 2.2
IDENTIFICATION NUMBER: UN 1950
DOT Emergency Guide #: 126
Reportable Quantity (RQ): Not Applicable
International: Aerosols,non-flammable,(each not exceeding 1 L capacity),2.2., UN 1950, IMDG 9022
SECTION XV - REGULATORY INFORMATION
TSCA (Toxic Substance Control Act): Components of this product are listed on the TSCA Inventory.
CERCLA (Comprehensive Environmental Response, Compensation and Liability Act): RQ 100 pounds for Trichloroethylene (CAS # 79-01-6). We
recommend you contact local authorities for other reporting requirements.
SARA TITLE III (Superfund Amendments and Reauthorization Act): Trichloroethylene (CAS # 79-01-6)
311/312 Hazard Categories: Acute, Pressure
313 Reportable Ingredients: Trichloroethylene (CAS # 79-01-6)
CALIFORNIA PROPOSITION 65: This product contains chemicals which are known to the State of California to cause cancer or reproductive
toxicity.
SECTION XVI - OTHER INFORMATION
State Right-to-Know Programs: Massachusetts, Pennsylvania, New Jersey
Prepared by: Virginia KMP Corporation revised: 2001-09-26
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated here in. Virginia KMP assumes no legal responsibility for use or reliance upon these data.
Commercial Food Equipment Service Association P_0000299127 D_0000323968
BLAST-A-COIL
NFPA Ratings
Health: 2
Flammability: 0
Reactivity: 0
HMIS Protective Equipment: X See your supervisor
Revised: 8/21000
Prepared by: Virginia KMP Corporation revised: 2001-09-26
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Virginia KMP. The data on
this sheet related only to specific material designated here in. Virginia KMP assumes no legal responsibility for use or reliance upon these data.
|