Page 1 of 5
MATERIAL SAFETY DATA SHEET MSDS WP-003
Prepared to OSHA, CMA, ANSI and WHMIS Standards MSDS Revision Date 11/01/2000
1. PRODUCT IDENTIFICATION
1.1 Product Name:
HONDA 89 AUTOMATIC TRANSMISSION FLUID (P/N 08200-9001, 08206-9001)
1.2 Chemical Name:
MIXTURE
1.3 Synonyms:
NONE LISTED.
1.4 Trade Names:
HONDA AUTOMATIC TRANSMISSION FLUID
1.5 Product Use:
AUTOMOTIVE - LUBRICANT
1.6 Manufacturer鈥檚 Name:
APOLLO AMERICA CORPORATION
1.7 Manufacturer鈥檚 Address:
701 PORT ROAD JEFFERSONVILLE, IN 47130
1.8 Emergency Phone:
1-800-424-9300
1.9 Business Phone:
1-812-284-3300
2. COMPOSITION & INGREDIENT INFORMATION
EXPOSURE LIMITS IN AIR
ACGIH OSHA OTHER
TLV STEL PEL STEL IDLH
CHEMICAL NAME(S) CAS NO. % ppm ppm ppm ppm ppm
NO HAZARDOUS INGREDIENTS NA NA NA NA NA NA NA NA
REPORTED BY THE MANUFACTURER
NA 鈮? Not Available; ND 鈮? Not Determined; NE 鈮? Not Established; C 鈮? Ceiling Limit; See Section 16 for Additional Definitions of Terms Used
NOTE: all WHMIS required information is included. It is located in appropriate sections based on the ANSI Z400.1-1993 format.
Page 2 of 5
MATERIAL SAFETY DATA SHEET MSDS WP-003
Prepared to OSHA, CMA, ANSI and WHMIS Standards MSDS Revision Date 11/01/2000
3. HAZARD IDENTIFICATION
3.1 Hazard Identification:
NON-HAZARDOUS COMPONENTS PER 29 CFR 1910.1200. COMBUSTIBLE. LOW ORDER OF TOXICITY FOR NORMAL INDUSTRIAL OR
COMMERCIAL USE.
Inhalation: Absorption: Ingestion:
3.2 Routes of Entry: YES YES NO
3.3 Effects of Exposure:
EYE: SLIGHT IRRITATION.
SKIN: SLIGHT IRRITATION AND POSSIBLE DERMATITIS (RASH).
INGESTION: LOW ORAL TOXICITY. MAY HAVE A LAXATIVE EFFECT. IF ASPIRATED, CHEMICAL PNEUMONITIS MAY OCCUR.
INHALATION: NOSE AND THROAT IRRITATION. SPRAYING / MISTING MAY CAUSE CHEMICAL PNEUMONITIS.
3.4 Symptoms of Exposure:
EYE: STINGING, REDNESS, WATERING.
SKIN: DRYING / CRACKING SKIN. POSSIBLE DERMATITIS (RASH).
INGESTION: UPSET STOMACH, NAUSEA, VOMITING, AND DIARRHEA.
INHALATION: NO SYMPTOMS KNOWN OR REPORTED BY THE MANUFACTURER.
3.5 Acute Health Effects:
EYE: SLIGHT IRRITATION.
SKIN: NO EFFECTS REPORTED BY THE MANUFACTURER.
INGESTION: LOW ORAL TOXICITY. MAY HAVE A LAXATIVE EFFECT. IF ASPIRATED, CHEMICAL PNEUMONITIS MAY OCCUR.
INHALATION: NOSE AND THROAT IRRITATION. SPRAYING / MISTING MAY CAUSE CHEMICAL PNEUMONITIS.
3.6 Chronic Health Effects:
EYE: NO CHRONIC EFFECTS REPORTED BY THE MANUFACTURER.
SKIN: SLIGHT IRRITATION POSSIBLE DERMATITIS (RASH) MAY OCCUR UPON REPEATED OR PROLONGED EXPOSURE.
INGESTION: NO CHRONIC EFFECTS REPORTED BY THE MANUFACTURER.
INHALATION. NO EFFECTS KNOWN OR REPORTED BY THE MANUFACTURER.
3.7 Target Organs:
EYES, SKIN, AND UPPER RESPIRATORY TRACT.
4. FIRST AID MEASURES
4.1 First Aid:
EYE: FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. IF IRRITATION PERSISTS, SEEK MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING AND WASH AFFECTED AREAS WITH SOAP AND WATER OR A NON-LIQUID SKIN CLEANSER. IF
IRRITATION PERSISTS, SEEK MEDICAL ATTENTION. LAUNDER CLOTHING BEFORE REUSE.
INGESTION: DO NOT INDUCE VOMITING. CALL A PHYSICIAN OR A POISON CONTROL CENTER IMMEDIATELY FOR ASSISTANCE AND
INSTRUCTIONS. GIVE 1 TO 2 GLASSES OF WATER TO DILUTE. IF VOMITING OCCURS SPONTANEOUSLY, KEEP VICTIMS HEAD LOWERED
(FORWARD) TO REDUCE THE RISK OF ASPIRATION.
INHALATION: REMOVE VICTIM TO FRESH AIR AT ONCE. IF BREATHING IS DIFFICULT, ADMINISTER SUPPLEMENTAL OXYGEN. IF BREATHING
HAS STOPPED, ADMINISTER ARTIFICIAL RESPIRATION. SEEK IMMEDIATE MEDICAL ATTENTION. PROVIDE SUPPORTIVE TREATMENT, KEEPING
VICTIM WARM AND QUIET.
HEALTH 1
4.2 Medical Conditions Aggravated by Exposure:
NONE EXPECTED, WHEN USED AS INTENDED.
FLAMMABILITY 1
REACTIVITY 0
PROTECTIVE EQUIPMENT B
EYE SKIN
Page 3 of 5
MATERIAL SAFETY DATA SHEET MSDS WP-003
Prepared to OSHA, CMA, ANSI and WHMIS Standards MSDS Revision Date 11/01/2000
5. FIREFIGHTING MEASURES
5.1 Flashpoint & Method:
257掳F (COC)
5.2 Autoignition Temperature:
NA
5.3 Flammability Limits: Lower Explosive Limit (LEL): NA Upper Explosive Limit (UEL): NA
5.4 Fire & Explosion Hazards:
RED = FLAMMABILITY
LOW FIRE HAZARD. PRODUCT WILL NOT READILY IGNITE BUT IS COMBUSTIBLE. FOAM BLUE = HEALTH
AND WATER MAY CAUSE FROTHING WHICH CAN INCREASE THE INTENSITIY OF THE FIRE. YELLOW = REACTIVITY
1 WHITE = SPECIAL MEASURES
5.5 Extinguishing Methods:
1 0
CARBON DIOXIDE, DRY CHEMICAL, AND FOAM. 0 = NO HAZARD
1 = MINIMAL HAZARD
5.6 Firefighting Procedures:
2= SLIGHT HAZARD
REMOVE CONTAINERS FROM FIRE DANGER AREA IF SAFELY POSSIBLE. PREVENT RUNOFF 3 = MODERATE HAZARD
4 = SEVERE HAZARD
FROM FIRE CONTROL OR DILUTION FROM ENTERING STREAMS, SEWERS, OR DRINKING
WATER SUPPLY. FIRE FIGHTERS SHOULD WEAR FULL-FACE, SELF-CONTAINED BREATHING
APPARATUS (MSHA/NIOSH APPROVED OR THE EQUIVALENT) AND IMPERVIOUS
PROTECTIVE CLOTHING WHENEVER FIGHTING FIRES INVOLVING CHEMICALS.
6. ACCIDENTAL RELEASE MEASURES
6.1 Spills:
ELIMINATE ALL POSSIBLE SOURCES OF IGNITION AND PROVIDE MAXIMUM VENTILATION. STOP LEAK OR SPILL IF SAFELY POSSIBLE. SECURE
SPILL AREA AND DENY ENTRY TO ALL UNPROTECTED INDIVIDUALS. IF SPILL IS SMALL, COVER WITH APPROPRIATE INERT ABSORBENT AND
PLACE INTO CLOSED CONTAINERS FOR PROPER DISPOSAL. IF THE SPILL IS LARGE, COVER ALL DRAINS AND DIKE WELL AHEAD OF THE SPILL
AREA TO PREVENT RUNOFF INTO DRAINS, SEWERS AND ALL WATERWAYS. RECOVER FREE LIQUID FOR RECYCLING OR DISPOSAL. USE
NON-SPARKING, EXPLOSION-PROOF EQUIPMENT. CONTACT APPROPRIATE LOCAL, STATE, AND FEDERAL AUTHORITIES FOR ASSISTANCE
OR REPORTING REQUIREMENTS.
7. HANDLING & STORAGE INFORMATION
7.1 Work & Hygiene Practices:
WASH HANDS THOROUGHLY AFTER USING THIS PRODUCT AND BEFORE EATING, DRINKING OR SMOKING.
7.2 Storage & Handling:
USE AND STORE IN A COOL, DRY, WELL-VENTILATED AREA AWAY FROM EXCESSIVE HEAT, SPARKS, OPEN FLAMES AND OTHER POSSIBLE
SOURCES OF IGNITION. DO NOT STORE IN UNMARKED OR OPEN CONTAINERS. PROTECT CONTAINERS FROM DAMAGE OR TIPPING.
7.3 Special Precautions:
READILY AVAILABLE EMERGENCY FIRE, MEDICAL AND SPILL RESPONSE EQUIPMENT OR MEASURES ARE RECOMMENDED.
8. EXPOSURE CONTROLS & PERSONAL PROTECTION
8.1 Ventilation & Engineering Controls:
GENERAL MECHANICAL VENTILATION IS SUFFICIENT UNLESS SPRAYING OR MISTING OPERATIONS ARE TAKING PLACE. FOR THESE
OPERATIONS, LOCAL EXHAUST AND NIOSH CERTIFIED RESPIRATORY PROTECTION IS RECOMMENDED.
8.2 Respiratory Protection:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA's 29 CFR 1910.134 AND ANSI Z88.2 REQUIREMENTS MUST BE FOLLOWED
WHENEVER WORKPLACE CONDITIONS WARRANT A RESPIRATOR'S USE.
8.3 Eye Protection:
SAFETY GLASSES SHOULD BE MANDATED FOR USE WITH THIS PRODUCT, AS A MINIMUM. IF SPLASHING OR MISTING IS ANTICIPATED,
SPLASH GOGGLES OR A FACESHIELD IS RECOMMENDED.
8.4 Hand Protection:
WHERE CONTACT IS LIKELY, IMPERVIOUS GLOVES ARE RECOMMENDED. DO NOT WEAR RINGS, WATCHES OR JEWELRY WHICH COULD
ENTRAP THE MATERIAL AGAINST THE SKIN.
8.5 Body Protection:
FULL CHEMICALLY RESISTANT PROTECTIVE CLOTHING SHOULD BE USED WHENEVER SPLASHING IS ANTICIPATED
Page 4 of 5
MATERIAL SAFETY DATA SHEET MSDS WP-003
Prepared to OSHA, CMA, ANSI and WHMIS Standards MSDS Revision Date 11/01/2000
9. PHYSICAL & CHEMICAL PROPERTIES
9.1 Density: VAPOR IS HEAVIER THAN AIR
9.2 Boiling Point: ND
9.3 Melting Point: NA
9.4 Evaporation Rate: ND
9.5 Vapor Pressure: ND
9.6 Molecular Weight: NA
9.7 Appearance & Color: RED OILY LIQUID
9.8 Odor Threshold: CHARACTERISTIC ODOR
9.9 Solubility: INSOLUBLE
9.10 pH NEUTRAL
9.11 Viscosity: 25-35 CST @ 40掳C
9.12 Other Information: NA
10. STABILITY & REACTIVITY
10.1 Stability: STABLE UNDER NORMAL CONDITIONS.
10.2 Hazardous Decomposition Products: NOT DETERMINED, PER THE MANUFACTURER.
10.3 Hazardous Polymerization: WILL NOT OCCUR.
10.4 Conditions to Avoid: OPEN FLAMES, SPARKS, HIGH HEAT AND PROXIMITY TO INCOMPATIBLE SUBSTANCES, IGNITION
SOURCES AND HEAVILY TRAFFICKED AREAS.
10.5 Incompatible Substances: STRONG OXIDIZERS
11. TOXICOLOGICAL INFORMATION
11.1 Toxicity Data: LOW DERMAL AND ORAL TOXICITY FOR NORMAL INDUSTRIAL AND COMMERCIAL USE. HOWEVER,
SWALLOWING THIS MATERIAL MAY CAUSE MOUTH AND GASTROINTESTINAL IRRITATION. DIRECT CONTACT
MAY CAUSE EYE AND SKIN IRRITATION. INHALATION MAY CAUSE UPPER RESPIRATORY IRRITATION.
11.2 Acute Toxicity: SEE SECTION 3.5
11.3 Chronic Toxicity: SEE SECTION 3.6
11.4 Suspected Carcinogen: ND
11.5 Reproductive Toxicity: NA
Mutagenicity: NA
Embryotoxicity: NA
Teratogenicity: NA
NA
Reproductive Toxicity:
11.6 Irritancy of Product: MILD
11.7 Biological Exposure Indices: NA
11.8 Physician Recommendations: APPLY GENERAL SUPPORTIVE MEASURES. TREAT SYMPTOMATICALLY.
12. ECOLOGICAL INFORMATION
12.1 Environmental Stability: NA
12.2 Effects on Plants & Animals: ECOTOXICITY: NO INFORMATION AVAILABLE
12.3 Effects on Aquatic Life: ENVIRONMENTAL FATE: NO INFORMATION AVAILABLE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO
SEWERS/WATER SUPPLIES.
13. DISPOSAL CONSIDERATIONS
13.1 Waste Disposal:
MATERIAL, IF DISCARDED, IS NOT EXPECTED TO BE A CHARACTERISTIC HAZARDOUS WASTE UNDER RCRA. DISPOSE OF IN ACCORDANCE
WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS. RECYCLING OR RECLAMATION IS RECOMMENDED.
13.2 Special Considerations:
ENCLOSED - CONTROLLED INCINERATION IS RECOMMENDED UNLESS DIRECTED OTHERWISE BY APPLICABLE ORDINANCES.
Page 5 of 5
MATERIAL SAFETY DATA SHEET MSDS WP-003
Prepared to OSHA, CMA, ANSI and WHMIS Standards MSDS Revision Date 11/01/2000
14. TRANSPORTATION INFORMATION
The basic description (proper shipping name, hazard class & division, ID Number, packing group) is shown for each mode of transportation.
Additional descriptive information may be required by 49 CFR, IATA,/ICAO, IMDG and the CTDGR.
14.1 49 CFR (GND):
NOT REGULATED BY THIS MODE
14.2 IATA (AIR):
NOT REGULATED BY THIS MODE
14.3 IMDG (OCN):
NOT REGULATED BY THIS MODE
14.4 TDGR (Canadian GND):
NOT REGULATED BY THIS MODE
15. REGULATORY INFORMATION
15.1 SARA Reporting Requirements:
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES SUBJECT TO SARA REPORTING REQUIREMENTS.
15.2 SARA Threshold Planning Quantity:
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES WITH A SARA THRESHOLD PLANNING QUANTITY.
15.3 TSCA Inventory Status:
ALL CHEMICAL SUBSTANCES OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY OR ARE EXEMPT FROM INVENTORY STATUS.
15.4 CERCLA Reportable Quantity (RQ):
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES WITH A CERCLA REPORTABLE QUANTITY.
15.5 Other Federal Requirements:
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES WITH OTHER FEDERAL REQUIREMENTS.
15.6 Other Canadian Regulations:
ALL CHEMICAL SUBSTANCES OF THIS PRODUCT ARE LISTED ON THE CEPA DSL/NDSL OR
ARE EXEMPT FROM LIST REQUIREMENTS. THIS PRODUCT HAS BEEN CLASSIFIED
ACCORDING TO THE HAZARD CRITERIA OF THE CPR AND THE MSDS CONTAINS ALL OF
THE INFORMATION REQUIRED BY THE CPR.
15.7 State Regulatory Information:
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES LISTED AS A CALIFORNIA PROPOSITION 65 CARCINOGENIC OR REPRODUCTIVE
HAZARD.
16. OTHER INFORMATION
16.1 Other Information:
NA
16.2 Terms & Definitions:
SEE ATTACHMENT
16.3 Disclaimer:
This Material Safety Data Sheet is offered pursuant to OSHA鈥檚 Hazard Communication Standard, 29 CFR 搂1910.1200. Other
government regulations must be reviewed for applicability to this product. To the best of ShipMate's & Worldpac's knowledge, the
information contained herein is reliable and accurate as of this date; however, accuracy, suitability or completeness are not
guaranteed and no warranties of any type, either expressed or implied, are provided. The information contained herein related only
to the specific product(s). If this product(s) is combined with other materials, all component properties must be considered. Data
may be changed from time to time. Be sure to consult the latest edition.
16.4 Prepared for:
WorldPac, Inc.
37137 Hickory Street
Newark, CA 94560
510-608-5525 phone
510-742-9262 fax
http://www.worldpac.com/
16.5 Prepared by:
ShipMate, Inc.
1810 Green Lane
Redondo Beach, CA 90278-3618
310-798-4200 phone
310-798-4339 fax
http://www.shipmate.com/
|